2000 FORD EXPEDITION Complaints

I BEGAN NOTICING ELECTRICAL PROBLEMS WITH THE LIGHTS GOING ON AND OFF, DASH GAUGES GOING ON AND OFF, RADIO GOING ON AND OFF, HEATER GOING ON AND OFF, DOOR ALARM STAYING ON WHEN DRIVER'S DOOR IS OPEN, BUT NO KEY IN IGNITION OR LIGHTS ON, DOOR LOCKS NOT WORKING PROPERLY, 4WD ENGAGING AUTOMATICALLY, CD PLAYER GOING OFF AND ON, WINDSHIELD WIPERS GOING ON AND OFF, AND WATER ON DRIVER'S SIDE FLOOR AFTER RAINS. IT HAS BECOME MORE OF A PROBLEM. I DID NOT KNOW WHAT WAS CAUSING THE PROBLEMS UNTIL I BEGAN REPLACING PARTS AND FOUND ON THE INTERNET THAT THIS HAS BEEN A KNOWN PROBLEM WITH THE EXPEDITION AND FORD BEING AWARE OF THE PROBLEM FOR MANY YEARS. I JUST WROTE THE FORD COMPANY AND THEY TOLD ME THEY KNEW NOTHING ABOUT SUCH PROBLEMS!!! REFERENCE NUMBER IS [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

WHILE I PULLED IN A PARKING LOT AFTER FREEWAY DRIVING THE THROTTLE STICKS. THIS ONLY HAPPENS IN LOT TEMPERATURES. THIS MAKES THE VEHICLE UNSAFE TO DRIVE. YOU HAVE TO PUSH THE BRAKE EXTREMELY HARD TO STOP AND THE MOMENT YOU REMOVE YOUR FOOT FROM THE BRAKE THE VEHICLE SPEEDS UP. WHEN THIS HAPPENS ON SNOW COVER ROADS THE ABS KICKS IN. WHEN THE ABS RELEASES THE BRAKES THE VEHICLE JERKS FORWARD 2 TO 3 FEET. THIS IS A MAJOR SAFETY ISSUE MAKING THE VEHICLE UNSAFE TO DRIVE. FORD HAS ISSUES A TSB ON THE PROBLEM (TSB 01-21-5) SUGGESTING A PVC REPAIR KIT. THE PROBLEM IS NOT BEING CAUSED BY A DEFECTIVE PART, IT IS A DEFECTIVE DESIGN ALLOWING MOISTURE TO ENTER THE SYSTEM FROM THE PCV AND ICE UP THE THROTTLE PLATE. THIS NEEDS TO BE A RECALL. *TR

SUMMARY: WATER LEAKED AROUND THE LEFT SIDE OF WINDSHIELD CAUSING ELECTRICAL FAILURES, INCLUDING BUT NOT LIMITED TO THE STARTER, RADIO, WINDSHIELD WIPERS, HEADLAMPS, ETC. THE WATER ENTERING THE VEHICLE WET THE POWER DISTRIBUTION BOX (PDB) AND THE GENERIC ELECTRONIC MODULE (GEM). THESE COMPONENTS CONTROL VARIOUS ELECTRICAL SYSTEMS IN THE VEHICLE. THE VEHICLE CONTINUED TO ATTEMPT TO START ITSELF WITHOUT ANY KEY IN IGNITION UNTIL IT RESULTED IN THE STARTER BURNING UP AS WELL AS DAMAGING ASSOCIATED WIRING AND BATTERY. VEHICLE'S WINDSHIELD HAD TO BE REPLACED AS WAS THE STARTER, ASSOCIATED WIRING AND BATTERY AFTER VEHICLE WAS TOWED TO REPAIR FACILITY. *TR

