2006 FORD EXPEDITION Complaints

the service engine light continues to turn on. the timing belt continues to fail and has already been replaced once. the camshaft on both sides have been replaced. the solenoids have also been replaced and the diagnostics codes still pop up (p0022) (p0021) are just some that i can remember. the engine does not have enough power on the driver side and throws the timing belt off which causes the loud rattle coming from the engine. when reaching the speed of 40-45 mph the truck begins to shake. recently in november 2023, when fueling up with gas , the truck began to shake and not respond. when accelerating, the truck takes off very slowly and the gears dont kick in on time. when the gas light comes on , the truck begins to function well. but as soon as i put gas again. it feels like the truck is going to fall apart. the driver door gets stuck when trying to open from the inside. the back door on the left does not open from the outside. the gear handle can be moved up and down while the truck is not turned on. please help!!

The contact owns a 2006 Ford Expedition. The contact stated that while driving 35 MPH, the contact stated that there were exhaust fumes inside the vehicle. The engine warning light was illuminated. The vehicle was diagnosed by an independent mechanic and confirmed the failure was a defective charcoal canister for the evac system. The vehicle had not been repaired. The manufacturer was made aware of the failure however, the part was not available. The failure mileage was approximately 70,000.

The contact owns a 2006 Ford Expedition. The contact stated that while driving at a low rate of speed, the vehicle would independently accelerate upon depression of the accelerator pedal without warning. During a recent failure, the contact crashed into a fence as part of the fence had become wedged underneath the vehicle. After placing the vehicle into park and exiting the vehicle, the wheels continued to move. The air bags did not deploy upon impact. Despite minor soreness to his neck, no medial attention was required. A police report was not filed. Despite the failure, the contact managed to restart the vehicle and safely to his destination. The fence sustained severe damage as a result of the failure. The dealer nor the manufacturer had yet to be notified of the failure. The vehicle had yet to be diagnosed or repaired. The failure mileage was approximately 220,000.

The contact owns a 2006 Ford Expedition. The contact stated while driving 55 MPH, the vehicle was driving sluggishly. The contact stated that the check engine warning light was illuminated. The vehicle was not drivable. The contact towed the vehicle to an independent mechanic and was informed that the ignition coil, the throttle body sensor (TBS) sensor, and the timing chain needed to be replaced. The vehicle was not repaired. The vehicle was not diagnosed or repaired at the dealer. A dealer was not contacted. The manufacturer had been informed of the failure. The contact stated on another occasion the vehicle failed to start. The vehicle was not drivable. The failure mileage was approximately 130,000.

While driving yesterday i heard a pop. The 4th coil pack literally blew out from its spot. I have now had 3 coil packs blow out at random causing the holes that the bolt straps the coil pack to the spark plug to strip out. I have a transmission leak that will not stop and I've taken it in multiple times for repairs and it still is leaking. Since getting this vehicle i noticed at the electrical issue where everything including my headlights will shut off and then pop back on while I'm driving. My seat belt will not open so i can buckle and I'm now getting frustrated because I've spent a lot of money on this only to realize has had the same issue with previous owners and they for some reason were too embarrassed to report it but I'm not and I'm sick of dumping money into this damb thing!

UPON RECEIVING TUNE UP THE SPARK PLUGS BROKE APART.AFTER GETTING THEM OUT CYL#1 WOULD NOT HOLD SPARK PLUG,CAUSED ME TO SPEND MORE MONEY TO GET PROBLEM FIXED.BUT THE SHOPS WILL NOT GUARANTEE THE WORK THAT IS NEEDED.THEY ALL SAID IT WAS A FACTORY ISSUE.THE TRUCK WAS STATIONARY AS WELL.

TL* THE CONTACT CALLED ON BEHALF OF THE OWNER OF A 2006 FORD EXPEDITION. WHEN THE VEHICLE WAS STARTED, THERE WAS AN ODOR OF ANTIFREEZE IN THE VEHICLE. ADDITIONALLY, THE TEMPERATURE GAUGE AND CYLINDER HEAD TEMPERATURE SWITCH BECAME INOPERABLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE INTAKE MANIFOLD AND CYLINDER HEAD TEMPERATURE SWITCH NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 245,000.

TRAVELING ON OLD ADOBE RD IN PETALUMA, CA AT APPROX. 25-30 MPH, WENT OVER INCLINE AND SAW TRAFFIC WAS STOPPED. PRESSED HARD ON BRAKE PEDAL AND VEHICLE SLOWED BUT DID NOT STOP. RESULTED IN A 3 CAR ACCIDENT

TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. WHILE DRIVING APPROXIMATELY 40 MPH, THE FRONT PASSENGER SIDE WINDOW SHATTERED. THERE WERE NO INJURIES. THE CONTACT STATED THAT THE WINDOW WAS NOT STRUCK BY DEBRIS OR A FOREIGN OBJECT. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 178,000.

THE VEHICLE EXPLODED IN OUR DRIVEWAY. IT HAD NOT BEEN DRIVEN OR TURNED ON IN ALMOST 2 WEEKS. IT WAS LOCKED. THIS CAUGHT ONE OTHER CAR ON FIRE AND TO EXPLODED AND ANOTHER TO GET BODY MELT DOWN ON ONE SIDE.