1997 FORD EXPEDITION Complaints

I PULLED UP TO MY HOUSE AND AFTER EXITING THE VEHICLE IT BEGAN SMOKING THEN CAUGHT A FIRE UNDER HOOD. FIRE WAS PUT OUT WITH WATER HOSE. *TR

TL* THE CONTACT OWNS A 1997 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, A LOUD BANGING NOISE WAS HEARD AND THE VEHICLE BEGAN TO SHAKE. THE VEHICLE WAS TOWED HOME AND THE CONTACT NOTICED THAT ONE OF THE SPARK PLUGS FRACTURED AND DESTROYED THE MOTOR. THE MOTOR AND SPARK PLUGS WERE REPLACED. THE FAILURE HAD SINCE RECURRED THREE TIMES. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 150,000.

TL* THE CONTACT OWNS A 1997 FORD EXPEDITION. THE CONTACT STATED THAT THE FUEL TANK STRAPS FRACTURED AS A RESULT OF CORROSION. THE CONTACT MENTIONED THAT THE FRAME ON THE DRIVER SIDE WAS ALSO AFFECTED BY CORROSION. THE VEHICLE WAS TAKEN TO THE DEALER WHO VERIFIED THE FAILURE AND ADVISED THAT THE VEHICLE COULD NOT BE REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 45,000.

THE STRAPS HOLDING THE GAS TANK IN PLACE HAVE RUSTED OUT CAUSING THE GAS TANK TO SEPARATE FROM THE VEHICLE. *TR

THE VEHICLE WAS PARKED IN THE DRIVE WAY AND CAUGHT FIRE AT 2 IN THE MORNING. *TT

THE REAR LOWER TRAILING ARMS THAT HOLD THE REAR AXLE IN PLACE ARE MADE TOO THIN AND WITH CORROSION WILL FAIL. THIS WILL CAUSE THE REAR AXLE TO MOVE BACKWARD AND BREAK THE DRIVE SHAFT. *KB

TL* THE CONTACT OWNS A 1997 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING 5 MPH OVER A SMALL BUMP IN THE ROAD, THE SPARE TIRE DETACHED FROM UNDERNEATH THE VEHICLE. THE CONTACT EXAMINED THE VEHICLE AND NOTICED THAT THE CABLE WHICH HELD THE SPARE TIRE IN PLACE FRACTURED DUE TO RUST. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA. THE FAILURE AND CURRENT MILEAGES WERE 156,000.

1997 FORD EXPEDITION SPONTANEOUSLY COMBUSTED IN TARGET PARKING LOT ABOUT 2 HRS AFTER THE DRIVER PARKED IT THERE AND WENT IN TO WORK. THE AFT AREA OF THE ENGINE COMPARTMENT, THE FRONT DRIVER AND PASSENGER SEATING AREA AND MOST OF THE BACK SEATS WERE MELTED AND BURNED. THE FIRE WAS PUT OUT BY DENVER FIRE DEPT. SOUNDS MUCH LIKE MANY INTERNET REPORTED ISSUES WITH "FORD EXPEDITION CRUISE CONTROL SWITCH FIRES". *TR

TL* THE CONTACT OWNS A 1997 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, HE BEGAN TO ROLL THE FRONT PASSENGER SIDE WINDOW DOWN. WHILE ROLLING THE WINDOW DOWN, IT DROPPED DOWN INTO THE DOOR PANEL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP WHERE THE CONTACT WAS INFORMED THAT THE WINDOW DETACHED FROM ITS TRACK, ALLOWING IT TO DROP DOWN INTO THE DOOR PANEL. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN. UPDATED 08/01/11*LJ UPDATED 09/19/11

TL* THE CONTACT 1997 FORD EXPEDITION. THE CONTACT STATED THE STEERING BOLT ON THE VEHICLE BROKE. THE CONTACT FOUND NHTSA RECALL CAMPAIGN IN NUMBER: 03V196000 (STEERING: GEAR BOX: SHAFT SECTOR), BUT WAS TOLD BY THE MANUFACTURER THAT HIS VEHICLE WAS NOT INCLUDED. THE FAILURE AND CURRENT MILEAGES WERE 105,000.