2002 FORD EXPEDITION Complaints

SPARK PLUG SHOT FROM ENGINE. HAS 112500 MILES ON SUV. WAS ICE AND SNOW ON BACK ROAD 30 MILES FROM HOME AT 14 DEGREES. SOUNDED LIKE ENGINE BLOWING UP. THEN LOAD PING SOUND IN MOTOR AND LACK OF POWER. ENGINE SHUT OFF ON IDLE. WAS STUCK. HAVE NOT SERVICED YET. FORD NEEDS TO FIX THIS ISSUE IMMEDIATELY. THIS 5.4 L TRITON SHOULD RUN FOR LONGER THAN 110,000 MILES. MY OLD DODGE WOULD NOT AND DID NOT HAVE ANY ISSUE AND IT HAD 130,000 MILES WHEN IT WAS WRECKED.

TL* THE CONTACT OWNS A 2002 FORD EXPEDITION. THE CONTACT STATED THAT THE VEHICLE'S DRIVER SIDE SEAT BELTS WOULD UNLATCH INDEPENDENTLY. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS NOT TAKEN TO AN INDEPENDENT MECHANIC OR DEALER TO BE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 123,000.

TL* THE CONTACT OWNS A 2002 FORD EXPEDITION. WHILE DRIVING APPROXIMATELY 30 MPH, THERE WAS AN ABNORMAL ODOR IN THE VEHICLE AND IT CAUGHT FIRE. THE FIRE WAS ABLE TO BE EXTINGUISHED BY THE FIRE DEPARTMENT. THE VEHICLE WAS DESTROYED AND TOWED FROM THE SCENE. A POLICE REPORT WAS NOT FILED. THERE WERE NO INJURIES. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CONTACT BELIEVED THAT THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 06E056000 (FUEL SYSTEM, GASOLINE). THE FAILURE MILEAGE WAS APPROXIMATELY 200,000. THE VIN WAS NOT PROVIDED.

TL* THE CONTACT OWNS A 2002 FORD EXPEDITION. THE CONTACT STATED THAT THE FRONT PASSENGER SIDE SEAT BELT UNLATCHED INDEPENDENTLY WITHOUT WARNING. THE CONTACT MENTIONED THAT THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO A DEALER BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 4,000. UPDATED 1/21/16 *CN

TL* THE CONTACT OWNS A 2002 FORD EXPEDITION. WHILE DRIVING AT LOW SPEEDS AND ATTEMPTING TO ACCELERATE, THE TIRES WOBBLED. IN ADDITION, THE FRONT AND REAR OF THE VEHICLE WERE UNSTABLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT ALL FOUR RIMS WERE BENT. THE VEHICLE WAS TAKEN TO ANOTHER INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE BELTS AND BANDS WERE WORN FOR ALL FOUR TIRES AND THAT ALL FOUR TIRES COULD HAVE BLOWN OUT. THE MECHANIC STATED THAT THE FRONT PASSENGER SIDE TIRE WAS FRAYED TO THE POINT THAT IT COULD BLOW OUT AND NEEDED TO BE REPLACED. ALL FOUR TIRES WERE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 102,000.

ON THE EVENING OF JULY 7TH, 2015 AT APPROXIMATELY 10:45 P.M. WE HEARD A COMMOTION OUTSIDE OUR APARTMENT COMPLEX AND DISCOVERED MY '02 EXPEDITION FULLY ON FIRE AND BEING DOUSED BY THE LOCAL FIRE DEPARTMENT. IT HAD JUST COME BACK FROM REPAIRS THAT AFTERNOON - TO THE PIGTAIL SWITCH AND RE-WIRING IN THE STEERING COLUMN DUE TO LOSS OF TURN SIGNALS AND RADIO. NOT ONLY WAS MY CAR DESTROYED, BUT THE CARS ON EITHER SIDE WERE DAMAGED, AS WELL AS DAMAGE TO THE APARTMENT COMPLEX. WE RETAINED AN ATTORNEY AND OUR INITIAL REPORT FROM THE FIRE DEPARTMENT STATED THE CAUSE AS "FAULTY WIRING." THE PRIVATE FIRE INVESTIGATOR WE RETAINED HAS ADVISED OUR ATTORNEY THAT THE FIRE IS DUE TO THE FLAWED CRUISE CONTROL SYSTEM THAT HAS BEEN THE CAUSE OF HUNDREDS OF OTHER FIRES IN FORD VEHICLES. WE INTEND TO PURSUE THIS MATTER LEGALLY AND WOULD SINCERELY APPRECIATE ANY ASSISTANCE OR ADVISE YOUR OFFICE CAN PROVIDE. *TR

ON MULTIPLE OCCASIONS THE DRIVER'S SIDE SEAT BELT HAS RANDOMLY UNBUCKLED ITSELF FOR NO APPARENT REASON. IF AN ACCIDENT WERE TO OCCUR THE SEAT BELT MAY NOT BE CONSIDERED A RELIABLE RESTRAINT WHICH COULD RESULT IN SERIOUS INJURY OR DEATH. AFTER MULTIPLE COMPLAINTS FROM SEVERAL CONSUMERS THIS SAFETY DEVICE SHOULD BE INVESTIGATED. *TR

CAR STARTED WITHOUT ANY PROBLEMS IN THE MORNING BUT IT DID NOT SHIFT ANY GEAR, CAR WAS TOWED TO THE MECHANIC AND TAKEN TO THE MECHANIC. WHILE THE MECHANIC WAS CHECKING THE VEHICLE THE CAR CAUGHT ON FIRE, THE ENGINE AND THE WHOLE FRONT OF VEHICLE CAUGHT ON FIRE. *TR

TL*THE CONTACT OWNS A 2002 FORD EXPEDITION. THE CONTACT STATED THAT THE GEAR LEVER FAILED TO SHIFT OUT OF THE PARK POSITION. IN ADDITION, THE FOUR POWER WINDOWS AND DOOR LOCKS BECAME INOPERABLE. THE CONTACT REPLACED THE 5 AMP FUSES ON FORTY DIFFERENT OCCASIONS HOWEVER, THE FAILURE PERSISTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 75,000.

5 AMP FUSE POPPED. REPLACED WITH ANOTHER 5 AMP FUSE. SHIFT LOCK SOLENOID ATTACHED TO BRAKE MASTER CYLINDER CAUGHT FIRE. FIRE WAS CONTAINED AND CONTROLLED. MINIMAL DAMAGES. UNSURE OF VEHICLE DRIVABILITY. COULD HAVE HAPPENED DURING TRANSIT. CONDITION UNSAFE. *TR