2018 FORD EXPEDITION Complaints

Car doesn’t let me pump fuel at gas station and overfills even when the tank is empty. Gas leaks from the bottom of the car. Weird suction noise comes from the fuel filler neck. I was doing research and found that many people have this same problem with my car and there’s a recall for this but for the 2015-2016 models and not the 2017. It’s a recall on the evap system suction pump and code is 20Y6.

The contact owns a 2018 Ford Expedition. The contact stated while starting the vehicle to pull out of a parking lot, he heard an abnormal sound coming from the vehicle. There was no warning light illuminated. The contact was able to drive home safely. The vehicle was taken to the dealer to be diagnosed. The contact was informed that the cam-phaser needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 77,000.

Left front strut leaked and back two struts provide very minimal dampening, which combined created a dangerous situation when banking on the interstate and hitting minimal bumps. When on the interstate at 65-70mph, if any bumps (e.g., bridge/overpass joints) are driven over the truck bounces wildly 5-8 times and the body twists, making it feel as though the truck is on the limit of controllability.

During a routine trip on the highway, as I was trying to overtake a vehicle the SUV shifted from 10th gear to 1st and locked up the wheels. This left my vehicle unable to move for a few seconds while on the highway. I lost all throttle response, the vehicle lit up the wrench icon on the dash. The issue has been replicated at the ford dealership and there are currently 3 others in for repair for the same issue.

During a recent oil change at 14299 miles (04/28/2022), I was told that the rear brake pads were dangerously low and had to be replaced immediately. I previously had an oil change and inspection by the same dealership on 11/17/2021 (10986 miles) and 6/22/2021 at 8685 miles and the brakes were checked ok with no mention of any wear whatsoever. When I asked the service manager what could have caused such a rapid deterioration of the brake pads, I was given a shoulder shake and was told that they didn’t find a problem like calipers sticking and things just happen. This car new with only a couple hundred miles on it when we bought it from the same dealer. My concern is that, at this low mileage, I could have gone longer before I brought it in for an oil change and inspection and, if the pads were that bad, we could have been in a very serious accident. The dealership non-concern about the seriousness of the defect/problem is very concerning. The service facility was QuickLane at Jones Ford, 5757 Rivers Avenue, North Charleston, SC. THE CONSUMER BELIEVED THE USE OF THE CRUISE CONTROL WAS THE CAUSE OF THE BRAKE PADS' RAPID DETERIORATION.

When getting things out of the Rear Cargo area the Lift Gate has come down unexpectedly and hit Me in the head. Several times the Rear Lift gate randomly opens when exiting or entering the car. Has hit my spouse and has come close to hitting other person walking in back of the vehicle. The Lift Gate came open barely missing the vehicle parked behind it. Would of damaged both vehicles Renegade Super C $300,000 and the Ford Expedition $85,000 along with possibly pinning and injuring the person behind the vehicle. Took the vehicle to a Ford Dealer and they ran diagnostic tests and looked for any faults and found nothing. We feel like we are driving a ticking time bomb and just missing a bullet each time we go to use the vehicle. Need immediate attention-

Ford had a recall on this vehicle for Powertrain Control Module (PCM) Reprogram For Cam Phaser Rattle. I returned this vehicle to the dealer on 1/19/20 (37,830 miles on vehicle) the "VCT phasers" were replaced when the parts came in (2/2020). Earlier this month the same "rattle" started again. Returned to dealer on 4/11/22, they reprogramed (21B10) and said it was repaired. It was not and I returned the vehicle to the dealer on 4/19/22. Ford has identified the "rattle" as the same problem, however they are stating that they are NOT responsible because the vehicle is now "out of warranty" (96,229 miles). How does that happen that a vehicle recall that Ford fails to repair in the first place is now not their responsibility to repair?!!!

The door opened while driving due to the latch on the rear passenger door popped open. The door now will not stay latched closed. It just continues to stay open. My daughter could have fallen out of the car while we were driving because of this.

The lug nuts swell and thus disable the lug wrench or any standard socket from removal. This has prevented me from changing tire or brakes because I can't remove the wheel.

When trying to change a flat, the factory provided lug wrench would not go onto the factory lug nuts. I was able to get to the tire shop and was advised of an on going issue with the ford lug nuts “swelling “ which in turn would not allow me to remove them to change the tire. After further digging there seems to be many many complaints of this same issue. It was recommended to purchase new ones that were not a two piece design as the OEM Ford ones are. I was told that this could and most likely would continue to happen and could even cause the wheel to come off in worst case scenario. I had to pay 195 dollars for a new set cause I had no other choice being on the road and away from home or a dealership