2019 FORD EXPEDITION Complaints

The contact owns a 2019 Ford Expedition. The contact received notification of NHTSA Campaign Number: 26V402000 (Power Train); however, the part to do the recall repair was not yet available. The contact stated that while driving approximately 60-70 MPH, the vehicle shuddered with the message "See Manual" displayed, and the vehicle jerked. The contact stated that the failure had occurred during hard acceleration. The vehicle was taken to the dealer, where it was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The contact was informed that parts were unavailable for the recall repair, and the contact was provided an estimate for the repair. The vehicle was not repaired due to the cost. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure and informed the contact that parts would be available in 2027. The failure mileage was approximately 97,000.

The contact owns a 2019 Ford Expedition. The contact stated that while stopping at a red light, there was a big explosion coming from the seat belt pretensioner that shook the vehicle. Additionally, the seat belt seized, and the air bag warning light was illuminated. The contact sustained whiplash and was treated with anti-inflammatory medication, shots, and muscle relaxers by the doctor. The contact associated the failure with NHTSA Campaign Number: 26V344000 (Seat Belts). The dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 136,000.

The contact owns a 2019 Ford Expedition. The contact stated that while driving at an undisclosed speed, there was an explosion sounding like a gunshot coming from the top of the vehicle. The contact stated that the driver’s side seat belt retractor tightened, and the contact felt severe pressure on the chest, almost knocking the wind out of the contact. The vehicle was swerving due to the failure, but the contact was able to keep the vehicle under control before pulling over. There was a burned electronics odor coming from the seat belt location. The contact associated the failure with NHTSA Campaign Number: 26V344000 (Seat Belts). The dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 61,000.

The contact owns a 2019 Ford Expedition. The contact stated that while attempting to park the vehicle, the message to shift to park(P) was displayed. The contact stated that later while driving at an undisclosed speed, the transmission independently shifted to park. The vehicle was taken to the dealer where it was diagnosed with transmission failure. The contact was informed that the failure caused the transmission to overheat. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The contact received notification of NHTSA Campaign Number: 26V402000 (Power Train); however, the part to do the recall repair was unavailable. The contact stated that the vehicle was the family vehicle used for transporting the contact's six minor children. The manufacturer was made aware of the failure, and a case was filed. The contact inquired about reimbursement if the vehicle was repaired out of pocket. The contact stated that the request was denied. The failure mileage was approximately 140,000.

Transmission is shifting hard and during highway speed acceleration shifts really hard check engine light came on

I am submitting this complaint regarding the transmission in my 2019 Ford Expedition because I believe it presents a serious safety hazard that should be investigated for a safety recall. My vehicle has approximately 108,000 miles. While driving at highway speeds, particularly when attempting to pass another vehicle, the transmission will suddenly stop providing power to the wheels. The vehicle completely loses acceleration without warning, making it impossible to safely complete a passing maneuver. This creates an extremely dangerous situation because I am left vulnerable in fast-moving traffic with no ability to accelerate out of the way of other vehicles. What makes this defect even more concerning is that the vehicle does not set any diagnostic trouble codes or illuminate a warning light when the failure occurs. After the incident, the transmission resumes normal operation and drives as though nothing happened, making it difficult to diagnose despite the serious safety risk. I have found that many owners of 2019 Ford Expeditions and other Ford vehicles equipped with the 10-speed automatic transmission have reported similar symptoms. Many of these reports identify premature failure of the CDF drum as a likely cause of the transmission malfunction. While I cannot personally confirm the exact internal failure without disassembly, the symptoms my vehicle exhibits are consistent with those widely reported by other owners. A vehicle should not unexpectedly lose the ability to accelerate while traveling at highway speeds, especially during passing maneuvers where acceleration is essential for safety. This defect places drivers, passengers, and others on the road at risk of a serious crash. I respectfully request that this issue be thoroughly investigated and that, if a common manufacturing or design defect is confirmed, Ford be required to issue a safety recall so affected owners are not forced to bear the cost of repairing a defect that poses a significant risk t

The contact owns a 2019 Ford Expedition. The contact stated that while operating the vehicle, the transmission was shifting hard when shifting from park (P) to drive (D) or reverse (R). The contact stated that the hard shifting of the transmission also occurred while driving, with the transmission shifting from 4th to 5th gear and 6th, 7th, and 8th gear. The vehicle was taken to the local dealer, who was unable to identify a transmission failure, and the vehicle was not repaired. The manufacturer was not yet notified of the failure. The failure mileage was 77,000.

The contact owns a 2019 Ford Expedition. The contact stated that while driving 70 MPH, the message "Vehicle in Park" was displayed. The contact stated that the vehicle unexpectedly shifted into park(P) on two separate occasions. There was an abnormally loud clunking sound coming from the vehicle. The vehicle failed to accelerate. The contact received notification of NHTSA Campaign Number: 26V402000 (Power Train). The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 79,000.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V099000 (Seat Belts). While driving approximately 45 MPH and approaching an intersection, the air bag warning light illuminated. There was an abnormally loud sound like a gunshot coming from the vehicle, and smoke was inside the vehicle. The front passenger’s seat belt unexpectedly deployed and retracted on the side of the vehicle. The seat belt failed to move and became inoperable. Prior to the failure, the owner's daughter was seated in the front passenger’s seat. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 81,000.

I have 3 small children so I am concerned about my car. The gear shift goes out of drive while driving. If you push the gas and then let up and push the gas again it won’t go and if you keep pushing the gas it will start fishtailing all over the road. You have to take your foot off the gas for a period of time until it goes back in gear which causes you to completely slow down and can cause a crash. When trying to give excessive gas it will disengage and won’t go. It will only engage 1 tire and cause it to fishtail. It has almost caused an accident multiple times because it slips out of gear and it currently has a recall for a similar issue. You can’t pull over or move over wile it disengages because you can’t go anywhere if you push the gas it just accelerates like it was in park. This is not an if something happens it’s a when something happens. Nobody else can drive my vehicle because they won’t know how to stop it from happening and they may get seriously hurt. It has happened on multiple occasions