2002 FORD EXPLORER Complaints

MY 2002 FORD EXPLORER 4.6L IS HAVING MAJOR TRANSMISSION PROBLEMS AT ONLY 110K MILES. IT HESITATES SHIFTING GEARS AND SLIPS WHILE DRIVING. THE VEHICLE ALSO STALLS WHEN STOPPING AT A RED LIGHT OR STOP SIGN. IT HAS THE INFAMOUS CRACK DOWN THE BACK HATCH. BOTH ARE PROBLEMS THOUSANDS OF CUSTOMERS HAVE COMPLAINED ABOUT YET FORD DOES NOTHING. THE TRANSMISSION PROBLEM IS A VERY EXPENSIVE COST TO REPAIR AND IT SHOULDN'T BE THE CUSTOMERS RESPONSIBILITY WHEN FORD KNEW THERE WAS A PROBLEM.

AS I WAS OUT DRIVING ONE DAY, I PULLED OFF FROM A GREEN LIGHT AND OUT OF NOWHERE THE "SERVICE ENGINE LIGHT" AND THE "O/D LIGHT" BOTH TURNED ON AT THE SAME TIME. AT THE SAME TIME I NOTICED THAT THE TRUCK BEGAN TO SHIFT VERY POORLY COMING OUT OF 1ST AND 2ND GEAR. IT IS NOW TO THE POINT WHERE THERE IS A REALLY LOUD "CLUNK" EVERY TIME THE TRUCK SHIFTS, ESPECIALLY IN THE LOWER GEARS AND WHEN PUTTING THE TRUCK IN REVERSE. I PULLED OVER TO ENSURE THAT IT WASN'T SOMETHING I HAD DONE AND IT WASN'T! I LET THE CAR SIT FOR A FEW HOURS HOPING THAT WOULD CLEAR THE ISSUE, BUT NO LUCK! AFTER MUCH RESEARCH ON THE PROBLEM THIS IS A VERY WELL KNOWN PROBLEM BY FORD MOTOR COMPANY AND NOTHING HAS BEEN DONE TO RESOLVE IT FOR THEIR CUSTOMERS. I PURCHASED THIS VEHICLE JUST UNDER A MONTH AGO AND ALREADY I'M LOOKING AT $2,000 TO PUT IN A NEW TRANSMISSION. WELL AFTER PURCHASING THE VEHICLE I CAN NOT AFFORD TO FIX FORD'S MISTAKE!!! THIS IS A CLEAR DEFECT OF A FORD PRODUCT AND AFTER SPENDING MY HARD EARNED MONEY ON ONE OF THEIR PRODUCTS I EXPECT MUCH BETTER FROM THEM! EVEN AFTER SPENDING $2,000 ON ANOTHER TRANSMISSION, IT IS A SURE FACT THAT IT IS ONLY INEVITABLE THAT THIS PROBLEM WILL HAPPEN AGAIN AND AGAIN AND AGAIN TO ANYONE WHO PURCHASES A 2003 FORD EXPLORER! IF I AND I'M SURE ANYONE ELSE WOULD'VE KNOWN THIS FACT, I'M POSITIVE; FORD WOULD HAVE NOT SOLD AS MANY MODELS. CAN WE SAY BAMBOOZLED AND TAKEN FOR MY MONEY BY FORD MOTOR COMPANY! PLEASE HELP US CUSTOMERS OUT AND DEMAND A RECALL ON THESE POORLY BUILT COMPONENTS THEY MASS PRODUCED AND STUCK INSIDE A WIDELY MARKETED AND SOLD VEHICLE. HOW WOULD YOU FEEL IF YOU AND YOUR INFANT CHILD WAS DRIVING AND OUT OF NOWHERE...BOOM...ANOTHER $2,000 YOU DO NOT HAVE FOR ANOTHER POORLY BUILT FORD TRANSMISSION SMH... ## VIN FAILED ## [XXX] ## INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

TL* THE CONTACT OWNS A 2002 FORD EXPLORER. WHILE THE GEAR SHIFTER WAS SHIFTED INTO THE PARK POSITION, THE FOUR WHEEL DRIVE SHIFTED. WHILE DRIVING 10 MPH, THE FOUR WHEEL GEARS SHIFTED AGAIN. THE CONTACT ACTIVATED THE GEAR BUTTONM BUT IT DID NOT WORK. THE VEHICLE MANAGED TO PLACE ITSELF BACK INTO DRIVE GEAR. THE WARNING LIGHTS DID NOT ILLUMINATE. THE FAILURE OCCURRED NUMEROUS TIMES. THE DEALER WAS NOT NOTIFIED. THE MANUFACTURER WAS NOTIFIED. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 145,819.

