1999 FORD EXPLORER Complaints

WHILE DRIVING DOWN RT.10 IN WHIPPANY,NJ MY '99 FORD EXPLORER CAUGHT ON FIRE. ELIEVE IT WAS AN ELECTRICAL FIRE - FIRE WAS BEHIND THE DASH BOARD. I SAW FLAMES COMING FROM THE PASSENGER SIDE ON THE FLOOR AND THE CAR QUICKLY FILLED UP WITH SMOKE. I PULLED OFF THE ROAD - CALLED 911 - POLICE AND FIRE TRUCK ASSISTED ME.*AK

CONSUMER'S 1999 FORD EXPLORER (VIN [XXX]) CAUGHT ON FIRE DUE TO A VEHICLE DEFECT. REQUEST THAT THE SCOPE OF THE FORD RECALL FOR THE CRUISE CONTROL DEACTIVATION SWITCH BE EXPANDED. *NM THE CONSUMER BELIEVED THE FIRE WAS DUE TO A DEFECTIVE SPEED CONTROL DEACTIVATION SWITCH. A RECALL WAS ISSUED FOR OTHER MODELS REGARDING THE SPEED CONTROL DEACTIVATION SWITCH. THE CONSUMER IS REQUESTING FOR THE RECALL TO BE EXPANDED. LAWYER ON BEHALF OF CONSUMER, ALSO SEE ODI#10115518 *JB INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

@ 50,000 MILES RADIATOR WENT OUT AND WE REPLACED W/ NEW RADIATOR/ HEADS IN THE MOTOR HAD TO BE REPLACED / ELECTRICAL PROBLEMS / RE-BUILT TRANSMISSION PUT IN / DRIVER'S SEAT RECLINER FAILURE . *AK

WHILE DRIVING APPROXIMATELY 80 MPH ACCELERATION PEDAL WAS LET GO BUT SPEED DID NOT DECREASE. CONSUMER THEN APPLIED BRAKES BUT HAD NO EFFECT. HE TRIED TO APPLY THE BRAKES AGAIN WHICH SLOWED VEHICLE DOWN. ACCIDENTS WERE AVOIDED WHILE PULLING TO SHOULDER OF ROAD. *AK

VEHICLE HAD BEEN TO THE REPAIR SHOP THREE TIMES FOR THE PADS AND ROTORS BEING DEFECTIVE. ALSO, SEEMED TO BE AN ISSUE WITH OTHER CONSUMERS. *AK THE CONSUMER STATED THAT THE BRAKES SQUEAK EVEN AFTER THE REPAIR. *TC

THE INTERIOR OF THE FUEL TANK DEVELOPED RUST, CAUSING THE VEHICLE TO STALL MULTIPLE TIMES ON THE ROAD. TAKEN TO SHOP FOR A NEW REPLACEMENT FUEL TANK.*AK *TC

I HAVE A 1999 FORD EXPLORER XLT WITH A V-6 SOHC 4 LITER ENGINE. THE CAR HAS NOT PROPERLY ACCELERATED SINCE PURCHASE IN 2000, IT HAS CONSTANTLY STALLED WHILE DRIVING AND THE DEALER COULD NOT DETERMINE THE PROBLEM BECAUSE THE CHECK ENGINE LIGHT WAS NOT ON. I FOUND OUT FEBRUARY 16, 2005 THAT I HAVE A BROKEN INTAKE MANIFOLD GASKET AND IT COST OVER $1,000 TO FIX. I HAVE SEARCHED THE INTERNET RELATED TO THIS PROBLEM AND FOUND THERE ARE EIGHT FORD MODELS MANUFACTURED FROM 1996 THROUGH 2001 WITH THIS PROBLEM. FORD REFUSES TO ACKNOWLEDGE THIS DEFECT TO CONSUMERS BUT ACCORDING TO THE ARTICLE INTHE ATTACHED LINK, THEY HAVE EXTENDED THEIR WARRANTY ON THIS PART TO THE POLICE DEPARTMENT AND TAXI COMPANIES THAT HAVE PURCHASED THE AFFECTED CARS. PLEASE VISIT THE WEBSITE FOR MORE INFO.HTTP://WWW.GM-V6LEMONS.COM/MEDIAATTN.HTM THANK YOU FOR ANY HELP YOU CAN PROVIDE PETER DELVECCHIA. *JB

THIS REPORT CONCERNS A 1999 FORD EXPLORER SPORT 2DR 4X4. VEHICLE HAS 144,000 PLUS MILES. SPECIFICALLY THIS PERTAINS TO THE FRONT DRIVER?S SEAT (NON-POWER MODEL). OVER THE LAST 5 YEARS I HAVE REPLACED THE FRONT DRIVERS SEAT (BOTTOM FRAME) THREE TIMES. EACH TIME THE SEAT FRAME HAS BROKEN IN THE SAME MANNER. THE PROBLEM IS THAT THE FRAME METAL RIPS/TEARS AT THE LOCATION OF THE MOUNTING BOLT FOR THE RECLINE LEVER. THIS TEARING CAUSES THE SEAT BACK TO RECLINE WITHOUT WARNING ON THE LEFT SIDE CAUSING THE DRIVER TO FALL BACKWARDS AWAY FROM THE STEERING WHEEL. FORD HAS STATED THAT THEY DO NOT HAVE ANY INFO ON THIS. THIS IS SOMEWHAT STRANGE AS THEY APPARENTLY DIRECTED DEALERSHIPS APPROXIMATELY 2 YRS AGO TO REPLACE THIS FRAME ON ALL AFFECTED VEHICLES. THE PROBLEM IS VERY APPARENT AND A VERY EASY FIX. THE TEARING OCCURS JUST TO THE FRONT OF THE (FRONT) BOLT HOLE ABOUT 1/8 INCH FROM THE HOLE. THERE IS A LARGE SPOT WELDED PLATE INSIDE THE FRAME WHERE THE BOLTS FOR THE RECLINE LEVER INSERT INTO THE FRAME. IF THIS PLATE WAS EXTENDED ABOUT 4 INCHES OR MORE PAST THE FRAME HOLES THIS PROBLEM WOULD NOT OCCUR. I HAVE DETAILED PHOTOS OF THIS FRAME AND PROBLEM AREA AVAILABLE FOR USE TO YOUR OFFICE AS WELL AS THE FRAME ITSELF.*AK

VEHICLE WAS PARKED IN THE GARAGE FOR AT LEAST 2 HOURS BEFORE THE VEHICLE CAUGHT ON FIRE. THE FIRE DEPARTMENT WAS NOTIFIED, AND THE FIRE WAS EXTINGUISHED. VEHICLE WAS TOTALED. THIS WAS CONFIRMED BY THE INSURANCE COMPANY. *AK

CONSUMER REPLACED FRONT DRIVER'S SEAT (BOTTOM FRAME) 3 TIMES. EACH TIME THE SEAT FRAME HAS BROKEN IN THE SAME MANNER. *BF THE FRAME METAL RIPPED/TORE AT THE LOCATION OF THE MOUNTING BOLT FOR THE RECLINER LEVER. THE TEARING CAUSED THE SEAT BACK TO RECLINE WITHOUT WARNING ON THE LEFT SIDE. AS A RESULT THE DRIVER FELL BACKWARDS AWAY FROM THE STEERING WHEEL. *NM