2018 FORD EXPEDITION Complaints

The cam shafts are not function correctly and need to be replaced which is causing the engine to overheat. The heater hose blew while we were driving the other day and engine temperature went to almost 300. The catalytic converter is also not functioning which is releasing emissions when we drive. The overheating engine could cause a fire while driving and the we all know about the emissions procedures. The vehicle has been inspected by the correct dealership. The warning light did come on and we took it into the dealership within the week. We also heard a knocking in the engine when we cold started the car. The engine light was not on when the heater hose blew due to the faulty cam shafts.

The contact owns a 2018 Ford Expedition. The contact stated that he had taken the vehicle to the dealer on four separate occasions due to moisture leaking from the panoramic sunroof. Due to the failure, the roof headliner needed to be replaced a second time. The contact stated that the panoramic sunroof had never been used and had remained covered. The manufacturer had been notified of the failure and referred him to the NHTSA Hotline. The vehicle was not repaired. The failure mileage was approximately 20,000.

Rear passenger door will not open from the outside even in the unlocked position. It is still locked and cannot be opened from the inside or the outside. We have children that require the use of safety seats. in the event of an accident, we cannot remove them from the back seats. We have to climb from the front seats to the back just to get them out of the car. I have not been to the dealer but, the problem is still not resolved. No one has inspected the vehicle. There were no warning signals whatsoever. i consider this a major problem in the event of an accident. Not being able to get out or have help open the door from the outside will put lives at risk.

There is a recall on many 2018 CAM Phasers. My vehicle has the same issue with the recalls on many 2018 Expeditions that also effect the EPA ratings. For some reason FORD says the Recall is not my vehicle but they knew their was an issue and the FORD dealership tried to do a software update but the issue was never cured. They never performed the needed next step remediation. The ongoing CAM phase issue cause engine light to stay on. This has been going on with them for several years. They never would do the part 2 cure.

RPMs rev up as the truck is changing gears- engine stalls which causes an abrupt halt. I have to let off the gas for the gears to catch up. Several mechanics have looked and there are no codes. This is a very dangerous situation as I am on the road several hours a day for my job. It is especially scary when my children are in the car. Apparently, this is very common with the 2018 Ford models and NOTHING is being done!!!!!! Ford will be sued if this causes an accident d/t no my fault of my own. THIS NEEDS TO BE ADDRESSED ASAP!!!!!!!!!

Door locks don’t unlock on 3 out of 4 doors. Transmission jerks and acts like losing power frequently. Engine tries to die at idle when stopping. Timing chains failed along with cam phasers yet symptoms still continue. Heater hoses leak to heater core. This caused high temps of 255 degrees to occur for engine.

Front Blower motor not working correctly. Engine Valve cover driver side small crack.

No Brakes, Engine Racing, & ignition would not turn off, yes available for inspection at Seth Whatley Ford. Car crashed which was the only way it came to a stop, wheels were still turning when I got out of the car, if anyone one had been around they would have been hurt or killed. Towed to dealer, dealer was unable to find any evidence on their side. Insurance adjuster came out and assess the damage from crash. There was no warning lights or sensors that were working during this episode. Monday, March 27, 2023 at approximately 10am, I got into my Expedition to start my vehicle, the brake pedal was depressed as I pushed the button to start the car, and the engine was running smoothly. Foot was on the brake pedal when I put the car into reverse, the car shot out from the carport and engine was racing. I tried to pump the breaks and push the engine button, while guiding the car as it kept going faster and faster, until I hit a trailer that was attached to a truck. There was two witness that saw everything, that went on. I feel this car is DANGEROUS. If this had occurred when my family was around serious injuries could have occurred, or if I had been in a parking lot, there was no way to stop and I was not in control. Safety is the first issue. Special Note - I took my car in February 2022 for the recall.

The contact owns a 2018 Ford Expedition. The contact stated that the dealer had previously serviced the vehicle under an unknown recall for engine rattle on cold start; however, the failure recurred after the recall repair was performed. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure. The failure mileage was approximately 16,000.

The contact owns a 2018 Ford Expedition. The contact stated that upon starting the vehicle, a rattling sound was coming from the vehicle. There was no warning light illuminated. The contact took the vehicle to the dealer and was informed that the cam phaser needed to be replaced. The manufacturer was also notified of the failure and informed the contact that there were no recalls associated with the VIN, and that the warranty on the vehicle had expired. The contact was referred to the NHTSA Hotline for assistance. The vehicle was not repaired. The failure mileage was approximately 57,000.