2011 FORD EXPLORER Complaints

The contact owns a 2011 Ford Explorer. The contact stated while driving at an undisclosed speed, the passenger's side exterior A-Pillar Applique Trim detached. The contact stated that the exterior A-Pillar Applique Trim was flapping and hitting the ground. The dealer was made aware of the failure. The contact was informed that the parts were unavailable. The contact was advised to remove the detached exterior A-Pillar Applique Trim. The contact received a recall notification, NHTSA Campaign Number: 24V031000 (Structure) however the parts were unavailable. The manufacturer was not made aware of the failure. The failure mileage was approximately 1000,000.

In early 2024, we learned our 2011 Ford Explorer was under open recall (NHTSA #24V031) for the A-pillar windshield trim, which could detach and create a road hazard. For two years, our Ford dealer said repairs could not be done due to parts availability. The A-pillar trim detached three separate times, including once at 75 mph on a highway, causing fear and danger. The vehicle’s elderly owner stopped driving for safety. On May 26, 2026, a non-Ford mechanic attempted a repair due to the delay at Ford, but the part broke during that attempt. The recall remains incomplete, and we have ongoing safety concerns, out-of-pocket expenses, and no timeline for a real fix.

Vehicle is very hard to steer, will not reset when restarting the vehicle. two dash messages; advance track warning and power assist failure. I have not attempted to drive on road due to difficulty of steering the wheel. I am afraid the vehicle is uncontrollable at this point and needs to be towed to a repair facility. Not sure if this incident is linked to the recall under 14S06 for ford recalls.

The contact owns a 2011 Ford Explorer. The contact stated that after parking in the garage and turning the engine off, approximately 5 minutes later a loud noise came from the rear of the vehicle. The contact discovered that the rear hatch window had exploded and glass shards fell into the vehicle. The cause of the failure was not determined. The contact indicated that at the time of the failure the rear window defroster was not activated. The manufacturer and local dealer was not contacted. The failure mileage was 227,000.

The contact owns a 2011 Ford Explorer. The contact stated that while driving at an undisclosed speed, the vehicle became difficult to maneuver. The message that the "Vehicle Needed Attention" was displayed on the instrument panel. The vehicle was taken to back to the residence. The contact researched and was made aware of an unknown recall; however, the VIN was not associated with the recall. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 270,000.

The contact owns a 2011 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the A-pillar trim clip detached, and the vehicle was taken to the local dealer where a temporary repair was performed using tape to secure the trim. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The approximate failure mileage was 135,000.

The steering wheel got stiff and impossible to turn. I had to use extreme force to be able to make a left turn. It happened in a large intersection. No warning appeared.

The contact owns a 2011 Ford Explorer. The contact stated that while driving at an undisclosed speed, the steering wheel became extremely stiff. The steering wheel was extremely difficult to turn. The vehicle was not repaired. The dealer was not notified of the failure. The manufacturer was not notified of the failure. The failure mileage was 160,000.

The contact owns a 2011 Ford Explorer. The contact stated that while driving at an undisclosed speed, the driver's side A-pillar trim on the windshield started to detach. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The dealer was contacted; however, the vehicle was not diagnosed or repaired, and the dealer confirmed that parts were not yet available for the recall repair. The manufacturer was made aware of the failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The approximate failure mileage was 116,035.

The contact owned a 2011 Ford Explorer. The contact stated that while the vehicle was parked, turned off, and unoccupied, the vehicle caught fire. The contact was in her residence, and a neighbor knocked on her door, making her aware that the vehicle had caught fire. The fire has been extinguished by the local fire department. The fire department indicated that the failure may have occurred due to a wiring malfunction in the vehicle. A police report was not filed, but a fire report was filed and was unavailable. There were no injuries reported. The dealer was contacted. The vehicle was not diagnosed or repaired. The vehicle was destroyed. The manufacturer was not made aware of the failure. The approximate failure mileage was 200,000.