2018 FORD EXPEDITION Complaints

Ford has issued an extended warranty for an issue that is clearly a manufacturing issue within their 3.5 ecoboost engine, currently their program is for the replacement of the cam phasers, but they only replace them if the vehicle is under 70k miles on it, if it's pass that mileage the cost goes to the customer, which seems unfair practice as ford have stated that there is a fault with their cam phasers in the engine, but don't have to do a full recall because they give an "extended" warranty which if the vehicle is pass a certain mileage and of no fault of the customer they are allowed to pass the fault to the customers for a factory problem. This issue should be of concern as it can cause the vehicle to go off time and the engine to lock up and cause accidents, harm or even death.

The auto start stop function failed to restart the engine in an intersection on three occasions. We entered the intersections waiting to make a left turn and the auto stop start turned the car off. When we picked up our foot off the break to complete the left turn and clear the intersection the auto stop start failed to restart the car. An error code came up that said "Auto Start/Stop Shift to P, then restart engine". We shifted to park and restarted the car to clear the intersection to blaring horns. Thankfully there wasn't an immediate need to clear the intersection due to oncoming traffic or we would have been clobbered.

Drivers door would not close. Took 10 months for the new door latch to get shipped to my local Ford dealer . They charged us $ 708.00 to do the repair .

The contact owns a 2018 Ford Expedition. The contact stated that she noticed fluid leaking from the rear of the vehicle while parked. The contact took the vehicle to the dealer where she was informed that the passenger’s side shock needed to be replaced. The contact had also taken the vehicle to an independent mechanic who confirmed the failure and gave her an estimate for the repair. The manufacturer was notified of the failure and a claim was filed. The contact was referred to NHTSA for assistance. The contact stated that she only does city driving and that a failure of this magnitude should not have happened this soon on a newer vehicle. The vehicle had yet to be repaired. The failure mileage was approximately 44,000.

Left front Strut was leaking at 7000, was replaced by ford. 12/6/2, the SUV has 27,800 miles and the same Strut is leaking again. The car is been only drive on city roads and freeway. I can see many people are complaining about the same issue.

Vehicle has less that 40,000 miles on it. It has become almost uncontrollable if you hit any rough spots on the road. During the last oil change it was noted the rear shocks and struts were bad as well as the front struts. This is far to early for a vehicle to have these issues. It has never been off-road and only towed a small trailer one time.

The aluminum caps on the lug nuts swell making them impossible to remove with the standard lug wrench. Rather than equipping the vehicles with quality single piece lug nuts instead they are cheap lugs nuts with flimsy caps that are prone to early and premature failure. When I got a flat tire I was unable to remove the lug nuts with the standard lug wrench provided. What should have been a straightforward 1/2 hour tire change ended up being an over 4 hour ordeal on the side of the road. The only way to remove the lugs nuts was with a damaged lug extractor tool which I did not have at the time. The only way to get the tire changed was pay for a tow and then have all 24 lug nuts removed and replaced with better quality single piece nuts at a specialty shop at my expense.

The transmission would slip and not go into gear. Causing me to stall in the middle of intersections. This occurred multiple times and if I took my foot off the gas it woudl catch and I could go again. Dealership told me it could be PCM issue and was not able to see me until December of 2021. At the end of October it suddenly became almost undriveable and was limped to dealership. It was determined that the gear ratio for the 3rd gear was incorrect and at 67,318 miles and 4 years old it needs a new transmission.

When I drove a little bit uneven highway overpass about 50mph with family, three teenagers and my wife, I saw the rear bounces back a lot, almost lost control of the vehicle. Next day, I took it to local Ford Service and they say the rear structs and shocks were completely worn out, and need to be replaced. It has only highway mileage of only just over 20,000miles. Actually they were talking about leaking of oil through the seals and technician showed all four struts were leaking, rears much worse. The vehicle just passed 3 year warranty period by two months, and technician suggested the leakage had been there long before the factory warranty expired. So disappointed with Ford. This was my first Ford and will be the last.

We have put roughly 20,000 miles on this vehicle and were putting new tires on, when the technician showed me that all four struts were leaking. This vehicle is not driven excessively, it is primarily for short trips around the city and is not used in heavy traffic. A quick search identifies that this is a known issue, with multiple people identifying there concern. There are multiple several complaints on the NHTSA website. So after paying out of pocket, I called Ford to see if they would offer reimbursement. I received a call back from an extremely rude individual informing me that Ford will not reimburse me because there are no active recalls. After I explained that there are multiple complaints about this same issue she stated that Ford does not issue recalls and only the NHTSA will do that. Therefore, I am requesting the NHTSA look into this issue.