5 PEOPLE IN MY VEHICLE DRIVING 55MPH ON I40 AROUND MIDNIGHT WHEN AIR SUSPENSION WENT OUT AND EVERYTHING IN THE DASH WENT CRAZY. THINGS CUTTING OFF AND ON MOVING BACKWARDS AND FORWARDS, WHEN I CUT IT OFF SO TO NOT DRIVE WITH AIR SUSPENSION DOWN IT WOULD NOT RESTART UNLESS YOU STARTED IT IN NEUTRAL BUT THE BATTERY KEPT DYING AND EXPLODED DRIVING TO SHOP,.GOT ANOTHER BATTERY, IT EXPLODED TO. NOTHING ELECTRICAL WORKED. DOOR LOCKS, WINDOWS,SPEEDOMETER, STEREO WOULDN'T COME ON THEN WOULD COME ON BY ITSELF, LIGHTS TO. AIR SUSPENSION WOULD NOT WORK, BEEN IN THE SHOP TWICE. FIRST TIME THEY DIDN'T KNOW WHAT WAS WRONG. THIS TIME THEY KNOW BUT I CAN AFFORD TO FIX IT. THE GEM MODULE AND FUSE BOX IS OVER 600.00 PLUS LABOR! IM DISABLED WITH A FIXED INCOME AND I HAVEN'T DRIVEN ANYWHERE SINCE FEB I CANT GET TO MY DOCTOR, GROCERY STORE, TO GET MEDICINE FOR HEART ATTACK AND OTHER DISABLING ILLNESSES. I CANT AFFORD ANOTHER CAR OR TO FIX MY EXPO. THIS COULD HAVE BEEN DANGEROUS I SURE NEED SOME HELP WITH THIS.ELECTRICAL SYSTEM FAILURE NHTSA PRELIMINARY EVALUATION #PE05033 STATUS:CLOSED DATE OPENED:JUNE 15, 2005 DATE CLOSED: OCTOBER 13, 2005 RECALL: NO RECALL ISSUED COMPONENT(S): ELECTRICAL SYSTEM EQUIPMENT:ELECTRICAL VISIBILITY:WINDSHIELD SUMMARY: ODI HAS RECEIVED 39 REPORTS ALLEGING THAT WATER LEAKS AROUND THE WINDSHIELD CAUSING ELECTRICAL FAILURES, INCLUDING BUT NOT LIMITED TO THE WINDSHIELD WIPERS AND THE HEADLAMPS.FORD REPORTS THAT WATER ENTERING THE VEHICLE CAN WET THE POWER DISTRIBUTION BOX (PDB) AND THE GENERIC ELECTRONIC MODULE (GEM).THESE COMPONENTS CONTROL VARIOUS ELECTRICAL SYSTEMS IN THE VEHICLE.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS, EA05015, TO ALLOW FURTHER INVESTIGATION OF THE ISSUE AND TO ASSESS THE NATURE OF THE POTENTIAL SAFETY CONSEQUENCE.NHTSA: FOR DETAILED INFORMATION & SUPPORTING DOCUMENTS, SEE THE OFFICIAL NHTSA INVESTIGATION#PE05033. *TR

TL* THE CONTACT OWNS A 2000 FORD EXPEDITION. WHILE DRIVING 5 MPH, AN UNKNOWN NOISE EMITTED FROM THE REAR DRIVER SIDE OF THE VEHICLE AND IT BEGAN TO SHAKE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE TRAILING ARMS FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 135,000.

JUST STOPPED AT STOP LIGHT, PULLED AWAY AND HEARD A SMALL POPPING NOISE, SLOWED DOWN TO TURN CORNER TO TRY TO PULL OVER AND LOOK AND VEHICLE STARTED POPPING LIKE A POPCORN POPPER. THOUGHT IT WAS MUFFLER(S). GOT UNDER CAR TO LOOK NOTHING WRONG THERE, PROCEEDED TO GO BACK HOME. ( LESS THAN 5 BLOCKS AWAY) DRIVING ON (COASTING) ONLY USING GAS PEDAL TO MAKE IT INTO DRIVEWAY. GOT UNDER HOOD AND SEEN SPARK PLUG LAYING ON ENGINE, COIL LOOING LIKE IT HAD CAUGHT FIRE. REPLACED WIRE, PLUG AND PUT A HELIX COIL ON IT. DROVE FOR ABOUT A MONTH. SAME THING HAPPENED AGAIN. HAD MECHANIC "RETHREAD" THE HEAD AND USE "SLEEVE". THIS LASTED ABOUT ANOTHER MONTH. HAD TO REPLACE IT 3 MORE TIMES (ALWAYS THE SAME PLUG THAT POPPED OUT) UNTIL AUGUST 2 WHEN IT DIDN'T EVEN MAKE IT OUT OF MY DRIVEWAY BEFORE IT POPPED AGAIN. NOW IT IS SITTING IN MY DRIVEWAY, A 5100 POUND "LAWN ORNAMENT" NOT LOOKING FORWARD TO REPLACING THE HEAD. *TR

