2017 FORD EXPEDITION Complaints

When I recently got tires rotated my vendor (not the car manufacturer) informed me there are known problems with lug nuts on Ford Expeditions; that apparently something about two-layer metal causing swelling and difficulty for tire repair shops to effectively remove them which causes (to a degree) stripping of them. Tire shop employee informed me and also showed me the result after they rotated and you can tell there is an issue.

The rear shocks/struts have each failed twice so far. I have had both replaced once, and the rear passenger side replaced through Ford. I am being told by El Cajon Ford the rear driver's side needs to be replaced again (and the passenger side also because they are supposed to be changed at the same time. I have the Platinum warranty for Ford, which covers the MacPherson Strut (which is what my vehicle has on the rear, it does not have individual shocks). I have had the vehicle less than 4 years, and am looking at putting the 5th set of shocks on the vehicle. For clarification, the MacPherson strut has a shock as part of its assembly. It is not a separate unit, it is a component of the MacPherson strut.

Breakfast fluid leaking, brake fluid light on. Found brake master cylinder leaking inside of brake booster.

Brakes failed while driving. Mechanics found all brake fluid leaked internally from master cylinder into the brake booster. I have another Ford vehicle that was recalled for this exact problem in 2017.

Car stops accelerating at various speeds on numerous occasions, and cannot get vehicle to propel. No propulsion occurs. Must bring vehicle to complete stop, turn off, and turn back before it will accelerate. Large wrench appears on screen, but disappears after the car is restarted. Safety issue because you cannot maintain speed or accelerate, was almost rear-ended and created potential accident trying to pull vehicle over. Took two visits to the authorized dealer to diagnose the problem as their was no "code" apparent to dealer, and was almost rear ended in between those visits. Vehicle owner quickly googled problem and noticed that N. Carolina Consumers Council had successfully petitioned NHTSA for this issue on other Fords, but that recall appears not to have included these Expeditions. Dealer replaced the throttle body.

Wife started car. Pushed on the brake to put it in gear. Brake pedal went to floor. Checked master cylinder. Cylinder was completely empty. Brake fluid leaked past seals in master cylinder into the brake booster, then got sucked into engine and burned. No warning lights came on at all.. Luckily wife was at the pool down the road from our house when it happened. She drove 5 mph back to the house. A four year car should not have a faulty brake master cylinder. Master cylinders should last for at least 10 years. Ford has a major problem brewing.

During a recent routine mileage based tire rotation and balance at an independent service center , the technician had difficulty placing the socket onto the lug nuts to remove them. He had to tap the socket wrench with a hammer to get the socket onto the nut. Tech illustrated where the lug nuts had swollen and he had seen this on other Ford vehicles. This factory lug nut is a 2-part assembly and swells over time to the point where a standard and factory supplied socket on the vehicle would not work properly if there was a situation where the tire needed to be changed .ie.. a flat on the side of the highway. This vehicle is less than 5 yrs. old... I purchased a complete new set of 24 lug nuts before leaving. A true safety issue of one being able to use the vehicle equipment to safely remove and replace a tire without concern over whether the socket will fit the lug nuts AND removing the lug nuts from the socket. I have opened a case with Ford.

TOTAL BRAKE FAILURE WHILE BACKING UP , ALMOST HIT ANOTHER VEHICLE, SHIFTED TO FORWARD TO AVOID ACCIDENT , LOSS OF BRAKE FLUID IN MASTER CYLINDER TO BRAKE BOOSTER. EXACT SYMPTOMS AS RECALL 20S31 WITH 2014 TO 2017 F150. THE EXPEDITION IS ON AF150 CHASSIS . ACCORDING TO DEALER NOT UNDER RECALL BUT PROBABLY SHOULD BE. OUT OF WARRANTY. REPAIRED ON MY DIME. REPLACED MASTER CYLINDER AND CLEANED BOOSTER. VEHICLE WAS IN MOTION AT TIME OF INCIDENT. JUST GLAD I WASN'T ON THE BOAT RAMP OR HIGHWAY

TL* THE CONTACT OWNS A 2017 FORD EXPEDITION EQUIPPED WITH COOPER TIRES, TIRE LINE: EVOLUTION H/T, TIRE SIZE: 275/65/R18, DOT NUMBER(S): UTYJ1J94120, UTYJ1J93720, UTYJ1J93320. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 21T002000 (TIRES). DISCOUNT TIRE (7920 W BELL RD, GLENDALE, AZ 85308) WAS MADE AWARE OF THE ISSUE HOWEVER, THE CONTACT'S WIFE WAS INFORMED THAT THE TIRES WERE NOT INCLUDED IN THE RECALL. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

I WAS DRIVING THE SUV AND ALL OF A SUDDEN THE ENGINE SEEMED TO SHAKE, THE RPM'S WENT UP AND THE CAR WOULD NOT ACCELERATE. THIS WAS ON A BUSY ROAD AND THANK GOD I WAS ABLE TO PULL OVER SAFETY. THE SUV WAS NOT ABLE TO MOVE AND WAS TOWED TO THE FORD DEALER. I WAS TOLD THE THROTTLE BODY PHYSICALLY LOOKED GOOD BUT THE ELECTRONIC IN IT WAS DYSFUNCTIONAL AND IT WOULD NEED TO BE REPLACED. THE COST WAS 755.93. THIS IS 2017 FORD EXPEDITION. CRAZY AND UNSAFE, WHAT INTERESTING WAS THE SERVICE TECH ASKED IF I CLEARED THE CODE P2112 FROM THE OBC. I SAID NO I DON'T KNOW HOW TO DO THIS. HE TOLD ME THEN THE CAR CLEARED THE CODE SO MAYBE THAT WHY IT CAN HAPPEN OVER AND OVER AGAIN. THE WAS A HISTORY OF P2112 BUT NO ACTIVE CODE. INTERESTING - SAFETY PROBLEM