2018 FORD EXPLORER Complaints

My vehicle has defect in the electronic power brake assist system that lead to extended stopping distances and cause me to hit someone from behind.

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

The internal water pump system on the EcoBoost engine in the 2018 Ford Explorer failed after 7 years and only 63,880 miles. The vehicle was taken into the shop multiple times when the check engine light came on and the defect was not located until the vehicle failed. Due to the design, it is not easily fixed and cost an outrageous amount of money to fix for a vehicle with less than 100,000 miles. This is a safety risk because if this is a common issue, which it is, and the engine fails while driving it, the driver is not able to get to a safe area to address damages and is left stranded. There are numerous complaints regarding the design flaw of having the water pump inside the engine. The manufacturer refuses to address the flaw. The check engine light came on and was taken in and wrongly diagnosed each time until the engine failed.

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that while the vehicle was parked, the A-pillar trims on the front passenger’s side and the front driver's side became loosened. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that on a separate occasion, while driving at 70 MPH, the hood unexpectedly opened. The contact stated that the hood was slightly ajar. The message "Hood Ajar" was displayed. The contact pulled over to the shoulder of the roadway and pushed the hood down. The contact continued driving. Most recently, while driving 70 MPH, the failure reoccurred with the message "Hood Ajar" displayed. The contact pulled over to the side of the shoulder and pushed down and closed the hood. The vehicle was not diagnosed or repaired after the most recent failure. The manufacturer was not made aware of the failure. The failure mileage was unknown.

The contact owns a 2018 Ford Explorer. The contact stated that while his wife was driving 65 MPH, the passenger’s side A-pillar trim detached from the vehicle. No warning light was illuminated. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The failure mileage was unknown.

The dash cover came unglued and is rolling up exposing a white cloth that reflects on the windshield makingit hard to see

The contact owns a 2018 Ford Explorer. The contact stated that while operating the vehicle, the engine overheated, and the vehicle stalled. The contact inspected the vehicle and discovered that the serpentine belt had failed. The contact replaced the serpentine belt, and the vehicle was repaired. Later, while operating the vehicle, several electrical warning lights were displayed. The battery was replaced, but the failure persisted. The contact replaced the alternator; however, after replacing the alternator, the transmission remained stuck in park(P), rendering the vehicle undrivable. The cause of the failures was not yet determined. The manufacturer was notified of the failure. The local dealer was not contacted. The failure mileage was 155,000.

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000(Structure); however, the part to do the recall repair was not yet available. The contact stated that the passenger's side and driver's side windshield exterior A-pillar trims had become loose and were deteriorating. The vehicle was taken to the dealer, where it was inspected several times, and the dealer determined that the trims needed to be replaced. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of failure. The failure mileage was approximately 75,000.

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that while driving at an undisclosed speed, the front passenger side A-pillar trims detached. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 98,000.

I previously reported a battery 'explosion' in this 2018 Ford Explorer with ODI 11678705 due to my concern for a potentially highly dangerous situation for my grandchildren who were riding with me. And myself. An unpleasant smell intermittently followed this car that morning July 10 Upon opening the hood it was evident that battery acid had leaked out of the battery and 'exploded' covering most visible engine parts. Entire time of drive there was no 'alert' showing up on my dashboard July 11 car would not start to take to Ford dealership. AAA towed car with AAA driver remarking 'looks like your battery exploded!' Engine compartment cleaned by service, battery replaced July 12 July 18 engine light came on. Ford dealership contacted, no service appointment available until Aug 20. Advised by Ford service to take short trips only, and stop driving if engine light started flashing. I restricted my driving. July 27 started car for trip to church. Loud banging coming from under hood. Stopped driving. Car towed July 28 to Ford dealership repair. Car was not into service dept until Aug. 5. Aug 6, Ford service decided to get input from a more experienced technician to diagnose the problem with 2018 Ford explorer Aug 7, Ford service escalated case to Ford corporate for engineering help with identifying 'electrical' problem with my car. Ford service rep stated 'you car is throwing a code not typically seen with explorers) How can be safe if these my car had a battery issues mechanics freely admit they have not seen before. And now trained Ford mechanics cannot even find or fix the broken link that truly may be responsible for back to back engine failures? Dealer has finally been able to provide a rental. This car has been maintained according to factory recommendations at Sunset Ford and Bommarito Ford St. Loui