1997 FORD EXPLORER Complaints

TL* THE CONTACT OWNS A 1997 FORD EXPLORER. THE CONTACT STATED WHILE DRIVING 50 MPH, THE VEHICLE STARTED TO SHAKE ABNORMALLY, THE CONTACT WAS UNABLE TO DRIVE IN 4 WHEEL DRIVE. THE CONTACT STATED THE CHECK GAUGE WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED WITH THE FRONT DRIVE SHAFT, THE CONTROL ARMS, THE FRONT OXYGEN SENSOR, AND THE FRONT AND REAR BRAKES NEEDING TO BE REPLACED. THE CONTROL ARMS WERE REPLACED HOWEVER, THE FAILURE PERSISTED. THE MANUFACTURER HAD NOT BEEN INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 147,000.

TL* THE CONTACT OWNS A 1997 FORD EXPLORER. THE CONTACT STATED THAT THE VEHICLE CAUGHT ON FIRE WHILE PARKED IN HIS DRIVEWAY. THE CONTACT STATED THAT AN INDEPENDENT MECHANIC DIAGNOSED THAT THE HYDRAULIC FLUID WAS LEAKING DUE TO THE FAULTY CRUISE CONTROL SWITCH CAUSING THE FIRE. THE CONTACT MENTIONED THAT THE HYDRAULIC FLUID LEAKED OUT WHEN IT GETS WARM EVEN WHEN THE VEHICLE NOT RUNNING. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR A DIAGNOSTIC TESTING AND WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 23,000. THE VIN WAS NOT AVAILABLE. *BF

MY LIGHTS DON'T WORK STABILIZING BAR IS BAD,SPEED CONTROL DOSE NOT WORK SECURITY KEY CODE NOT WORKING,DOOR CONTROLS DO NOT WORK.WIPER WORK SOMETIMES.BALL JOINT ARE BAD, TIRES WEARING BAD,,BUSHINGS ARE VERY BAD.TRANSMISSION IS STARTING TO SLIP,ALL WHEEL DRIVE DOES NOT WORK, IT GRINDING SOUND.HEAF LIGHT ONLY BRIGHTS WORK.

RUNNING ON THE HIGHWAY THE RIGHT AXLE OF THE DIFFERENTIAL BROKEOFF AND THE WHEEL CAME OFF WITH THE BRAKE CALIPER AND BRAKE HOSE AND BECAUSE OF THIS CAUSE LOOSE CONTROL AND CRASH .THE VEHICLE IS TOTAL LOSS.

I RECENTLY FOUND OUT MY VEHICLE HAS AN OPEN RECALL REGARDING THE POSSIBLE LEAKAGE OF THE SPEED CONTROL DEACTIVATION SWITCH, WHICH COULD CAUSE A FIRE WHETHER THE VEHICLE IS RUNNING OR NOT. THE FORD MANUFACTURER'S RECALL #09S09 AND THE NHTSA RECALL #09V399000. THIS IS STILL AN OPEN RECALL.I CONTACTED FORD RECALL CENTER TODAY AND THEY ARE REFUSING TO REMEDY THIS HAZARDOUS RECALL DUE TO THE AGE OF THE RECALL AND THE AGE AND MILES OF MY VEHICLE. THIS IS A SAFETY ISSUE AND FORD SHOULD FIX IT AS BODILY INJURY OR EVEN POSSIBLE DEATH COULD OCCUR IF THIS RECALL IS NOT REMEDIED. MY VEHICLE IS RUNNING PROPERLY FOR THE MOMENT BUT SINCE THIS IS A SAFETY ISSUE, FORD MOTOR CO. SHOULD BE REQUIRED TO FIX IT NO MATTER THE AGE OF MY VEHICLE.

