2019 FORD EXPEDITION Complaints

The contact owns a 2019 Ford Expedition. The contact stated that while the vehicle was parked, the contact observed a loud bang and smoke emanating from the front passenger’s seat. Additionally, the front passenger’s seat belt had seized and was not able to retract or extend. The vehicle was towed to a dealer but was not diagnosed. The manufacturer was notified of the failure. The failure mileage was 69,000.

When I cold start my 2019 Ford Expedition Limited it has a ticking noise under the hood coming from the engine. Remote start or in the cab button start noise happens. Would like this fixed asap as the manufacturer Ford is aware of the problem. I’ve own a 2004 Ford explorer xlt never had any problems except wear and tear. Silverado was my 1st truck no problems. I love ford trucks, I’m embarrassed by this. Please honor your slogan “Built Ford Tough” Thank you

The contact owns a 2019 Ford Expedition. The contact received notification of NHTSA Campaign Number: 24V099000 (Seat Belts) however, the part to do the recall repair was not yet available. The contact stated that the rear driver's side seat belt was locked and failed to extend or retract. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was unknown. VIN tool confirms parts not available.

The center console cup holder collapsed. It was a driving distraction and could have resulted in injury. We now have a have an open hole in the center of our car.

The contact owns a 2019 Ford Expedition. The contact received notification of NHTSA Campaign Number: 24V099000 (Seat Belts); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

While driving on the highway at moderate speeds during rush hour there was noticeable hesitation/delay with acceleration (automatic transmission). It made a noticeable clunk and it completely lost power momentarily. I called the Ford dealership and was told there is a Technical Service Bulletin (TSB) on this exact issue but it's not covered under a recall. I received further correspondence stating that because it's not a recall it has to go through Ford's warranty department and it may not be covered. My vehicle has been at the dealership since March 8th. This is very dangerous and is a significant safety risk to have harsh and delayed shifting, clunking and power loss. I hope a safety recall can be recommend to prevent serious injury.

The contact owns a 2019 Ford Expedition. The contact stated that while starting the vehicle and driving 25 MPH, the service engine warning light was illuminated. The contact stated that upon starting the vehicle there was an abnormal rattling and ticking noise heard. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The approximate failure mileage was 40,000.

The contact owns a 2019 Ford Expedition. The contact stated while driving and depressing the accelerator pedal, the vehicle failed to exceed 60 MPH. There was no warning light illuminated. The vehicle was taken to the dealer, where an unknown software update was performed. Additionally, the contact stated that while driving at various speeds, the vehicle stalled. The contact also stated that the vehicle overheated while driving and while idle. The contact stated that the engine had overheated to 230-240 degrees, and the engine was shuddering while driving. There was no warning light illuminated. The vehicle was taken to the dealer, where the water pump, the TCM, the battery and unknown parts were replaced; however, the failure persisted. The vehicle was taken to a second dealer, Suburban Ford of Ferndale (21600 Woodward Ave, Ferndale, MI 48220), where it was diagnosed that the cam phasers had failed and needed to be replaced. The vehicle was not repaired. The contact related the failure to Ford Campaign Number: [XXX]. The manufacturer was notified of the failure and informed the contact that the vehicle was not covered. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 28,000. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Pulling up to a stop light and we heard an explosion, my wife immediately said something hit her , we smelled burning smell and smoke. My wife has a large bruise from the seatbelt and the seatbelt no longer works

The contact owns a 2019 Ford Expedition. The contact stated while driving at an undisclosed speed, the electrical system became inoperable. The contact stated that the center console had no power. The contact stated that the radio and the charging station had no electrical power. The engine on due to low power warning light illuminated and went off. In addition, the rear driver's side door and the passenger's front and rear door latches were inoperable. The latches failed to unlock from the inside. The vehicle was taken to the dealer several times however, the failure could not be duplicated. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 3,500.