1997 FORD EXPLORER Complaints

MY 1997 FORD EXPLORER HAS AN INTAKE MANIFOLD FAILURE. I UNDERSTAND BY READING MANY MESSAGE BOARDS AND OTHER COMPLAINTS ON THE INTERNET THAT FORD HAS RECALLED THIS ITEM ON SOME VEHICLES BUT NOT ALL. I REALLY CAN'T BELIEVE THAT FORD WOULD ACTUALLY USE A PLASTIC INTAKE ON ANYTHING. I BELIEVE IT IS A BREAK DOWN IN JUDGEMENT AND FORD SHOULD BE RESPONSIBLE FOR THE REPLACEMENT OF THIS PART.*AK

I HAVE HAD MY1997 FORD EXPLORER FOR TWO YEARS, THE SAME PROBLEM KEEPS RECURRING. IT BECOMES SULIGISH ON THE ON SET, THAN THE CHECK ENGINE LIGHT COMES ON. 12 TIMES NOW I HAVE HAD TO REPLACE THE SPARK PLUGS, 3 TIMES I HAVE DONE FUEL ENJECTION CLEANS, 2 TIMES I HAVE CHANGED THE O2 SENSOR. I HAVE TALKED TO OTHER OWNERS THAT SPEAK OF THE SAME PROBLEMS.*AK

DRIVER'S SIDE REAR DOOR COULD NOT BE OPENED FROM THE INSIDE. DEALER WAS NOT NOTIFIED AT THIS TIME. *AK

THE VEHICLE STABILIZER BOLT SNAPPED WITHOUT WARNING. AS A RESULT, WHEN TURNING IN EITHER DIRECTION THE VEHICLE ROLLS. A RECALL(00V-402000) WAS ISSUED, HOWEVER THE VEHICLE'S VIN NUMBER IS OUTSIDE OF THE REMEDY SCOPE. *LA *SC

WHILE DRIVING THE ABS ENGAGED, WHICH CAUSED THE TRUCK TO FLIP OVER. AS A RESULT THE DRIVER WAS EJECTED FROM THE VEHICLE, THEN TWO SECONDS LATER, THE VEHICLE CAUGHT FIRE. *JB THE CONSUMER CONTACTED THE MANUFACTURER ABOUT THE FAILURE BUT THE RESPONDED WITH A LETTER WHICH SAID " SORRY THERE IS NOTHING WE CAN DO FOR YOU AT THIS TIME." *NM

1997 EXPLORER 4.0 SOHC PURCHASED IN 1999.MADE KNOCKING NOISE WENT TO DEALERSHIP SEVERAL TIMES UNDER WARRANTY AND WAS TOLD MY MOTOR WAS PULLED AND TENSIONER (PULLEY, CAM TENSIONER) WAS REPLACED.AFTER RECIEVING NOTIFICATION FROM FORD OF "IN WARRANTY" SERVICE BULLETIN,DIFFERENT DEALER SAID IT HADNT BEEN REPLACE OR DOCUMENTED BY PREVIOUS SERVICE.SO,IT WAS SUPPOSEDLEY REPLACED AGAIN (2 TIME).STILL MAKING THE NOISE AFTER SO LONG, AND TOLD SEVERAL TIMES "WE CANT FIND ANYTHING WRONG" KEPT DRIVING.NOW, I AM IN DEALERSHIP FOR ABOUT 10TH TIME AND MY TESNIONERS,POSSIBLY MY TIMING CHAIN,AND POSSIBLE OTHER COMPONENTS (HOPEFULLY NOT MOTOR)NEED TO BE REPLACED AGAIN(3TIME,MORE DAMAGE)??!!THIS TIME THERES NO WARRANTY OR REASON WHY I SHOULDENT "HAVE TO PAY" SO IT IS COSTING ME $1600 SO FAR...POSSIBLY MORE IF THERE WAS MORE DAMAGE.THIS MUST BE DOCUMENTED BECAUSE I HAVE TRIED IN GOOD FAITH AND NUMEROUS,TIRING EFFORTS TO REPAIR THIS FROM DAY ONE!DO NOT WANT TO HAVE TO REPLACE MOTOR IN NEAR FUTURE LIKE OTHERS.*AK

I HAD PURCHASED A 1997 FORD EXPLORER XLT FROM MK AUTO IN AUBURN, CA AND THE CAR FAX I RECIEVED SAID THERE HAD BEEN NO RECALLS AND NO ACCIDENTS ON THE VEHICLE. THE OWNER FROM MK AUTO ASSURED ME MANY TIMES THAT THE FEHICLE WAS IN GOOD RUNNING CONDITION. THE DAY AFTER I BAUGHT THE VEHICLE IT BROKE DOWN IN ME. MK AUTO TOOK IT BACK 3 TIMES IN HOPES THEY COULD FIX IT, BUT NEVER DID. 10 MONTHS LATER THE CAM CHAIN GUID BROKE IN THE ENGINE. MY HUSBAND AND I LOOKED ON THE INTERNET AND FOUND THERE HAD BEEN 13 RECALLS ON MY VEHICLE I NEVER KNEW ABOUT. THIS CAR IN VERY UNSAFE FOR MY FAMILY AND I AM OUTRAGED I WAS NEVER NOTIFIED! I HAVE NOW TRIED TO BUY ANOTHER CAR, BUT THE FORD EXPLORER IS WORHT SO LITTLE AND NOW I HAVE SO MUCH NEGATIVE EQUATY ITS HARD.......I FINALLY FOUND A CAR, BUT AM PAYING DEARLY FOR IT BECAUSE OF THE EXPLORER WHICH HAS BEEN SITTING IN THE CAR LOT OF A FORD DEALERSHIP FOR OVER A MONTH!*AK

WHILE DRIVING AT 60 MPH CONSUMER HEARD A LOUD EXPLOSION AND THE VEHICLE VEERED TO THE LEFT. VEHICLE ENDED UP IN A GULLY FACING ONCOMING TRAFFIC. CONSUMER EXAMINED THE VEHICLE AND FOUND THAT THE TREAD PEELED COMPLETELY OFF OF THE RIGHT REAR TIRE.*AK

WHILE DRIVING AT ANY SPEED VEHICLE JERKED AND THE OVERDRIVE LIGHT APPEAREED ON THE DASHBOARD AND REMAINED ON. VEHICLE WAS TAKEN TO DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT TRANSMISSION NEEDED TO BE REPLACED.*AK

THE DRIVER SIDE SEAT BELT BUCKLE ASSEMBLY MALFUNCTIONED AND FAILED TO LOCK. THE LATCH PLATE DID NOT LOCK IN THE BUCKLE. THIS RENDERED THE SEAT BELT INOPERATIVE.*AK