2019 FORD EXPEDITION Complaints

I am submitting this complaint regarding an intermittent transmission and loss-of-motive-power issue with my 2019 Ford Expedition equipped with the 10-speed automatic transmission. When I first start the vehicle and begin driving, I experience an intermittent delay, particularly around the 1st-to-2nd gear transition. I press the accelerator and the engine RPM increases/revs, but the vehicle does not move forward or accelerate as expected. There is approximately a 3–5 second delay before the transmission engages and the vehicle suddenly begins moving. During these events, it feels as though the transmission has temporarily gone into neutral even though the vehicle is in Drive. This is not simply a harsh or uncomfortable gear change. The engine responds to the accelerator, but power is temporarily not being transferred to the wheels. I consider this a significant safety concern because a 3–5 second loss or delay of motive power could leave me unable to accelerate when entering traffic, crossing an intersection, merging, or attempting to avoid another vehicle. The vehicle can suddenly engage after the delay, which could also cause an unexpected surge forward. My vehicle has previously been taken to a Ford dealership for a transmission/PCM-related recall, and I was told that the recall had been corrected. However, I continue to experience this loss/delay of motive power. I am aware that Ford has issued technical service information addressing delayed engagement and delayed shifting in 2018–2021 Ford Expeditions equipped with the 10R80 transmission. I am concerned that my symptoms may be related to the known transmission issues affecting these vehicles and that this condition may represent a broader safety concern. I am requesting that NHTSA review this condition and determine whether further investigation or additional safety action is warranted.

On 8/6/2026, the transmission/powertrain of my 2019 Ford Expedition malfunctioned, causing a complete loss of propulsion. While traveling on a busy mountainous highway with my three children, I stopped in a center turn lane to merge into fast-moving traffic. When I attempted to accelerate, the vehicle would not move. The transmission display showed 4th gear even though the vehicle was stopped. We were stranded in the center turn lane with traffic approaching from both directions, creating a serious collision risk. No accident occurred. This vehicle has a documented history of recurring transmission problems since 2024, including harsh/delayed shifting, bucking, hesitation and jerking, repeatedly involving 4th gear, and even loss of propulsion with the initial 2024 issue. In Jan. 2025, the dealer documented a delayed upshift and harsh bump/buck into 4th gear. In July 2025, the dealer documented hesitation/jerking that was worse going into 4th. The transmission has been removed/disassembled multiple times and has undergone major repairs including CDF drum/internal transmission work, main control/valve body repairs, and most recently torque converter and additional valve body replacement in early 2026. Previous transmission symptoms have been reproduced and verified by the dealer. After the 8/6/2026 incident, the vehicle was taken to the Lincoln dealer. The current repair record documents "complete loss of propulsion with gear stuck in 4th" and delayed shifting surrounding 4th gear. The dealer attempted to reproduce the failure and obtain diagnostic codes but has not been able to duplicate it and reports no codes at this time. I do not recall any warning lights or messages immediately before the failure. The vehicle is available for inspection. Ford has previously been contacted regarding these recurring transmission failures and provided partial assistance with a prior repair.

I started by 2019 Ford Expedition and was driving through a parking lot at a low speed when there was an explosion sound (comparable to a gun shot over my left shoulder as the driver). My seatbelt pulled in and locked down. My car smelled like a firework had been set off and there was a white-grey powder across my lefts. I immediately stopped and parked my vehicle. I had my passenger move to the back of the car as a safety precaution. It took effort to get the belt to unlatch and off. We moved the vehicle to a safer parking spot and had it towed to David McDavid - FtW. I have a seatbelt burn on my neck. My left shoulder, across my chest, and right hip are very sore today. We received the recall notice the day prior. However, the letter states that: Ford has not issued instructions to stop driving your vehicle…. Had this happened while driving at a faster speed, the incident could have very easily been catastrophic. My concern now is that the dealership is trying to say this is an interior trim concern, and Ford’s customer service could do nothing other than repeat their script that there is no remedy at this time. Their advice lent the consumer to saving receipts for rental and/or repair with faulty parts until the advanced notice becomes an active one. I have no vehicle to drive, I have mild injuries, and we have zero support from Ford. Making matters worse, our dealership is wanting to charge us for inspecting the vehicle and calling it an “interior trim concern”, while listing the seatbelt retractor inspection right after it for free. THESE ARE THE SAME ISSUE.

