2018 FORD EXPEDITION Complaints

Panoramic sunroof stuck in open position. Will not close without multiple failed attempts. When closing the sunroof makes a cracking and grinding noise. This issue has been identified by Ford, however my VIN does not currently fall under the open recall. Therefore, Ford will not cover the repair. Details of existing recall are below… Ford TSB 18-2374 Some 2015-2019 F-150, 2017-2019 F-Super Duty, 2018-2019 Expedition/Navigator vehicles equipped with a vista roof opening panel may exhibit a binding/sticking, glass stuck open or closed, noisy operation including chatter, rattling, or grinding. This may be due to the glass brackets cracking and/or breaking apart. The glass panel brackets are serviceable separately from the frame assembly and require the roof opening panel glass to be moved to the vent position. Follow the Service Procedure steps to correct the condition.

Powertrain/ Transmission required replacement. Replacement transmission from the factory deemed defective and suffered a catastrophic failure in less than 24 hours after install.

Something is going on with the transmission we got it at dealer now it shifts funny 3 to 4 and 6to8 and sometimes you go to pull out and it revs up to 3000 rpm and don't move then it slam in gear and move and not all the time but sometimes you slow down you hear a crunching noises under expedition. If you stop fast it down shifts hard and if you go to move again it's like it's in a high gear it never shifted down .it's a 2018 10 speed transmission and if you read online ford has problems with them so why is it not a safety recall on this transmission before someone pulls out somewhere and gets kill because it won't move . It's a problem not a accident

While my wife and I were driving with passengers, I accelerated from the on ramp to enter the right lane of an interstate. I had to take my foot off of the gas pedal for maybe 1 second as the sight line became better. When I pressed the gas pedal to accelerate into the lane, NOTHING, no power at all for at least 3 seconds. Alarmed, I released pressure on the gas pedal and tried again, this time the engine and transmission engaged. Having no power in response to pressing the gas pedal was dangerous and frightening in that situation, particularly as there were cars that were closing in from behind in hat lane. This situation occurred a second time in almost the exact same sequence within a week. I thereafter took the vehicle to a Ford dealer. They advised there were no reports in their database and no procedures for the failure. AFTER reviewing how dangerous the event was, the dealer chose to reprogram the control for a charge, invoice and my note thereon is attached. The power failure was complete, as if there were no engine nor transmission. After the reset by Ford there was a different single incident with the powertrain which seems unrelated. While driving in a local town my wife took her foot off the gas pedal but the vehicle continued to accelerate. She braked after which the transmission appeared to "shift" and "reset" and thereafter acted normally. In none of the events was the cruise control engaged, in fact we rarely, if ever use it. The first incident was in July on a family trip, the next early August and after the reprogramming the last incident was the week of October 17, 2022.

The contact owns a 2018 Ford Expedition. The contact stated that while starting the vehicle and driving at an undisclosed speed, the vehicle made rattling sounds. The vehicle was taken to the dealer where it was diagnosed that the failure was related to Customer Satisfaction Program: 21N08 (PCM Reprogram Due To Engine Shudder) and that the cam phaser also needed to be replaced. However, the dealer informed the contact that the manufacturer declined the repair due to the vehicle's salvage title. The manufacturer was made aware of the failure and declined the replacement part due to the salvage title. The failure mileage was approximately 48,000.

At approximately 30,000 the vehicle's suspension failed, leading to a very rough ride like a boat hitting waves, and at speed affects the ability to control the vehicle. The Ford dealer advised that all shocks needed replacing. The problem developed gradually over about six months. These or the original shocks on the vehicle, and their early failure is a defect and safety concern.

The contact owns a 2018 Ford Expedition. The contact stated while starting the vehicle, he heard a loud noise coming from the vehicle. The vehicle was taken to the dealer and the contact was informed that the cam phaser needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and informed of the failure however, no assistance was provided. The failure mileage was 83,000.

Power running boards switched from automatic to off position while driving vehicle and without warning to driver. Due to height of vehicle (20" wheels) and failure to deploy, injury occurred while attempting to exit vehicle. Ford took over two weeks to determine problem and cost owner approximately $1400 to repair as vehicle was no longer under warranty. Vehicle had less than five thousand (5,000) miles.

While coming to a stop, or already stopped with the Auto Start/Stop system engaged, the vehicle will completely shut down and the message "Auto StartStop Shift to P, then Restart Engine" pops up. After doing that the engine restarts normally. AGM battery was recently replaced and engine starting is strong. This has happened around 3-4 times in the last few weeks, and normally occurs when the engine is still cold in the first couple miles of driving (although temps have been very mild, in the 60's or 70's). I have tried contacting two Ford dealers in my area but both have been unresponsive. One said they can't even take appointments related to powertrain in the next several months and the other will not call me back after leaving repeated messages. Thankfully this has only occurred while stopped or coming to a stop in traffic, but could also happen while making a turn into oncoming traffic.

my transmission shifted from first gear to second gear very hard causing the vehicle to lunge. My daughter is a new driver and it scared her so much that she stopped in traffic at a stop sign and I thought the vehicle was hit. my dash cam even recorded it as a possible collision (no one hit us just jerked that bad). I have only owned it for a month and when I took it to the dealer that I bought it from they said Ford knows they have a problem and it sucks. (dealerships words) I had no lamps or warnings come on at the time of the event. when I changed driving modes the vehicle went completely out of gear and would not go back into gear until I shut it down and started it back up.