1997 FORD EXPEDITION Complaints

OUR 1997 FORD EXPEDITION EJECTED A SPARKPLUG, MULTIPLE TIMES IN THE PAST YEAR. WAS HELICOILED AND STILL DAMAGED MOTOR TO THE POINT OF REBUILD OR REPLACING MOTOR. HAPPENED DURING A HOLIDAY TOWING OUR BOAT, VERY LUCKY IT DIDN'T HURT ANYONE. WE HAD TO HAVE BOAT AND FORD TOWED, RUINED OUR VACATION, THANKS TO HAVING A CLASS A DRIVER BEHIND THE WHEEL MINIMIZED A MAJOR ACCIDENT. *TR

THERE IS EXCESSIVE PLAY IN THE STEERING WHEEL, IT ROCKS FROM SIDE TO SIDE. I AM A MECHANIC SO I REPLACED BOTH SHAFT BEARINGS BUT THIS DID NOT CURE THE PROBLEM. THE UPPER STEERING SHAFT WILL NEED TO BE REPLACED BECAUSE THE YOKE IS WEARING OUT CAUSING THIS CONDITION. IF THE YOKE SHOULD SNAP THE ABILITY TO STEER WILL BE LOST AND CAN CAUSE DEATH. THIS IS A CRUCIAL AND CRITICAL STEERING COMPONENT THAT SHOULD LAST THE LIFE OF THE VEHICLE. CAN YOU LET ME KNOW IF THIS IS COVERED BY THE MANUFACTURER AS THIS REPAIR WILL HAVE TO BE DONE ASAP. ALSO THE REAR LOWER CONTROL ARMS ARE RUSTED OUT THEY ACTUALLY HAVE HOLES IN THEM I WOULD LIKE TO KNOW IF THIS WOULD BE COVERED AS WELL. THIS VEHICLE IS WELL MAINTAINED, I HAVE DRIVEN A LOT OF DIFFERENT VEHICLES AND NEVER SEEN STEERING AND SUSPENSION PARTS WEAR OUT LIKE THIS BEFORE. THEY DON'T MAKE THEM LIKE THEY USED TO. I LIKE MY TRUCK THOUGH,I WILL BUY ANOTHER FORD IN THE FUTURE, BUT FOR RIGHT NOW I GOT TO KEEP THIS ONE ROLLING DOWN THE HIGHWAY. THANKYOU *TR

MY BRAKES STARTED SQUIKING, AND THAT WENT ON FOR ABOUT A WEEK AND THEN IT BECAME HARD FOR ME TO STOP. SO NOW I HAVE A LOT OF SQUIKING AND I HAVE TO STOP WAY BEFORE I AM SUPPOSE TO. I BOUGHT SOME BRAKE PADS THAT DID NOT FIX THE PROBLEM. *TR

I HAVE A 1997 FORD EXPEDITION, ENGINE COILS WERE REPLACED , CHECK ENGINE LIGHT WENT OFF AND THERE WAS NO JUMP IN ACCELERATION. 2 WEEKS LATER CHECK ENGINE LIGHT BACK ON. *TR

WHILE DRIVING MY 1997 FORD EXPEDITION XLT 5.4L V8 TRUCK A SPARK PLUG BLEW OUT OF THE HEAD OF THE ENGINE. THIS IS THE SECOND TIME THAT IS HAPPENED, THE FIRST BEING IN AUGUST, 2007. THIS SAME PROBLEM OCCURRED ON 2 DIFFERENT SPARK PLUGS. EACH TIME, THE PLUG BLEW OUT AND THE ENGINE MADE A POPPING SOUNDS LIKE A BADLY TUNED LAWNMOWER. I WAS ABLE TO GET TO A DEALER THE SECOND TIME, THE FIRST TIME I HAD TO BE TOWED. THROUGHOUT THE TIME I HAD TO DRIVE THE CAR THIS WAY, GAS VAPORS WERE COMING OUT OF THE CYLINDER AT EACH TURN OF THE PISTON. THIS SOUNDS TO BE A COMMON PROBLEM WITH THE 5.4L ENGINES FROM FORD. *TR

TL*THE CONTACT OWNS A 1997 FORD EXPEDITION. THE CONTACT STATED THAT HE IS UNABLE TO SHIFT THE TRANSMISSION FROM ONE OF THE DRIVE GEAR POSITIONS INTO THE PARK POSITION. THE FAILURE OCCURRED EVEN THOUGH THE GEAR SHIFT SELECTOR WOULD INDICATE PARK, WHICH ALLOWS UNINTENDED VEHICLE MOVEMENT. THE MANUFACTURER STATED THAT THEY WERE NOT RESPONSIBLE FOR ANY REPAIRS SINCE THE VIN WAS EXCLUDED FROM NHTSA CAMPAIGN ID NUMBER 97V171000 (POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL)). THE VEHICLE HAS NOT BEEN REPAIRED ACCORDING TO THE RECALL. THE FAILURE AND CURRENT MILEAGES WERE 166,000.

ENGINE MAKING A LOAD NOISE AFTER TRAVELING TO MY INLAWS WHICH WAS 216 MILES PULLED OVER NOTICED NUMBER 8 CYLINDER HAD BLOWN THE SPARK PLUG OUT OF THE BLOCK 2 MONTHS PRIOR NUMBER 3 CYLINDER BLEW OUT AND IN 2008 NUMBER 1 CYLINDER BLEW OUT PLUG FROM THE BLOCK. I HAVE BEEN IN TOUCH WITH FORD MOTOR COMPANY THEY THERE WAS NOTHING THEY COULD DO. *TR

RUBBER BRAKE LINE SEPARATED AT THE CALIPER. CAUSED TOTAL LOSS OF BRAKING POWER. LUCKILY I WAS PULLING INTO THE DRIVEWAY AT A SLOW SPEED WHEN THIS HAPPENED. *TR

WAS DRIVING HOME FROM WORK, HEARD A LOUD NOISE AND TRUCK GOT REALLY LOUD. GOT IT HOME CHECKED IT OUT. THE SPARK PLUG BLEW OUT. HAD TO TAKE IT TO A DEALER AND GET A NEW INSERT PUT IN CAUSE IT WAS STRIPPED. *TR

1997 FORD EXPEDITION HAS WATER IN STEREO CAUSING ELECTRICAL FIRE IN DASH. NO WATER LEAKS FOUND. WINDSHIELD WAS RESEALED AND WATER TESTED. *TR