1998 FORD EXPLORER Complaints

DT: CONTACT STATES WHILE VEHICLE WAS PARKED IT STARTED SMOKING FROM UNDERNEATH THE HOOD. UPON INSPECTION IT WAS NOTICED THAT THE CRUISE CONTROL SWITCH WAS BURNED UP. THIS VEHICLE WAS NOT COVERED UNDER THE RECALL DUE TO VIN. *AK

ON MAY 15, 2004, I WAS FISHING IN A LOCAL BASS TOURNAMENT. I PARKED MY 1998 FORD EXPLORER BESIDE ONE OF MY FISHING FRIENDS CHEVY TRUCK AND BOAT TRAILER. AFTER LAUNCHING MY PARTNER FOR THE DAYS BOAT, I PARKED HIS TRUCK AND TRAILER ON THE OTHER SIDE OF MY EXPLORER. APPROXIMATELY 4 HOURS LATER, MY PARTNER AND I WERE APPROCHED BY ANOTHER FRIEND AND TOLD US WE WERE NEEDED BACK AT THE PARKING LOT THAT MY EXPLORER HAD BURNED TO THE GROUND, BURNED THE CHEVY WITH THE TRAILER TO THE GROUND AND SCORCHED PAINT AND MELTED PARTS OF MY PARTNERS TRUCK. THE CHEVY TRUCK AND MY EXPLORER WERE TOTAL LOSSES AND I LOST A LOT OF PERSONAL ITEMS THAT INSURANCE DID NOT PAY FOR. STATE FARM CLAIM # 18-1010-243

HARD TO GET VEHICLE OUT OF PARK INTO DRIVE FOR SEVERAL DAYS PRIOR TO THE FIRE. ABOUT 2 HOURS AFTER THE VEHICLE HAD BEEN PARKED, AND ENGINE TURNED OFF, A FIRE STARTED UNDER THE HOOD, AND DESTROYED THE VEHICLE.

DT: GAS PEDAL FELL OFF WITHOUT WARNING. DEALER AND MANUFACTURER HAD NOT BEEN CONTACTED YET.*AK

I OWN A 1998 FORD EXPLORER. IT ONLY HAS 23,000 MILES ON IT. I HAVE HAD NOTHING BUT TROUBLE WITH IT. THE MOST RECENT PROBLEMS ARE I HEAR A LOUD NOISE IN THE MOTOR AREA WHEN I USE THE AIR CONDITIONER, I ALSO CANNOT GET THE DRIVER WINDOW DOWN UNLESS I MESS WITH IT ALONG TIME, I HAVE HAD TO REPLACE THE HOOD BRACKETS 2 TIMES, AND THEY NEED REPLACED AGAIN. THE BACK WINDSHIELD WIPER DONT CLEAN THE WINDOW WELL ENOUGH AND IT GETS STUCK, SO I HAVE TO GET OUT AND FIX IT. I ALSO KEEP GETTING THE 'DOOR AJAR' LIGHT ON AT TIMES WHEN THE DOORS ARE ALL CLOSED. I THINK THERE ARE SOME ELECTRICAL PROBLEMS WITH MY EXPLORER. I DONT HAVE THE WARRANTY ANYMORE SO THEY WANT ME TO PAY FOR EVERYTHING BECAUSE THEY SAID ALL FORD COMPANIES ARE INDEPENDENT. IF ANYTHING HAPPENS TO ME OR MY FAMILY WE'LL SEE HOW INDEPENDENT THEY ARE. I THINK ALL EXPLORERS NEED TO BE RE-CHECKED. THEY WERE MADE TOO HASTY OR SOMETHING.

THE BLEND DOOR , PLENUM, THAT CONTROLS THE TEMPATURE OF THE AIR COMING INTO THE CABIN IS BROKEN IN THE SAME PLACE THAT MANY OTHERS HAVE EXPERIENCED. THIS WILL NOT ALLOW HEATED AIR TO COME FROM THE DEFROSTER VENTS RESULTING IN A SAFETY ISSUE.FAILURE DATE GIVEN IS APPROXIMATE.