ON DECEMBER 23RD, 2016 I WAS COMING HOME FROM WORK AROUND 6:00 PM. MY CAR WAS A 1997 FORD EXPLORER EDDIE BAUER EDITION. I HAD JUST GOTTEN OFF OF THE HIGHWAY AND TURNED ONTO MY ROAD WHEN I BEGAN TO SMELL SMOKE, SO, I PULLED OFF INTO AN EMPTY PARKING LOT BESIDE A WALKING TRAIL. I COULD TELL THAT IT WAS AN ELECTRICAL FIRE, BUT, IT TOOK ME QUITE A WHILE TO FIGURE OUT WHERE IT WAS COMING FROM. I CHECKED UNDER THE HOOD - BUT NOTHING SEEMED TO BE WRONG THERE. THEN, I GOT BACK INTO THE CAR AND THE SMOKE KEPT GETTING HEAVIER. I BEGAN FEELING AROUND FOR SOMETHING THAT WAS HOT. I CHECKED THE DASH, THE VENTS, THE STEERING WHEEL, THE SEATS - ALMOST EVERYTHING BEFORE I CHECKED THE CENTER COMPUTER CONSOLE. IN THE MIDDLE OF MY CAR - DIRECTLY UNDER THE RADIO - THERE IS A COMPUTER MODULE THAT DISPLAYS THE GAS MILEAGE, OIL STATUS, AND IF THERE IS A PROBLEM WITH THE LIGHTS ON THE CAR. THE MODULE HAD RECENTLY STARTED DISPLAYING A "CHECK HEADLAMPS" MESSAGE. WELL - I HAD DONE SO AND THEY WERE WORKING FINE - SO I DID NOT THINK ANYTHING OF IT. TURNS OUT THAT THE FIRE HAD STARTED UNDER THE CENTER COMPUTER MODULE. I GUESS THAT THE CAR SHOULD HAVE BLOWN A FUSE BUT INSTEAD - STARTED A FIRE. I TRIED TO RIP THE COVER AND THE CONSOLE UP - BUT IT WAS SCREWED DOWN AND I HAD NO LUCK. AT THAT POINT, THE FLAMES STARTED TO SPREAD VERY QUICKLY AND THE ENTIRE CAR WENT UP IN FLAMES IN A MATTER OF MINUTES. I CALLED 911 AND GOT AS FAR AWAY AS I COULD WITH MY BELONGINGS. THE FIRE TRUCK AND FIRE FIGHTERS CAME WITHIN FIVE MINUTES OR SO AND PUT OUT THE FIRE BEFORE IT REACHED THE GAS TANK. THE BOTTOM HALF OF THE CAR REMAINED UNTOUCHED, HOWEVER, THE INTERIOR WAS COMPLETELY DESTROYED. THE SEATS HAD BURNT OFF AND THE STEERING WHEEL WAS COMPLETELY GONE. I'M STILL IN MY TEENAGE YEARS - SO I DID NOT KNOW HOW TO DEAL WITH THIS SITUATION PROPERLY. I AM JUST GLAD I AM ALIVE AND THAT I WAS ABLE TO GET OUT OF THE CAR IN TIME.

WITH NO WARNING OR HINT OF ANYTHING GOING WRONG ON THE BRAKE SYSTEM, AS TRAFFIC SLOWED TO STOP FOR A LIGHT, THE BRAKES WENT COMPLETELY OUT ON MY FORD EXPLORER. THE PEDAL WENT TO THE FLOOR AND PUMPING HAD NO EFFECT. I WAS IN MID DAY TRAFFIC AND HAD ALMOST 2 CAR LENGTHS BETWEEN MYSELF AND THE SUV IN FRONT OF ME, WHICH UNFORTUNATELY, WAS WHAT STOPPED ME. THANKFULLY, I WAS ONLY GOING 20 MPH AND NO ONE WAS HURT NOR DID AIR BAGS DEPLOY. AFTER THE POLICE ARRIVED AND HAD US PULL INTO A PARKING LOT, THE PEDAL FELT LIKE IT HAD THE BRAKES BACK HOWEVER, THE BRAKE PEDAL WENT TO THE FLOOR AFTER CRANKING UP. I WAS ABLE TO STOP FROM ROLLING OUT THE OTHER SIDE OF A PARKING SPACE IN THE BACK OF THE LOT BY USING THE EMERGENCY BRAKES. EVEN THOUGH THE TRUCK HAS SHOWS HIGH MILEAGE,MOST OF WHICH IS HIGHWAY MILES, THE TRUCK AS BEEN MAINTAINED. I HAD THE TRUCK TOWED TO THE SHOP AND TWO MECHANICS COULD FIND NOTHING WRONG. I HAD THE MASTER CYLINDER AND BOOSTER WAS CHANGED EVEN THOUGH I WAS ASSURED IT WAS FINE. THAT SEEMED TO HELP MY PEACE OF MIND FOR ABOUT A WEEK UNTIL I WAS STOPPED AT A LIGHT AND THE BRAKE PEDAL EASED DOWN TO THE FLOOR. I RAN AN INTERNET SEARCH TO SEE IF ANYONE ELSE HAS HAD THIS PROBLEM AND SURPRISED TO SEE IT SEEMS TO BE A COMMON PROBLEM WITH EXPLORER. I'M SURE EVERYONE WHO MENTIONED HAVING THIS PROBLEM HAS NOT REPORTED IT THAT SHOULD HAVE.

