1997 FORD EXPLORER Complaints

TL* THE CONTACT OWNS A 1997 FORD EXPLORER. THE CONTACT STATED THAT WHEN DRIVING APPROXIMATELY 35-40 MPH OVER A ROAD BUMP, THE VEHICLE WOULD SWAY FROM LEFT TO RIGHT. THE VEHICLE WAS TAKEN TO THE DEALER, WHO ADVISED THAT THE FRONT STABILIZER BAR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED THREE TIMES HOWEVER, THE FAILURE RECURRED AFTER EACH REPAIR. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THERE WERE NO RECALLS FOR THE VEHICLE AND OFFERED NO OTHER ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 135,000.

I HAVE NO EXPLANATION FOR THE FIRE, THE CAR WAS PARKED IN MY DRIVEWAY. IT HAD BEEN DRIVEN ABOUT A BLOCK FROM MY HOME AND THEN IT WAS RETURNED TO THE DRIVEWAY. MY UNCLE SON SITTING IN THE LIVING ROOM WHEN THEY HEARD THE CAR ALARM AND LOOKED OUT OF THE WINDOW TO SEE CLOUDS OF BLACK SMOKE COMING FROM THE TRUCK. MY SON ATTEMPTED TO PUT THE FIRE OUT BUT IT WAS TO INTENSE, MY SON CALLED 911. THIS WOULD HAVE KILLED SOMEONE IF THEY HAD BEEN IN THE CAR. PHOTOS ARE AVAILABLE. FIRE DEPARTMENT COULD NOT SAY WHAT CAUSED THIS FIRE. THE TIRES EVEN MELTED. ALL SEVERE DAMAGE WAS TO THE FRONT END. THE CAR HAD NOT BEEN IN ANY KIND OF ACCIDENT, THERE IS NO EXPLANATION FOR THIS FIRE. PLEASE CONTACT ME FOR PHOTOS. NOT SURE WHAT TO DO BUT I NEED TO MAKE SURE NO FAMILIES. *TR

WE WERE LUCKY THIS TIME, WE HAD THE EXPLORER IN THE SHOP AND I GOT A CALL FROM THE LEAD TECH THAT STATED WHILE THE WERE SERVICING THE BRAKES NO LESS THAN 3 LINES ROTTED THROUGH, BUT*** THE ANTILOCK CONTROLLER SPRUNG A LEAK AND SPRAYED FLUID ALL OVER THE HOT ENGINE CAUSING A SMALL FIRE!!! NO DAMAGE BUT WE WERE LUCKY... *TR

SINCE THE EXPLORER WAS 5 YEARS OLD THE DRIVER SIDE OF THE TRUCK WAS STARTING TO SETTLE/ BE LOWER THAN THE PASSENGER SIDE. UNTIL IT WAS SO BAD THE SHOP STATED WE NEEDED TO REPLACE THE REAR SPRINGS, SHOCKS AND STABILIZER AND *** THE REAR WAS ALSO LOWER THAN THE FRONT. SO WE HAD TO REPLACE THE FRONT SHOCKS AND SEVERAL SUSPENSION PARTS TO TRY TO LEVEL THE VEHICLE BACK TO NORMAL. NOW WITH THE ENGINE BLOWN THE TRUCK AGAIN WAS SETTLING TO THE PASSENGER SIDE AND TOWARD THE REAR!!!!! *TR

THE ENGINE SLOWED DOWN AND JUST QUIT. WOULD NOT RESTART. HAD IT TOWED TO A REPAIR FACILITY *AGAIN* AND FOUND OUT THAT *2 (TWO)* TIMING CHAINS WENT OUT. THE DRIVERS SIDE SNAPPED IN TWO AND THE PASSENGER SIDE (REAR) HAD OVER 1 1/2 INCHES OF PLAY IN IT AND OBVIOUS STRETCHING OF THE TIMING CHAIN. THE FRONT BROKEN ONE TOTALED THE ENGINE, ALL TENSIONERS, SPACERS ETC WERE NOR IN PIECES LYING IN THE ENGINE. AND GUESS WHAT TO REPLACE THE REAR TIMING CHAIN YOU HAVE TO COMPLETELY REMOVE THE ENGINE FROM THE VEHICLE! THANKS AGAIN FORD!!!!!!!! *TR

WE MAINTAINED OUR VEHICLES REGULARLY, AFTER REPLACING THE TRANSFER CASE NOT 8 MONTHS AGO NOW THE TRANSMISSION WENT OUT. SPENT $2400 FOR A REBUILD. SHOP STATES THIS MODEL IS A PIECE OF [XXX], AND THE HAVE MADE A LOT OF MONEY FROM FORDS POOR ENGINEERING ON THIS MODEL. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

AFTER TURNING A CORNER AT LESS THAN 15 MPH A LOUD SOUND WAS HEARD AND THE ENGINE RACED BUT STOPPED MOVING. TRIED ALL GEARS AND AFTER HAVING IT TOWED TO A REPAIR FACILITY I WAS INFORMED THAT THE TRANSFER CASE BROKE.I HAD TO HAVE IT REPLACED. *TR

TL* THE CONTACT OWNS A 1997 FORD EXPLORER. THE CONTACT STATED THAT AS SOON AS THE VEHICLE WAS STARTED, IT ACCELERATED INDEPENDENTLY. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSIS AND THE CONTACT WAS INFORMED THAT THE SPEED CONTROL DEACTIVATION SWITCH HAD BEGAN TO LEAK INTERNALLY AND CAUSED THE FAILURE. THE CONTACT WAS INFORMED OF A RECALL FOR THE FAILURE UNDER NHTSA CAMPAIGN ID NUMBER: 09V399000 (VEHICLE SPEED CONTROL) HOWEVER, THE DEALER INFORMED HIM THAT THEY WERE ONLY REQUIRED TO STOP THE LEAK BUT NOT REPLACE THE DEFECTIVE PART. THE MANUFACTURER WAS NOTIFIED BUT OFFERED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 201,000. UPDATED 01/05/13*LJ UPDATED 2/13/2013 *JS

TL* THE CONTACT OWNS A 1997 FORD EXPLORER. THE CONTACT STATED WHILE DRIVING 45 MPH, THE TRANSMISSION FAILED CAUSING THE RPMS TO INCREASE CONTINUOUSLY. THE CONTACT DROVE THE VEHICLE TO THE DEALER FOR INSPECTION AND WAS ADVISED THAT THE SPEEDOMETER NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED AND STATED THERE WAS NOTHING WRONG WITH THE VEHICLE. THE FAILURE MILEAGE WAS 256,000.

TL* THE CONTACT OWNS A 1997 FORD EXPLORER 2 DOOR. THE CONTACT STATED THAT WHILE DRIVING VARIOUS SPEEDS, THE DRIVER'S SIDE SEAT BELT WOULD BECOME UNLATCHED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS WHERE THEY ADVISED HIM THAT THE SEAT BELT NEEDED REPLACING. THE MECHANIC WAS NOT ABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 187,000. THE VIN WAS UNAVAILABLE.