1999 FORD EXPEDITION Complaints

THE SIDE VIEW MIRROR HAS DETERIORATED TO THE POINT THERE IS NO REFLECTIVE MATERIAL LEFT. I AM UNABLE TO USE THE MIRROR, CAUSING A SAFETY ISSUE. FORD DEALER WILL NOT REPLACE/REPAIR AS CAR IS OUT OF WARRANTY. TECHNICAL SERVICE BULLETIN ISSUED. WILL COST $300 TO $400 TO HAVE FIXED.

I OWN A 1999 FORD EXPEDITION. I WAS DRIVING HOME WHEN I HEARD A BUMP IN THE BACK OF MY VEHICLE. I LOOKED IN THE REAR VIEW MIRROR TO SEE MY SPARE TIRE BOUNCING OFF ANOTHER VEHICLE AND ROLLING DOWN THE STREET. IF I HAD BEEN GOING AT A FASTER RATE OF SPEED, SOMEONE COULD HAVE BEEN SERIOUSLY INJURED IF NOT KILLED. I STOPPED TO RETRIEVE THE TIRE WHEN I NOTICED THAT THE CABLE HOLDING THE TIRE HAD JUST SNAPPED. AFTER A LITTLE RESEARCH ON THE INTERNET I HAVE DISCOVERED THAT THIS IS NOT AN ISOLATED INCIDENT. WHEN I CALLED THE DEALER TO SEE IF THERE HAD BEEN A RECALL THEY SAID THERE HAD NOT, BUT THEY COULD SELL ME A REPLACEMENT FOR $78. THIS IS NOT JUST ABOUT MONEY, IT'S ABOUT A KNOWN PROBLEM THAT FORD NEEDS TO FIX. AS I SAID BEFORE, "SOMEONE CAN BE SERIOUSLY INJURED BY THIS PROBLEM". CAN YOU LOOK INTO THIS PROBLEM? THANKS. *AK

I OWN THE INFAMOUS 1999 FORD EXPEDITION WITH THE HEAD GASKET OIL LEAK. THOUGH I LOVED THIS CAR FROM THE DAY I PURCHASED IT NEW UP UNTIL THE TIME AT 50,000 MILES THE OIL STARTED TO LEAK. IT IS WELL MAINTAINED AND BABIED, SO FOR SOMETHING AS SERIOUS AS THIS TO HAPPEN TO ALL OF US WHO OWN THESE VEHICLES DISAPPOINTS ME. FORD WOULD ONLY PAY FOR HALF OF THE REPAIR, BUT I BELIEVE THIS SHOULD BE A RECALL BECAUSE OF THE SERIOUSNESS OF THE PROBLEM.A HEAD GASKET BLOWING? THE HEADS ARE ALSO DEFECTIVE FROM WHAT I HAVE READ. THAT IS NOT YOUR AVERAGE REPAIR. I DON'T HAVE THE MONEY TO REPLACE SOMETHING THAT WAS INSTALLED DEFECTIVE TO BEGIN WITH. I GUESS I WILL CONTINUE TO STUFF A RAG UP UNDER THE LEAK UNTIL FORD FEELS LIKE TAKING REPONSIBILITY FOR ITS FAILURES. *AK

WHILE DRIVING DRIVER WAS UNABLE TO SEE FROM THE DRIVER SIDE AND PASSENGER SIDE MIRRORS. THIS CAUSED POOR VISIBILITY TO THE DRIVER. VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT BOTH MIRRORS NEEDED TO BE REPLACED. *AK

WHILE DRIVING MY VEHICLE THERE IS A VIBRATION IN THE REAR END WITH A LOUD BUMPING NOISE. MUCH LIKE A 4X4 IN A HARD TURN. THE DEALER HAS REPAIRED THE PROBLEM FOUR OTHER TIMES AND THIS WILL BE THE FIFTH. I AM WORRIED THAT THIS COULD BE A SAFETY ISSUE WITH SOMETHING HAPPENING TO THE AXLE WHILE DRIVING. THE VEHICLE ONLY HAS 56K MILES ON IT. THE VEHICLE ALSO LURCHES FORWARD ON START UP. *JB

#3 SPARK PLUG BLEW OUT AT 67,000 MILES. ORIGINAL PLUGS FROM MANUFACTURE WITH ALL FACTORY PARTS. SPOKE WITH SEVERAL FORD MECHANICS AND OTHERS WHO HAVE EXTENSIVE WORK ON THIS PROBLEM. FORD ACKNOWLEDGES NO DESIGN ERRORS. I FOUND ONLINE THAT THIS HAS HAPPENED TO SEVERAL FORD OWNERS WITH THE 5.4 L V8 AND THE V10 ENGINE AND ON OCCASION WITH 4.6L V8. THIS APPEARS TO ME TO BE A DESIGN FLAW THAT FORD SHOULD HAVE RECALLED. *JB

PURCHASED A NEW SET OF YOKOHAMA GEOLANDER AT TIRES SIZE 265/70/17 MOUNTED ON 1999 FORD EXPEDITION. TIRES WERE ROTATED WITH EVERY OIL CHANGE, AND AFTER 17,000 MILES HAVE COMPLETELY WORN OUT.

1999 FORD EXPEDITION. BOTH EXTERIOR MIRRORS (WITH INTEGRATED RED TURN SIGNAL CHEVRON) DELAMINATED LOST REFLECTIVE COATING ON BACK OF MIRROR. HAVE CONTACTED FORD DEALER ON TWO OCCASIONS, AND CONTACTED FORD CONSUMER SERVICES. FORD ACKNOWLEDGES SEVERAL SERVICE BULLETINS ON THE ISSUE BUT WOULD NOT TELL ME WHAT IT CONTAINED. THE VEHICLE HAD 55,000 MILES AND NOW HAS 65,000 MILES. QUOTED $169 PER MIRROR TO REPLACE MIRROR GLASS OR $400 PER MIRROR FOR COMPLETE REPLACEMENT. THE MIRROR WAS MANUFACTURED BY MUTH AND I CONTACTED THEM. THEY ACKNOWLEDGED A MANUFACTURING DEFECT AND HAD A UPGRADE KIT TO PROVIDE NEW MIRRORS GLASS FOR $216 DELIVERED TO MY DOOR. I PAID A BODY SHOP $65 FOR REPAIRS. I AM HAPPY WITH THE RESULTS. THIS IS A SAFETY ISSUE LIKE SEAT BELTS, AIR BAGS, ETC. I WILL SHIP THE OLD MIRRORS TO YOU AT MY EXPENSE FOR YOUR INVESTIGATION. *JB

LINK ASSEMBLY ON STABILIZER BAR BROKEN ON BOTH FRONT RIGHT AND FRONT LEFT AND TOTALLY MISSING. OCCASIONAL "THUMPING" NOISE UNDER FRONT END WARRANTED FURTHER INSPECTION AND THAT WAS WHEN THE LINKAGES WERE FOUND TO BE MISSING. FORD SERVICE DEPT. SAID THIS HAPPENS OCCASIONALLY? VEHICLE ONLY HAD 59.6K MILES. *NM

FAULTY TRANSMISSION ON 1999 FORD EXPEDITION XLT 4X4. 31,000 MILES, NEVER TOWED ANYTHING. OUT OF WARRANTY DUE TO TIME. *NM