2006 FORD EXPEDITION Complaints

AS I WAS DRIVING MY EXPEDITION, THE TRUCK SUDDENLY SHUT COMPLETELY OFF AND I HAD TO POWER STEERING AND THEN IN THE MESSAGE CENTER IT SHOWED "ENGINE FAILSAFE MODE". I HAD TO PUT MY FLASHERS ON AND COAST TO A STOP IN THE LANE I WAS IN AND COME TO A COMPLETE STOP BEFORE I COULD RESTART MY TRUCK. I WAS UNABLE TO SWITCH LANES OR MOVE TO A SAFER LOCATION BECAUSE I HAD NO POWER STEERING. I HAD THE SAME THING HAPPEN IN MARCH OF 2009 WHEN I WAS GOING 60 ON THE INTERSTATE IN THE MIDDLE LANE AND LOST ALL POWER AND HAD TO COAST TO A STOP IN THAT LANE WITH MY FLASHERS ON HOPING EVERYONE AROUND ME WOULD SEE I WAS HAVING CAR TROUBLE. I HAD 3 OF MY KIDS IN THE TRUCK WITH ME. IN 2009 I TOOK IT INTO THE FORD DEALERSHIP AND THEY SAID IT WAS THE THROTTLE BODY AND REPLACED IT WHICH COST ME $536.00. IN 2009 IT HAPPENED 5 TIMES BEFORE IT WAS FIXED. I TOOK THE TRUCK IN TODAY AND THEY SAID AGAIN ITS THE THROTTLE BODY AND BECAUSE IT'S BEEN 5 YEARS THE OTHER ONE IS NO LONGER UNDER WARRANTY. SO NOW I'M GETTING A NEW THROTTLE BODY PUT IN. I EMAILED FORD CORPORATE AND WAS BASICALLY TOLD THAT THERE IS NO CURRENT RECALL NOR PLANS FOR ONE SO THERE'S NOTHING THEY CAN DO FOR ME! *TR

THIS IS THE SECOND INCIDENT: THE FIST WAS ABOUT 3 MONTHS AGO. I WAS DRIVING DOWN A RESIDENTIAL STREET YESTERDAY WHEN THE "FAIL SAFE MODE" INDICATOR CAME ON AND SAID ENGINE SHUTTING DOWN. CAR TURNS OFF, CANNOT STEER. VERY DANGEROUS. I WAS ON A RESIDENTIAL STREET AND WAS ABLE TO PULL OFF. TURNED THE CAR OFF FOR A FEW MINUTES AND IT STARTED AND I DROVE TO WORK, BUT THE ENGINE LIGHT REMAINED ON. I TOOK IT TO AN AUTO PARTS STORE WHO RAN IT AND IT CAME UP AS THROTTLE BODY FORCES IMMEDIATE IDLE. WHICH IS EXACTLY WHAT THE 10 PAGES ON COMPLAINTS ON CARCOMPLAINTS.COM SAID IT WOULD SAY - HOWEVER INFORMATION ON THAT SITE ALSO SAID IT'S ACTUALLY THE FUEL PUMP MODULATOR, BUT THE COMPUTER DID NOT INDICATE THAT AT ALL. THERE WERE ALMOST 60 COMPLAINTS OF THE SAME SITUATIONS - WHEN I PULLED OUT INTO TRAFFIC TODAY THE CAR 'HESITATED' AND DID NOT ACCELERATE CORRECTLY. THE FIRST INCIDENT OCCURRED ON A MAJOR HIGHWAY - AND AGAIN I WAS LUCKY ENOUGH TO BE IN THE RIGHT LANE AND WAS ABLE TO PULL OVER. THIS DEFECT IS GOING TO CAUSE AN INJURY OR EVEN DEATH AND IT NEEDS TO BE RECALLED AND CORRECTED. I WILL BE CONTACTING FORD CORPORATE; BUT WITH THE RECENT INCIDENTS WITH GM I WOULD HATE TO SEE AN ACCIDENT OR FATALITY OCCUR WHEN FORD AND OTHERS ARE AWARE OF THIS PROBLEM. OBVIOUSLY I HAVE TO GET THIS FIXED, I'M HOPING MY FORD DEALER WILL WORK WITH ME, BUT I HAVE A 4 YEAR OLD SO TIME IS OF THE ESSENCE AND I'M GUESSING MONEY WILL BE TOO. REGARDLESS OF FORD'S CORPORATE RESPONSE, I WILL BE CONTACTING THE MEDIA. THIS IS A SAFETY ISSUE AND IS UNACCEPTABLE THAT FORD IS NOT TAKING RESPONSIBILITY. *TR

RUST IN THE CHANNELS OF THE ROOF HAS PENETRATED COMPLETELY THROUGH THE SHEET METAL. VEHICLE HAS BEEN WELL MAINTAINED AND IS OTHERWISE IN PERFECT CONDITION. *TR

