2021 FORD EXPEDITION Complaints

Travelling down interstate at speed and right rear quarter panel came loose, was flapping around behind and beside vehicle and partially tore free. This presents a high speed debris hazard.

Follow up to my previous complaint (11665325)see link below. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My Ford expeditions transmission is causing unsafe driving with rough sound and thunking noise. There is a C,D,F issue and valve separator parts that are the initial issue that can cause major issues for me and many others. A Ford technician advised me that TSBs exist and made me aware that my cost could be $199 (diagnostics), $1500 (parts), and $4400 or more (transmission repair or replacement). Why is this danger still be allowed with a well known issue. The problem started and appears to be getting worse. Why is Ford being held accountable for this lack of quality in their vehicles.

May 17th was trying to get over one lane on service road, gave car gas and it acted like it fail out of gear, let off gas and then it was fine. Did the something again about 4 hours later. Car only has 94,000 miles on it and dealership is saying that it needs a new transmission. I have never hauled anything with this car, only driving on the highway. I did take my Ford in at 57,000 because it was rough sounding when it would change gears. They said they couldn't find anything wrong. Now we need a new transmission and it is out of warranty of course. I just don't see how this transmission could not last longer then 94,000 miles. The note on the car still has a few years left on it. There are not active recall per Ford Relationship Center. I also have a claim with them as well. They told me to made a claim there as well.

I purchased a 2021 Ford Expedition and it has 37,000 miles on it and the transmission shifts hard when putting the vehicle in drive. The vehicle jerks violently. Also when driving down hils the transmission jerks. The vehicle shouldn't have transmission problems already. The transmission in this vehicle should have a recall. The Ford company is aware that there is an issue and they should fix the issue or replace the transmission for their consumers. I have a 2012 Expedition that doesn't have this problem and it has 280,000 miles on it.

The vehicles jerks when shifting, pops out of gear while driving, takes a long time to find the next gear, is delayed when doing from R to D. Yesterday, 05/14/2025, I took a left turn and drove maybe .2 of a mile and the car jerked very hard and popped out of gear. The car slowed down to almost a complete stop before it finally found a gear and I could accelerate. My children and I were in the car, I was afraid it was going to stall out and we would be sitting in the middle of the road and get hit. The road we were on had no shoulder. This isn't the first time this has happened, but it was the most severe.

This recall was issued in January 2025, we are rolling in to month 4 here, this vehicle is used for business and cant drive it while it has an open recall per insurance, we have lost out on almost 4 months of income on this vehicle along with loan payment of 4 months, I feel like Ford has not taken this serious and is taking their time considering its a little older model SUV. Not sure if there is some type of compensation for this from Ford on the delay of this fix. Also, we have had no issues with our rear camera on this vehicle; everything works fine.

The contact owns a 2021 Ford Expedition The contact stated while driving at an undisclosed speed, the transmission unexpectedly downshifted. The transmission warning light was illuminated. The vehicle was able to be restarted. The vehicle was taken to the dealer, where it was diagnosed with transmission failure and the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 79,000.

The contact owns a 2021 Ford Expedition. The contact stated while driving 10 MPH, the vehicle became stuck in first gear. The driver was able to maneuver the transmission into fourth gear. The contact turned the vehicle on and off, and the transmission was reset. There were no warning lights illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 20V197000 (Power Train). The vehicle was taken to the local dealer, and was diagnosed with CDF drum failure, and that the transmission needed to be rebuilt or replaced. The vehicle was not repaired. The vehicle was taken to an independent mechanic, who determined that the transmission needed to be rebuilt. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 78,000.

The transmission has started to delay engagement into drive and reverse which causes the ability for the vehicle to unexpectedly roll in either direction. The vehicle also shifts erratically and in a rough manner while driving causing the driver(s) to either hesitate acceleration and or cause a sense of urgency to stop. It was brought to my attention from repair/transmission shops that this is a common problem with this particular transmission and calls for a new replacement or rebuild. The issue is very noticeable when driving as stated by the driver(s) and auto repair mechanics/employees.