2019 FORD EXPEDITION Complaints

The contact owns a 2019 Ford Expedition. The contact stated that while starting the vehicle, there was an abnormal rattling sound detected. There were no warning lights illuminated. The contact called the local dealer but the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure but no additional assistance was provided. The approximate failure mileage was 65,000.

The contact owns a 2019 Ford Expedition. The contact stated upon starting the vehicle, the engine emitted abnormal loud rattling sounds. There was no warning light illuminated. The contact stated while driving 60 MPH, the vehicle would not shift from first gear to the other gears automatically. The contact was able to continue driving. The vehicle was taken to the dealer who informed the contact that the Transmission Control Module (TCM) needed to be reprogrammed; however, the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA for assistance. The contact referenced Ford Customer Satisfaction Program Numbers: 21B10 21N03 and 21N08. The failure mileage was approximately 29,000.

The contact owns a 2019 Ford Expedition. The contact stated that every time he started the vehicle, the engine would rattle and make a loud noise. The contact stated no warning light was illuminated. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined there was manufacturer internal recall 21B10 that was to address a PCM Re-flash failure. The contact was advised by the dealer that his warranty did not cover the repair. The contact did not have the vehicle repaired. The manufacturer had been informed of the failure. The failure mileage was 70,236.

The 2019 Expedition 10 Speed Transmission went into neutral during acceleration from third gear, skipped 4th and finally reengaged in 5th with a huge jolt. This happened a second time after leaving the next stop sign. During the neutral period ( approx. 3 or 4 seconds) engine RPM's increased dramatically with loss of forward motion and speed. My reaction was to remove my foot from the gas pedal before the engine red-lined. This issue could have caused vehicles behind to rear end our 2019 Ford Expedition. The transmission was at full temperature as the expedition had been driven for approx. 30 minutes prior to the issues. We then parked the expedition for about an hour and then started the drive home and the neutral issue occurred once again. The transmission hard shifting issues were first noticed in March/April 2022 had been reprogramed in June, 2022 which didn't resolve the problem. It was then serviced late July 2022 by rebuilding a control module(?). We were told to drive the vehicle for a couple of weeks while the transmission learned how we drive and everything would return to normal. Currently have returned the Expedition to the dealer as this is a serious safety issue. Hard shifting or even jumping a gear with a jolt isn't going be a danger, but losing power and control of the Expedition could have caused an accident and possible injury to us and others.

The first incident I was travelling on the highway at approx 60-70 mph and attempting to overtake a slower car by switching lanes. As I changed lanes and hit the gas, my Expedition became stuck between gears and lost power until I let off the accelerator and the rpm's came down. This happened on several occasions with similar circumstances. The other times it's been stuck between gears are typically when I am turning left. The loss of power and basically being in neutral while on the highway or turning left is a specific safety hazard that needs prompt attention. I am dropping it off at the dealership tomorrow and I'm sure they will be "unable to recreate the problem" and I'll have to wait until the recall for it to be fixed.

The Sync 3 System (APIM module) is faulty. Causing phone to connect/disconnect constantly, radio controls are delayed for 30 sec pauses or greater, changing from radio to climate will superimpose both categories on top of one another. Navigation sometimes just loads and loads and never comes on. The steering wheel controls create an even longer delay. I went to my local Ford dealer and had a master reset done which did not change the issues and was told that one or both of the modules is not working right "Malfunctioning " Latest updates to both the Sync and Navigation were preformed after the factory reset with no improvement to the system. With new state laws requiring hands free phone usage having the phone connect/disconnect constantly poses a very large safety problem. Also not being able to rely on the system to preform basic functions in a reasonable period of time causes your eyes to leave the road unnecessarily while driving.

This vehicle has only 10300 miles and never driven off road and the struts have failed. An independent garage confirmed the drivers side front strut is leaking and both rear. My Ford dealer stated they would replace the front and one rear under warranty but the second rear strut is leaking within Ford's "tolerances". This is just Ford's way of avoiding a warranty claim and hoping the bad leaking doesn't start until after the customer's warranty expires so they can reap thousands of dollars in repair revenue. I was also told by the Ford dealership that the FoMoCo replacement struts often arrive at the dealership leaking and they would not call me in for an appointment to replace until they have confirmed they received replacement struts that are not defective. My research shows this is a common problem with this vehicle and the NHTSA should investigate and force a recall since failed struts can cause a serious accident.

My family received a notice of Customer Satisfaction Program 21N08 – PCM Reprogram Due to Engine Shudder – 2017-2020 Ford F-150, 2018-2020 Expedition, & 2018-2020 Lincoln Navigator. We immediate began trying to locate an authorized repair facility. It took several months to get an appointment. During this time, our vehicle shuddered, stopped, and even turned off completely while driving. The problem continued to increase in intensity. When we were able to get the vehicle into a Ford dealership, they suggested that we contact Ford for the repairs that we needed. A private repair facility told us that now, because the shudder issue was not resolved right away, they discovered VCT phasers, VCT solenoids, timing chains and tensioners - failed setting code P0021 and causing engine to run rough. There was a loud rattle on startup which is related. P0018 stored in history. We have received a $4,000 repair estimate. I contacted Ford Customer service. They suggested I bring it into Ford Dealership. I explained that it had taken months to get in the first time. Customer service refused to provide me with additional authorized Ford repair (non dealers) in my location. Customer service refused to provide me with information on the error codes above. Customer service refused to provide me with more information concerning the PCMC reprogram and the known problems related to failing to obtain the reprograming. Customer service was not able to help me at all. I believe that the “PCM reprogram due to engine sudder” should be investigated as a potential formal recall program. Ford should repair of known issues a priority for their customers, and should also repair issues caused by failing to allow their customers to receive a timely remedy of this problem. I would also like more information on known issues with the PCM reprogram and engine shudder. I would like to view the quarterly reports.

The vehicle only has 38K miles on it and all 4 struts have failed. This is apparently a very common problem for Ford. This creates control issues and an unsafe ride. I had the vehicle in for a different recall and the Ford dealership confirmed all 4 are leaking and need to be replaced, but Ford will not cover them.

Both the driver side and passenger side front struts have leaked oil and failed. The driver side occurred after 33,000 miles and the passenger side at 45,000 miles.