CAR JUST DIED ON HIGHWAY JUST SHUT OFF WOULD NOT RESTART. AFTER LOOKING AT IT THE FPDM WAS CORRODED AND BAD. THIS HAS BEEN A INTERRMTINT PROBLEM AND HAS ALMOST CAUSED ACCIDENTS WHEN CAR STALLS WHEN DRIVING AT INTERSECTIONS AND SUCH ALUMINUM AND STEEL DONT WORK WELL UNDER A CAR AND CORRODE VERY BADLY. *TR

I WAS DRIVING AROUND 46MPH, AND IN THE MIDDLE OF DRIVING, MY TRUCK CUT OFF FOR AROUND 5 SECONDS. I ALMOST GOT BY THE TRUCK BEHIND ME. MY TRUCK KICKED BACK ON BY ITSELF, ALL WHY I WAS DRIVING. I WAS SO TERRIFIED THE TRUCK BEHIND ALMOST REAR ENDED ME. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE FAIL SAFE MODE WARNING LIGHT ILLUMINATED AS THE VEHICLE INDEPENDENTLY DECELERATED AND STALLED. THE VEHICLE WAS TOWED TO THE DEALER, WHO STATED THAT THE THROTTLE BODY WOULD NEED CLEANING. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED SEVERAL MONTHS LATER. THE VEHICLE WAS TAKEN BACK TO THE DEALER, WHO STATED THAT THE ENTIRE THROTTLE BODY WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURE WAS CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 96,000.

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT THE VEHICLE WOULD ENGAGE INTO SAFE MODE WHEN STARTED, CAUSING THE VEHICLE TO STALL. THE FAILURE WAS RECURRING OVER A THREE YEAR SPAN. THE VEHICLE WAS TAKEN TO A DEALER AND REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE WAS 70,000.

WHILE DRIVING APPROXIMATELY 35 KPH MY ABS LIGHT CAME ON FOLLOWED BY THE BRAKE LIGHT THEN THE AIRBAG LIGHT. (CHECK ENGINE NEVER GOES OFF. REPLACE ALL PLUGS AND COILS. REPLACE OF SENSORS AND SEVERAL FUSES.) THE HEADLIGHTS BEGIN TO FLASH OFF AND ON THEN TRUCK STARTED SPUTTERING. THE FUEL LIGHT WENT FROM 3/4 TANK TO E. I PULLED INTO SHOPPING CENTER PLACED IT IN PARK. WENT TO PUT IT BACK IN DRIVE AND COULDN'T SOMETHING WAS DRAINING BATTERY THAT IS ONLY 3 MONTHS OLD. DON'T KNOW RESOLUTION BUT TIRED OF THIS TRUCK! IT IS RIDICULOUS THAT THIS TRUCK HAS SO MANY REPEAT ISSUES AND NO RECALL. FORD NEEDS TO BE SUED. I DAILY HAVE TO TURN ON MY HAZARDS AND RESTART CAR BECAUSE IT SPONTANEOUSLY GOES INTO LIMP MODE, ESPECIALLY IN TRAFFIC. *TR

DRIVING AT 25MPH THE VEHICLE ENGINE SHUT DOWN AND WENT INTO FAILSAFE MODE, POWER STEERING ALSO DISABLED CAUSING A VERY DANGEROUS SITUATION TRYING TO STEER THE CAR FROM TRAFFIC TO A SAFE AREA WITHOUT ASSISTED STEERING. THIS PROBLEM HAS OCCURRED SEVERAL TIMES OVER THE PAST 2 YEARS AND USUALLY IN COLDER WEATHER. LAST TIME IT HAPPENED WAS ON A MAIN HIGHWAY BUT LUCKILY I WAS ALONE WITHOUT MY FAMILY AND IN THE INSIDE LANE SO I WAS ABLE TO PULL OVER THANKFULLY IT DIDN'T HAPPEN IN THE OVERTAKING LANE AS THERE IS NO TIME TO SAFELY CHANGE LANES WHEN IT SHUTS DOWN. SURPRISED THERE HAS BEEN NO FATALITIES DUE TO THIS AS IT IS A COMMON PROBLEM WITH 2006 FORD TRUCKS. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING BETWEEN 45 TO 50 MPH, THE VEHICLE STALLED AND THE ENGINE FAIL SAFE LIGHT ILLUMINATED. THE CONTACT WAS ABLE TO COAST TO THE SHOULDER WHERE THE VEHICLE WAS RESTARTED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO STATED THAT THE THROTTLE BODY WAS NOT OPENING AND CLOSING CORRECTLY. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 60,000 AND THE CURRENT MILEAGE WAS 75,000.