IT STARTED WITH A MINOR RATTLE IN THE ENGINE TOWARDS THE FRONT OF THE ENGINE. THE RATTLE GOT LOUDER AND LOUDER AND LOUDER UNTIL IT WAS DECIDED NOT TO MOVE THE VEHICLE ANY LONGER. TOOK VEHICLE TO A CERTIFIED MECHANIC, TURNS OUT, THE TIMING CHAIN ASSEMBLY BROKE THROWING PIECES ALL OVER THE PLACE CAUSING THE CHAIN TO MALFUNCTION THAT LEAD TO DAMAGE TO THE ENGINE. ENGINE BLOCK HAD TO BE REPLACED AT A COST OF AROUND $3000. FORD HAS A SERVICE BULLETIN OUT ON THIS SAME PROBLEM, HOWEVER I BOUGHT THE VEHICLE IN NOV 2000 AND I NEVER RECEIVED ANY SERVICE BULLETIN FROM FORD INFORMING ME OF THIS PROBLEM. I TRIED TAKING THE VEHICLE TO THE LOCAL DEALER AND WAS TOLD THEY WON'T REPAIR IT UNDER THE FORD SAFETY BULLETIN BECAUSE IT WAS ONLY FOR 7 YRS OR 100,000. THE VEHICLES 7 YEARS EXPIRED IN APRIL 2005. I TRIED EMAILING OR CONTACTING FORD DIRECTLY AND GOT NO RESPONSE.

DRIVER DOOR WON'T UNLOCK. KEY WON'T UNLOCK IT CAN'T PULL UP ON PLUNCHER. AND INSIDE DOOR HANDLE WON'T OPEN DOOR.DOOR IS JUST STUCK LOCKED. HAVE TO CRAWL OUT WINDOW OR GO OUT PASSENGER DOOR.WHAT WOULD I DO IF I HAD TO GET OUT FAST. I READ ON WEB SITES, ITS A SPRING THAT EVERY ONE IS HAVING TROUBLE WITH.AND ITS THE SAME DOOR. I FOUND OUT ABOUT THE DOOR PROBLEMS FROM OFFROADEXCHANGE.COM

THE ABS LIGHT CAME ON AND STAYED ON WHILE DRIVING. THE CONSUMER TOOK THE VEHICLE TO THE DEALERSHIP, AND A DIAGNOSTIC TEST WAS PERFORMED. THE DEALER DETERMINED THAT THE MODULE FOR THE ABS AND SPEED SENOR WENT OUT. THE DEALERSHIP ALSO NOTICED THE PINS FOR THE FRONTAL AIR BAGS WERE NEVER CONNECTED AT THE FACTORY, RENDERING THE AIR BAGS INOPERATIVE. *JB *SB *NM

DRIVERS SIDE DOOR, OF MY 1998 FORD EXPLORER, COULD NOT BE OPENED (FROM INSIDE OR OUTSIDE DOOR HANDLES). ATTEMPTED TO HAVE DOOR LATCH ASSEMBLY REPLACED, AS BROKEN SPRING WAS FOUND PROTRUDING FROM DOOR LATCH ASSEMBLY AREA <DRIVERS SIDE>. DEALERSHIP INCORRECTLY REPLACED INSIDE DOOR HANDLE AND NOW DRIVERS SIDE DOOR CANNOT BE LOCKED (BUT CAN NOW BE OPENED OR CLOSED). DUE TO DOOR LATCH ASSEMBLY PROBLEMS WITH CANADIAN FORD VEHICLES, I FEAR WE NOW HAVE A SERIOUS SECURITY & SAFETY ISSUE WITH OUR 1998 FORD EXPLORER. DEALERSHIP REFUSES TO REPAIR UNLESS WE BASICALLY AGREE TO REPLACE ALL INTERNAL PARTS OF DOOR <INCLUDING SEAT BELT?>. THE ESTIMATED REPAIR COST (PARTS & LABOR) IS IN EXCESS OF $500.