DRIVING NORMALLY DURING HEAVY RAIN WIPERS AND RADIO WENT DEAD AT HIGHWAY SPEED AND WORKED INTERMITTENTLY AFTER THAT. AFTER THE RAIN STOPPED AND CAR DRIED OUT WIPERS AND RADIO WORKED NORMALLY AGAIN. CARPET ON LEFT SIDE UNDER FUSE PANEL AND GEM MODULE, BOTH OF WHICH HAVE ALREADY BEEN REPLACED WAS WET. THIS IS A SAFETY CONCERN AS IT IS EXTREMELY DIFFICULT TO SEE WHEN THE WIPERS STOP WORKING UNEXPECTEDLY. THE CAUSE SEEMS TO BE THE WINDSHIELD WASN'T SEALED PROPERLY AT THE FACTORY, AS MY FATHER BOUGHT THE VEHICLE NEW AND SAID THE WINDSHIELD HAS ALWAYS LEAKED. I PURCHASED THE VEHICLE FROM HIM. *TR

ON MAY FIRST OF 2014 MY CHECK ENGINE LIGHT AND OIL LIGHT CAME ON. I ASSUMED I NEEDED OIL, SO I WENT TO THE ADVANCED AUTO STORE AND PURCHASED SOME OIL. I PUT THE OIL IN AND BEGAN TO PROCEED HOME. I WAS DRIVING AND THE OIL LIGHT WAS SHOWING AS HOT. THE CAR WOULD NOT GIVE ENOUGH POWER FOR ME TO DRIVE, IT BEGAN TO SHAKE. THE CAR IS NOT DRIVABLE ANYMORE. IT IS STILL DOING THE SAME THING. AFTER SOME RESEARCH I DISCOVERED THAT THIS CAR'S MAKE AND MODEL IS A RECALL CAR. I NEED TO KNOW WHAT TO DO. *TR

TL* THE CONTACT OWNS A 2000 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, ANOTHER VEHICLE CRASHED INTO THE CONTACTS VEHICLE AND THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT WAS TAKEN TO THE HOSPITAL. THE CONTACT SUSTAINED BACK AND NECK INJURIES. THE VEHICLE WAS TOWED TO AN IMPOUND LOT. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE MILEAGE WAS 107,000. PAM...UPDATED 07/02/14 *BF NO AMENDED TEXT. 07.03.14

THERE IS A DEFECT WITH THE INSTALLATION OF THE WINDSHIELD THAT CAUSES WATER IN ENTER THE CAB. UPON ENTRY, THE WATER GOES INTO THE GEM MOD AND FUSE PANEL OF THE SUV. THIS SHORTS THE SYSTEM - AT ONE POINT YOU MAY ENCOUNTER THE HEATER TURNING ON WITHOUT THE KEY IN THE IGNITION. HERE IS A SPECIAL NOTICE SENT BY FORD IN 2002 REGARDING THIS PROBLEM: *FORD SPECIAL MESSAGE #15773 VARIOUSELECTRICALCONDITIONS RESULTING FROM WATER INTRUSION INTO THE GEM/CJB SOME 1997-2002 EXPEDITION AND 1998-2002 NAVIGATOR VEHICLES MAY EXHIBIT VARIOUS UNUSUAL ELECTRICAL CONDITIONS, INCLUDING BUT NOT LIMITED TO: XXXXX XXXXX REAR BLOWER OR EATC STAYING ON WITH KEY OUT OF THE IGNITION, RADIO STAYING ON AFTER DOORS OPENED AND KEY OUT OF IGNITION, WIPER CIRCUIT FAILURE CODES, AND MULTIPLE SYSTEM WARNING LIGHTS WITH 'SHORT TO POWER' OR 'LOW BATTERY VOLTAGE' DTCS. THESE SYMPTOMS MOST OFTEN OCCUR AFTER A RAIN OR SNOW. THIS MAY BE DUE TO GEM/CJB WATER INTRUSION RESULTING FROM A WINDSHIELD WATER LEAK. TO SERVICE, REMOVE THE GEM AND CJB FROM THEVEHICLE, SEPARATE THEM AND INSPECT FOR WATER CONTAMINATION OR CORROSION. IF FOUND IN EITHER COMPONENT, REPLACE BOTH COMPONENTS AND COMPLETELY RESEAL THE WINDSHIELD. EFFECTIVE DATE: 04/05/2002 FORD MOTOR COMPANY *TR