2020 FORD EXPEDITION Complaints

The contact owns a 2020 Ford Expedition. The contact stated while driving at various speeds and attempting to steer the vehicle, the steering wheel would oversteer the vehicle. There were no warning lights illuminated. The vehicle was taken to a mechanic where it was diagnosed that the power steering was overcompensating while steering the vehicle. The mechanic stated that the failure was related to NHTSA Campaign Number: 24E055000 (Steering). The mechanic contacted the dealer and confirmed that the VIN was not included in the recall. The manufacturer was made aware of the failure. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 50,000.

Transmission started shifting hard (into and out of park to drive) and (between 3-4 and 7-8 gears). I brought my concerns to the dealership at the end of 2023 and asked if it could be reprogrammed. The advisor stated that the transmission was going bad and to just keep driving it until it failed because they are seeing a lot of failures. In July 2024 we pulled onto the highway when we attempted accelerate the engine revved to redline and the vehicle stopped accelerating. When the gas pedal was lifted the transmission started grinding back into gear. We had to slowly push the gas pedal down to get it home at 30mph. Every time it downshifted it would stop accelerating. Ford did a complete transmission replacement. I also have a 2019 F150 [XXX] ) with 79000 miles on it and it is now showing the same signs of failure with shifting. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

From early on, the vehicle had a hard shift from 7 to 8. This was discussed with the dealership and they claimed they couldn’t recreate it. This has been the life of the vehicle. About 6 months ago it began to hard shift in other gears. 3 to 4 being the most common. Then 2 months ago it would slow down, you could hear grinding, then jerk violently forward (finally getting into gear). When we called the dealership to ask they said they would have to look at it. But it was not consistent enough. The vehicle eventually began to slip from gear and jerk forward into gear, everyday. Almost causing me to be rear ended multiple times. Loosing speed at anytime and causing random speeds with the inability to regain speed until the car “found” a gear. I would be driving 60 mph and it would find a lower gear and jerk into gear. It needs a whole new transmission. FORD is aware of this issue with the 10R80 transmission. 3.5 eco boost. My car is un driveable now. It fails to find a gear. A quick Google search will showcase exact stories just like mine with people saying the exact same thing. Harsh shifting. Jerking. Grinding. Loosing speed while driving. FORD didn’t have a fix for anyone. And now new transmissions are the only fix. Please inspect.

The contact owns a 2020 Ford Expedition. The contact stated the windshield wipers were intermittently inoperable. Additionally, the contact stated that while attempting to drive from a complete stop at night, the vehicle failed to respond. The contact stated that the vehicle failed to turn off and was drivable after 15 minutes. The vehicle was driven to a parking spot. The vehicle was then taken to the dealer, where it was diagnosed that the windshield washer line located on the front passenger's side and on the rear windshield had exploded due to washer fluid accumulation. The dealer informed the contact that the failure caused the windshield washer fluid and freon to leak into the dashboard module and onto the front passenger's side floorboard. The dealer repaired the R and R BCM, reprogrammed the RCM communication circuit and the BCM, and installed the Alarm-KE and the R and R auxiliary evaporator cord. The vehicle was repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 68,305.

The 2020 Ford expedition has transmission issues. It will slip gears in the middle of driving, it will stall when trying to change gears from park to reverse to drive. When accelerating the vehicle will rev up in RPMs and drastically drop speed I’ve had to almost come to a complete stop on the interstate driving 70+ miles an hour. There were no lights or warnings that appeared on the dash. We took it to a mechanic to have it inspected and we were told that we need to replace the entire transmission. We contacted the Ford dealer in which we purchased it from and they are not willing to address the issue. I am a mother of four children, and I’m regularly driving in the vehicle to take them to and from school and various activities. I am very concerned about the safety of myself as well as my children. Should we be driving and the transmission completely shut down. Since having the vehicle looked at by a mechanic, the warning signs have now turned on and appear every time I start the vehicle.

The contact owns a 2020 Ford Expedition. The contact stated while driving 65 MPH, the driver's side seat belt became inoperable. There was no warning light illuminated. The contact stated that the seat belt would lock but would not retract until the vehicle was turned off. The vehicle was taken to the dealer where it was diagnosed and determined that the seat belt retractor tensioner had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The failure mileage was approximately 65,000.

The contact owns a 2020 Ford Expedition. The contact stated that the transmission was shifting hard. The contact stated that while driving 70 MPH, the vehicle jerked and shifted hard on several occasions. The contact stated that the Pre-Collision Assist warning light was flashing. There was an abnormally loud sound detected. The contact stated that the failure was related to TSB: 23-2123. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The contact called another local dealer, Max Ford of Harrisonville (2502 Cantrell Rd., Harrisonville, MO 64701); but the vehicle was not diagnosed or repaired. The manufacturer was contacted, but no additional assistance was provided. The failure mileage was approximately 70,000.

The contact owns a 2020 Ford Expedition. The contact stated while driving at an undisclosed speed, the transmission unexpectedly downshifted. There was no warning light illuminated. The vehicle was restarted; however, the failure recurred. The vehicle was taken to be diagnosed. The contact was informed that the transmission had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 66,000.

On multiple occasions, our car has lurched out of gear going at fast speeds on the highway. It slips out of gear and the car shakes and then it lunges back into gear. On a few occasions, the gas pedal was also inoperable while the car was "finding the right gear". This has been extremely scary for my family when this has happened. The first time we took it to the dealership and they reprogrammed the transmission. Then, it happened again about 6 weeks after the fix, and this time the transmission valve had to be replaced.

The vehicle was in park, with the engine running. The tailgate was open as I was loading a stroller into the back and my infant into a back passenger seat car seat. The driver's door was open, back drivers side door open, and tailgate open. The front passenger's seat belt pretensioner deployed and it sounded as though something hit the vehicle. I walked around the car to inspect for damage and even looked on top of the vehicle for damage. No damage occurred as nothing hit the vehicle. My wife got into the car in the front passenger seat and could not move the seat belt. I walked around and verified that it could not be moved as it was in the rest position with the pre-tensioner deployed. Issue: Non-event with front passenger seat belt pre-tensioner deployment Available to be inspected: Yes Safety at risk: My wife just had a c-section and if deployed with her in it, would have been much worse. Additionally, cannot use the seat now that seat belt is inoperable. Issue been reproduced: No. The pre-tensioner goes off with explosive charge making reproduction impossible. Warning lamps present: No.