CHECK ENGINE LIGHT CAME ON WENT TO A AUTO REPAIR SHOP AND WAS GIVEN OEM CODE P0442 (EVAPORATIVE EMISSION SYSTEM). THE SCENT OF GAS WAS PRESENT. I CHANGED THE FUEL CAP AND ISSUE STILL REMAINS. GAS FUEL TANK VAPOR VENT CHECK VALVE IS DEFECTIVE AND MUST BE REPLACED.

TURNED CAR ON TO DRIVE IT WOULD NOT START AFTER SEVER RAINFALLS UNTIL FINALLY WHEN I DID THE LAST TIME AFTER A JUMP, BATTERY NEW. IT STARTED TO MAKE THIS AWFUL NOISE LIKE A CLANKING SOUND LIKE A CHAIN SOUND. I TOOK IT TO A MECHANIC AND HE DID NOT KNOW WHAT THE PROBLEM WAS, CALLED A MOBILE MECHANIC AND HE SAID THE SAME THING SAID IT COULD BE A VALVE OR PISTON PROBLEM. FROM WHAT I HEAR SOUNDS LIKE A CHAIN. BEFORE THIS HAPPENING THE REAR WINDOW REGULATORS FOR THE REAR PASSENGER WINDOWS RIGHT AND LEFT SIDES BROKE. HAD LEFT SIDE FIXED RIGHT SIDE NOT FIXED, GLASS STILL HELD WITH A BOARD INSIDE DOOR.

ON FEB.12 2016 STILL NO DASH WARNING LIGHTS MY FORD TRAC..I LEFT MY HOME IN DRIVE MOVED ONTO HIGHWAY 66, THE TRUCK WOULD NOT SHIFT AS I TRIED TO INCREASE MY SPEED UP ONTO THE 66 HIGHWAY THE RPM RAN UP ONLY, I HAD TO SHIFT INTO SECOND GEAR TO GET OFF ROAD DROVE BACK HOME. NOW THE TRUCK WILL NOT MOVE WHEN SHIFTED INTO DRIVE OR REVERSE. I ONLY HAD IN 2ND GEAR THIS IS A AUTOMATIC TRANSMISSION.FLUID IS STILL OKAY. WHAT IS WRONG WITH THIS TRUCK?.MILAGE IS 123242

THERE WAS NOT WARNING LIGHTS ON DASH, TRUCK SLOWED DOWN THEN ENGINE RACED UP ALL ON ITS OWN TURNED I TURNED OFF ROAD SHIFTED TO NUTRAL AND SAT UNTIL THE RACING STOPPED CONTINUED ON TO AUTO PART STORE WHERE THEY PLUGGED INTO ENGINE IT READ STRANGE CODES..

TWO WEEKS AGO FOR NO REASON MY AIR BAGS DEPLOYED WHILE I WAS DRIVING. I CONTACTED FORD AND COULDN'T GET ANY HELP FROM THEM AT ALL. I WAS LEAVING WORK IN VIRGINIA.

I WAS DRIVING MY FORD ON THE HIGHWAY AND THE NEXT THING I KNOW MY FEET WERE REALLY HOT AND BLACK SMOKE STARTED COMING UP. THEN THE BLACK SMOKE STARTED COMING FROM THE ENGINE AND I NEARLY CRASHED TRYING TO GET TO THE EDGE OF THE HIGHWAY BEFORE THE FIRE TOOK OVER THE WHOLE FRONT OF THE CAR. LUCKILY THE FIRE DEPARTMENT WAS RIGHT THERE FOR ANOTHER ACCIDENT. IT WAS INCREDIBLY DISTURBING EXPERIENCE. LUCKILY MY 3 SMALL CHILDREN WERE NOT IN THE CAR.

TL* THE CONTACT OWNS A 2002 FORD EXPLORER. WHILE ATTEMPTING TO START THE VEHICLE, THE GEAR SHIFT FRACTURED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE STEERING COLUMN FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT AT THE DEALER BEING REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 153,000.