2020 FORD EXPEDITION Complaints

The contact owns a 2020 Ford Expedition. The contact stated while driving approximately 35 MPH and going down a hill, the vehicle experienced unintended acceleration. There was no warning light illuminated. The contact stated that the power steering operated as needed however, the brakes failed to operate as needed. The contact steered through an intersection as the vehicle continued to accelerate. Additionally, the Forward Collision Avoidance systems had not activated. The contact attempted to apply the parking brake however, the parking brake failed to engage. The contact stated that the vehicle then decelerated independently and she was able to stop the vehicle. The vehicle was towed to a hotel. The vehicle had not been diagnosed by a dealer or independent mechanic. The vehicle had not been repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 7,000.

While driving the Vehicle in 4A and sometimes 2 WD at 75MPH it shifts into neutral and you have to pull over and slow down to 50 MPH to get it to go back into gear. I have another vehicle just like it and the same problem exists and Ford dealer says they can't find anything. This is definitely a Safety Issue as it occurs mostly on the Interstate.

The contact owns a 2020 Ford Expedition. The contact stated that while the vehicle was parked, the rear windshield unexpectedly shattered. There was no impact to the rear windshield that could have caused it to shatter. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure but did not provide any assistance. The failure mileage was 17,143. The VIN was unavailable.

The contact owns a 2020 Ford Expedition. The contact stated while driving 70 MPH the "Power Train malfunction" warning light illuminated on the instrument panel as the vehicle went into LIMP mode. The contact stated that the vehicle would fail to accelerate when the accelerator pedal was depressed. The contact stated that the first time the failure occurred she pulled over had the vehicle was towed to an unknown Ford dealer as she was out of town. The contact stated that she was unaware of the diagnostic test result or repair. The contact stated that the failure had occurred multiple times. However, on the most recent failure after picking the vehicle up from the dealer the vehicle failed to stop when the brake pedal was depressed. The vehicle rolled into the parking lot next to the dealer and the contact had to turn the ignition off to stop the vehicle. The dealer was contacted immediately, and the vehicle was towed back to the dealer. The vehicle was currently at the dealer waiting for the diagnostic test and repair. The contact stated that the dealer contacted the Ford engineers and was awaiting guidance on how to repair the vehicle. The manufacturer was made aware of the failure. The contact stated that she had requested the manufacturer buy back the vehicle twice and was denied. The contact stated that the manufacturer advised her to contact NHTSA. The approximate failure mileage was 10,000.

The contact's husband owns a 2020 Ford Expedition. The contact stated that while driving at 65-70 MPH on cruise control, the vehicle inadvertently downshifted, skipped a gear, and lurched forward several times. There were no warning lights illuminated. The contact stated that the vehicle would skip from 3rd gear to 5th gear whenever she would depress the accelerator pedal. The contact was able to continue to drive the vehicle. The vehicle was taken to the dealer who diagnosed that the transmission needed to be replaced. The contact stated that the vehicle was repaired; however, upon picking up the vehicle from the dealer and driving home, the accelerator pedal was depressed but the vehicle inadvertently decelerated instead. There were no warning lights illuminated. The contact also stated that the RPM of the vehicle was jumping between 2,000 and 3,000 RPM. The contact continued to drive the vehicle. The vehicle was taken back to the dealer who test drove the vehicle but was unable to diagnose it. The dealer reset the adaptive learning of the vehicle; however, the failure persisted, and the vehicle would make abnormal clunking sounds while shifting into drive. The vehicle was taken back to the dealer who informed the contact that they could not duplicate the failure. The contact stated that the failure reoccurred increasingly and significantly while driving. Additionally, the driver’s side rear brake had an abnormally strong burning odor. The vehicle was taken to Lebanon Ford (770 Columbus Ave, Lebanon, OH 45036) who was unable to duplicate the failure. The dealer notified the manufacturer of the failure. The manufacturer's field technician advised the dealer to replace the brake light sensors. The contact stated that the brake light sensors were replaced; however, upon picking up the vehicle, the start button was depressed but the vehicle failed to start. The manufacturer was notified of the failure and offered a buy back. The vehicle was not repaired. The approximate failure mileage was 7,400.

The contact owns a 2020 Ford Expedition. The contact stated that while driving approximately 70 MPH, the gear shifter suddenly dropped, the RPM revved up, and there was a thumping noise and a shift system malfunction warning light illuminated. The failure occurred when the contact attempted to accelerate. The failure occurred twice and on the second occurrence, the contact noticed that the RPM was revving up while attempting to accelerate. The contact released the accelerator pedal to stop the failure and the vehicle returned to normal functionality. The contact took the vehicle to the dealer however, the mechanic was unable to determine the cause of the failure. The vehicle had not been diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was 30,916.

At 70+ MPH the automatic transmission tried to drop into 1st gear while on the interstate in a passing lane with heavy traffic all around. It had a loud and physical clunk then began to lose power. It was erratic, disorienting and distracting. The sudden change in behavior of the vehicle could have caused me to lose control of the vehicle at speed on a federal interstate and could easily resulted in an accident causing major injury and damage. The dealer says the car has no fault codes and they have download "updates" to the software. To date they have no explanation for why the vehicle behaved in this manner. This is the second time I have taken the vehicle in for odd transmission behavior. I have a video of the dashboard during the event showing the speed, RPM, mileage and the gear selector gauge when the transmission attempted several times to shift from higher gears to the 1st gear. I shared the video with the dealer. The video I have was taken with a iPhone. It would not up load to your site. I can make it available. This is dangerous with no answers!

Forward collision warning, dynamic brake support and automatic emergency braking do not work and the driver menu to to turn on/off and or adjust settings is inaccessible. Although not part of NHTSA recall #20V-262 issued in May 2020, my vehicle matches the exact vehicle configuration and problem(s) outlined in the recall documentation. The vehicle was brought to the dealership on 6/16/2020 where Ford claimed the vehicle did not have any of the aforementioned safety systems and therefore had no issue. [see attached paperwork dated 6/16/2020] After 1 entire month of back and forth, the dealership subsequently acknowledge the vehicle does indeed have the safety features and they need to further investigate with no commitments made on solution and or timeline. [see attached email dated The issue was spurred by a near miss collision when the systems did not activate.

While traveling at highway speed on I-95 North around 10AM, the vehicle brake quickly and abruptly activated which reduced the vehicle speed by 15-20 MPH. Within seconds, the vehicle returned to previously set speed with Adaptive cruise activated. This incident occurred while passing a tractor trailer truck. The truck was in the center lane and I was passing on the far left lane. As I started to pass the truck, the brake activated when within 10-20 feet of the truck for a moment then returned to previously set speed (75 MPH). This happened so quickly and unexpectedly, I did not notice any warning indicators on the dash display. Fortunately there were no vehicles closely behind me so there was little risk of an accident this time! Due to this incident, I have not used adaptive cruise since nor have I taken the vehicle to a dealer.

THE POWER RUNNING BOARD ON THE PASSENGER SIDE IS MALFUNCTIONING. TWICE IT HAS OPENED AND THEN STARTED SHUTTING WITH THE DOOR OPEN AND MY CHILD'S GOOD ON IT, ALMOST CLOSING WITH THEIR FOOT IN IT. I HAVE TAKEN IT TO THE DEALER BUT THEY COULD NOT REPLICATE THE ISSUE. I AM TAKING IT IN AGAIN NEXT WEEK. THE VEHICLE WAS NOT TURNED ON AND WAS IN PARK.