2022 FORD EXPEDITION Complaints

I am submitting a formal consumer complaint regarding a persistent brake issue—specifically a loud squeal when coming to a stop in a 2022 Ford Expedition Max Limited purchased as a Certified Pre-Owned vehicle through Ford’s Blue Advantage Program. At the time of sale, I was assured the vehicle met certification standards, had no unresolved safety concerns, and that any recalls had been addressed. However, I later learned that Safety Recall 25S47 (NHTSA Campaign 25V-314) had been issued in May 2025—one month prior to purchase—for a front brake line defect that may cause brake fluid leaks, reduced braking performance, and increased crash risk. Despite this, the vehicle was certified and sold with representation that the recall showed “no concern.” Since purchase, the vehicle has exhibited constant brake squealing, worsening stopping performance, and reduced responsiveness. The issue occurs at every stop and persists despite replacement of front and rear brake pads and rotors. Timeline: • Apr 2024 – Prior brake-related service • May 9, 2025 – Recall issued • June 4, 2025 – Brake service prior to sale • June 14, 2025 – Purchased as certified • Within 1 week – Issue reported • June 25, 2025 – Inspection found “no concern” • July 2025 – Pads/rotors replaced • Within 2–3 months – Issue returned • Ongoing – Condition deemed “within guidelines” Multiple attempts to resolve this through the dealer, a consumer complaint organization, a state regulatory complaint, and a manufacturer repair case have not resulted in a fix. This raises concern that a vehicle with a known safety-related defect was certified and sold without proper resolution. I request investigation into whether certification standards were properly followed and whether consumer protection requirements were violated. I am seeking a permanent manufacturer-backed repair, repurchase, or other appropriate relief.

The contact owns a 2022 Ford Expedition. The contact stated that while driving approximately 75 MPH, the sunroof windscreen flew off and landed on the highway. The vehicle was taken to a dealer, where it was determined that the sunroof windscreen needed to be replaced. The vehicle was repaired; however, the failure reoccurred approximately five months later. The contact stated that while driving approximately 75 MPH, the sunroof windscreen flew off onto the highway again. The vehicle was taken to the same dealer, where it was determined that the sunroof windscreen needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 32,065.

The contact owns a 2022 Ford Expedition. The contact received notification of NHTSA Campaign Number: 26V204000 (Visibility); however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

Harsh shifting in relation to TBS 23-2250 causing the vehicle response to be unpredictably unsafe merging or suddenly stopping or accelerating.

The contact owns a 2022 Ford Expedition. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while depressing the accelerator pedal, the vehicle hesitated before accelerating to the intended speed. The dealer was contacted and confirmed that the part to do the recall repair was not available. The manufacturer was not made aware of the issue. The failure mileage was unknown.

My vehicle shutters like it’s is going to die/shit off. When will this issue be resolved with the fuel pump system failure? I will be doing some research with the BBB to find out if this will be an actionable lawsuit. Most consumers who own these types of SUVs are mothers! This needs to be resolved asap!

Ford has a recall on the low pressure fuel pump but no fix yet. My fuel pump failed and I am being charged to fix it. But that also puts me back on the road with an unsafe vehicle. They will not provide me a rental until the recall has a solution or fix.

Receiving Front Camera Malfunction Service required warning. Also receiving pre-collision assist, adaptive cruise control and automatic emergency break system warnings. Other systems likely disabled. Found that there was a TSB issued for the same year but on the F-150. DTC's C1001:31, U3000:89, U3000:49. This issue is likely caused by faulty cable connections where condensation has caused corrosion making the system inoperable thus creating a major safety issue for owners. I took the Expedition to SawGrass Ford in Sunrise FL and they confirmed that the issue was due to the electronics/cables. The camera itself was not dirty or blocked. They charged me $250 for a diagnostic and then wanted to charge me $2500+. For the safety and security of all owners please investigate and hold FORD accountable for this.

All of the Advanced Drivers Assistance Systems are not functional. Ford is aware of problem and the fix is continuing to be delayed--over 1 year now. Vehicle has been to dealership multiple times without solution.

Transmission has known issue by Ford Motor Company concerning defective components leading to wear and improper function causing potential safety issues with acceleration and deceleration. My vehicle, I purchased used with 32k miles in April of 2025. I started to have issues with shifting approximately 6 months ago when it would shift erratically when cold and when vehicle was not warmed up. On several occasions the vehicle, when shifted into reverse to back out of a parking space, the vehicle hesitates and drops harshly into reverse. This has occurred at least 4 times within the last 3 months. The next issue is when the vehicle is initially started up in the morning and placed into gear to leave my driveway I pull out and it appears to be operating fine. When the transmission goes to upshift it will shift on the gauge screen indicating it is in 3rd gear but either I have no gear and the engine will rev without acceleration, or as in the last circumstance, it will shift to 3rd, jump to 8th gear, and have no accelerator input for approximately 5-10 seconds. The shift indicator shows the transmission then shifts from 8th, to 5th, then down to 3rd and drops harshly into gear and proceeds operation as normal. The transmission will not shift as smoothly as it does when it is warm for approximately 3-5 miles. This type of operation has been identified as being contributed to the interior components of the 10R80 transmission. In particular, the CDF clutch is identified in the TSB for this issue 23-2250. I have had my vehicle at the Ford dealer on 2 occasions for this issue and they have not been able to replicate the issue. I was advised the 2nd time that the service technician stated the transmission was low 2 quarts of fluid and they were unable to get the transmission to replicate the harsh shifting condition. This vehicle was serviced less than 2 months prior and no indication of low fluid was noted in the transmission at the time of service.