I was in a collision and the whole front end was crushed but the airbags did not deploy

While pulling into a parking space, vehicle in drive, the passenger seatbelt exploded. There was no accident and no one was sitting in the passenger seat. It sounded like a gunshot went off inside the truck, followed by smoke filling the cabin, and a smell like fireworks. The seatbelt was then permanently on a retracted position. No air bags were deployed but the plastic casing on the inside of the vehicle popped out where side airbags are stored. This incident was traumatic as the vehicle was in motion, but thankfully at a low speed. Ford says the remedy is not available and currently will not repair the seatbelt so that the vehicle is legally safe, and drivable.

The contact owns a 2019 Ford Expedition. The contact received notification of NHTSA Campaign Number: 26V344000 (Seat Belt). The contact stated that while driving 5 MPH with his wife seated in the passenger’s seat, the check engine warning light illuminated. The contact stated that approximately 5 minutes later, the passenger’s seat belt pretensioner exploded. The contact's wife sustained stomach bruises when the seat belt tightened on her stomach, and the contact released the passenger from the seat belt. Medical attention was not needed. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 78,000.

The car has recalls since 2024? Some are serious safety issues if in an accident. Way too long for a remedy from FORD. 2019 FORD EXPEDITION 2019 FORD EXPEDITION VIN: [XXX] Recall data refreshed on XXX 4Unrepaired Recalls associated with this VIN FEB 09, 2024 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The passenger-side seat-belt retractor pretensioner, which is part of the supplemental restraint/airbag system, malfunctioned. The pretensioner apparently deployed without a collision, and the passenger seat belt became permanently locked and unable to retract or extend. The vehicle and failed component remain available for inspection upon request. My safety and the safety of my passengers were put at risk because the pretensioner activated unexpectedly with a loud explosion-like bang, a burning or chemical smell, and movement of the passenger-side interior panel. The passenger seat belt is now unusable, leaving that seating position without a functional restraint. The unexpected deployment could also have startled the driver and caused a crash, and I am concerned that other restraint components may deploy unexpectedly or fail during an actual collision. The problem was confirmed by an authorized Ford dealership. Before the failure, the airbag warning light illuminated. I took the vehicle to the Ford dealership, where personnel looked it over and scheduled an appointment for August 28, 2026. At that appointment, the dealership performed diagnostic testing and documented code B007F for an open passenger-seat-belt pretensioner circuit. The dealership also confirmed that an open Ford Field Service Action appears in OASIS for this concern but stated that the campaign is currently on hold until Ford releases the repair. The vehicle has been inspected by the Ford dealership but, to my knowledge, has not been inspected by Ford corporate representatives, police, insurance representatives, or another independent service center. The airbag warning light was the warning symptom that appeared before the unintended deployment. After the failure, the passenger seat belt was locked, the airbag light remained illuminated, and the dealership’s diagnostic test confirmed the pretensioner-circuit fault.

The contact owns a 2019 Ford Expedition. The contact received notifications of NHTSA Campaign Numbers: 26V402000 (Power Train), 24V099000 (Seat Belts), 26V344000 (Seat Belts), and 26V368000 (Structure); however, the parts to do the recall repairs were not yet available. The contact was mostly concerned about NHTSA Campaign Number: 26V402000 (Power Train) recall. The dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was notified of the issue and confirmed that parts were not yet available. The contact had not experienced a failure.

My 2019 Ford Expedition Max 4WD has approximately 120,000 miles. Intermittently the engine RPM increases but the vehicle does not accelerate as expected when I press on the accelerator. The transmission does not appear to be shifting between 5th and 6th gears. This creates a safety concern because the vehicle does not always accelerate when expected, specifically when entering or merging with highway traffic. I took the vehicle to a Ford dealership on August 24, 2026. I described the symptoms to the service representative. The representative told me that this transmission has a known issue involving the clutch shaft/sleeve and indicated that repair would require significant transmission work. I declined the $200 diagnostic service because I do not intend to authorize the approximately $9,000+ repair. The vehicle has not been formally diagnosed.