2015 FORD EXPEDITION Complaints

I was driving and going around 45mph when the wrench warning light came on and I lost the ability to accelerate. The car could only coast. I was able to coast to a parking lot. I turned off the car and restarted it. It seemed fine so I drove home. The same thing happened again a couple of days later. We checked the codes and it had a p2112 error code. We replaced the throttle body and it seems fine now. However this is the second time we have had to replace the throttle body. The same thing happened in 2018 with about 74000 miles on the car. We replaced the throttle body then also. From internet searches this seems to be a common problem. It is a big safety issue since the car loses the ability to accelerate unexpectedly. I was lucky I was able to coast out of the way each time without causing an accident.

During cold starts the engine has a loud rattling sound. The sound goes away after about a minute.

The contact owns a 2015 Ford Expedition. The contact received notification of NHTSA Campaign Number: 22V648000 (Visibility, Electrical System). The contact stated while driving 65 MPH, with the A/C activated, the vents stopped blowing air. The contact unplugged the pig tail off the resistor under the passenger’s side dashboard. The contact stated that the pig tail was red hot and burned. The vehicle was taken to a dealer where it was diagnosed that the motor blower needed to be replaced; however, the failure persisted. The failure mileage was 244,000.

Vehicle was placed in park and rolled down a driveway. Vehicle almost crashed through a house across the street if the owner did not jump in the vehicle and slam the brake. Problem has not yet been reproduced by a dealer. The part has not yet been evaluated by the dealer. Although, the dealer has done improper inspections of broken parts on the vehicle when it was under warranty in an attempt to get out of replacing them, so I do not trust the dealer to do a proper assessment.

I had parked the vehicle in grocery store lot. I had been shopping for 20-30 minutes when I was called to the service desk and was told to go to the parking lot. My car had rolled back across the parking lot aisle and had hit another vehicle. I verified that the car was in park. No one was in the vehicle at the time. It just slipped out of park and rolled. I called Ford Motor Company and they are not going to do anything about it, even though this is a documented problem they have had, just not on my particular year and model combination. They are the ones who suggested I file this report.

The contact owns a 2015 Ford Expedition. The contact received notification of NHTSA Campaign Number: 22V648000 (Visibility, Electrical System). The contact stated that the A/C had stopped working as intended. There was no warning light illuminated. The contact stated that the A/C seat and throttle body plugs were replaced previously due to overheating. The vehicle was taken to a local dealer where it was diagnosed that the wiring harness pigtails needed to be replaced but were not covered under the recall associated with the VIN. The contact was informed by the local dealer that the wiring harness pigtail needed to be replaced prior to the recall repair or the failure listed in the recall could occur. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 175,000.

My ac blower went out, and we took it to a shop. The "pigtail" that connects looks to have been melted. I see there is a recall for this for other 2015 expedition, but 0 recalls for my Vin. NOT sure if I can reach out to ford for this since it's not included in the recall.

The contact owns a 2015 Ford Expedition. The contact stated that the vehicle was parked and shifted into park(P) and the contact exited the vehicle to run errands; however, upon returning to where the vehicle was parked, the contact became aware that the vehicle had rolled away. The contact stated that the failure was intermittent and had started engaging the parking brake whenever the vehicle was parked. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle was not diagnosed or repaired. The manufacturer was informed of the failure. The contact had researched online and related the failure to NHTSA Campaign Number: 22V413000 (Power Train). The failure mileage was approximately 138,000.

For the second time the front brake calipers on my 2015 Ford Expedition have locked up causing premature brake pad and rotor failures, causing the rotors to turn blue because they got so hot, therefore causing my brakes to fade and coast into the intersection. (No accidents yet). First repair was done at a reputable shop under an extended warranty, it is now back in the same shop for the same issue.

There was an open recall on our 2015 Ford Expedition for Blower Motor overheating. After fix a week later we took back in as the issue of no fan was still present and told no longer an open recall as it was marked complete, and would need to pay to have resistor and wiring harness for the blower motor replaced.