THE DRIVER SIDE INTERIOR DOOR HANDLE RETURN SPRING UNSEATED RESULTING IN INTERIOR DOOR HANDLE THAT DOES NOT RETURN TO THE FULLY STOWED POSITION AFTER ACTUATION. IF THE INTERIOR DOOR HANDLE RETURN SPRING IS UNSEATED, COULD THE DOOR UNLATCH IN THE EVENT OF A SIDE IMPACT CRASH, INCREASING THE RISK OF PERSONAL INJURY? *TR

1997 FORD EXPLORER SPORT. CONSUMER WOULD LIKE INFORMATION REGARDING AN ACCIDENT THAT OCCURRED IN SEPT 2010. *TA

THE 1997 FORD EXPLORER 4D EDDIE BAUER EDITION HAS A COMPUTER CONTROLLED MESSAGE CENTER. THE MESSAGE CENTER CONTROLS AMONG OTHER THINGS THE VEHICLE HEADLIGHTS AND FOG LAMPS. THE LIGHT OUT MODULE (LOM) ALSO KNOWN AS THE INDICATOR WARNING SYSTEM CONTROL IS LOCATED INSIDE THE MESSAGE CENTER CONSOLE AND RUNS "HOT" IN TEMPERATURE BECAUSE OF A FLAWED DESIGN. THE CURRENT DESIGN LEADS TO INTERNAL ELECTRICAL SYSTEM FAILURES THAT RESULT IN A LOSS OF THE LOW BEAM HEADLIGHTS. THE SYSTEM IS DESIGNED TO NOTIFY THE DRIVER OF A HEADLIGHT OR LAMP FAILURE, ETC, HOWEVER, THE FAILURE OF THE NOTIFICATION SYSTEM CAUSES THE LOW BEAM HEADLIGHTS (AND FOG LAMPS AS THEY ARE ON THE SAME CIRCUIT) TO FAIL. ON JUNE 25, 2014, THE SECOND FAILURE OF THE SYSTEM OCCURRED (WE ARE THE ORIGINAL OWNERS AND HAVE PREVIOUSLY REPLACED THE INDICATOR WARNING SYSTEM CONTROL OR LIGHT OUT MODULE (LOM) AT GREAT EXPENSE). FORD MOTOR COMPANY MUST RECALL THE 1997 FORD EXPLORER EDDIE BAUER EDITION AND ANY OTHER LIKE DESIGNED FORD PRODUCT WITH A LIGHT OUT MODULE (LOM) THAT FAILS LEAVING THE DRIVER WITHOUT LOW BEAMS AND NO MEANS OF FIXING THE SAID DEFECT WITHOUT AN AUTHORIZED FORD DEALER'S REPAIR (AT GREAT EXPENSE) THAT IS LIFE THREATENING IN THE INTERIM. SUCH REPAIRS ARE NOT POSSIBLE IF ON AN EXTENDED TRIP IN RURAL SETTINGS. THE ABSENCE OF LOW BEAM HEADLIGHTS AFTER SUNSET AND BEFORE SUNRISE IS LIFE THREATENING AND UNACCEPTABLE TO THE OCCUPANTS OF A 1997 FORD EXPLORER AS WELL AS TO PEDESTRIANS AND OTHER VEHICLES WHO CANNOT SEE THE FORD EXPLORER OPERATING WITHOUT HEADLIGHTS. THE CORRECTIVE SOLUTION NEEDS A VENTING SYSTEM SUCH THAT THE MESSAGE CENTER DOES NOT CONTINUALLY MELT THE INDICATOR WARNING SYSTEM CONTROL OR LIGHT OUT MODULE (LOM). THANK YOU FOR YOUR SERVICE AND FOR YOUR PROMPT ATTENTION TO THIS DEFECT REQUIRING A CORRECTIVE RECALL. *TR