1997 FORD EXPLORER Complaints

PREPARING TO BRAKE FOR A CORNER ON A RAINY NIGHT, THE ANTI-LOCK BRAKES LOCKED THE WHEELS AND SLID ME INTO AN ONCOMING TRAFFIC LANE AT ABOUT 35 MILES PER HOUR. THE ONCOMING VEHICLE SWERVED AND AVOIDED A HEAD ON COLLISION WITH ME. ABOUT 20 SECONDS LATER DOWN THE ROAD THE ANTI-LOCK BRAKES LOCKED AGAIN AS I TURNED INTO MY DEVELOPMENT AND AGAIN I SLID. VEHICLE HAS BEEN SERVICED THROUGH ITS LIFE AND HAS A LITTLE OVER 52,000 MILES ON IT. I COULD BE DEAD RIGHT NOW HAD I NOT BEEN A SLOWER HIGHWAY. IT APPEARS THIS PROBLEM HAS EXISTED SINCE THE VEHICLE WAS PRODUCED AFTER READING ALL OF THE COMPLAINTS ON THIS SITE. *JB

INVALID DESIGN OF PLENUM DOOR LEADS TO PART FAILURE RESULTING IN INABILITY TO CONTROL TEMPERATURE SETTING. CONDITION CAUSES INABILITY TO CONTROL INSIDE AIR TEMPERATURE AND POSSIBLY FAILURE OF DEFROST/DEFOGGING SYSTEM (SAFETY ISSUE). COST TO REPAIR IS PROHIBITIVE ($500 TO $1000) DUE TO THE NEED TO REMOVE THE DASHBOARD AND THE REPLACEMENT OF THE ENTIRE AIR CHANNEL (BECAUSE PLENUM DOOR ITSELF CANNOT BE PURCHASED/INSTALLED ALONE). *NLM

SAFETY COMPLAINT INVOLVING A STUCK ACCELERATOR ON A 97 FORD EXPLORER. THE INCIDENT OCCURRED ON A COUNTY ROAD, WHILE TRAVELING A 50 MPH, WHEN A ATTEMPT WAS MADE TO SLOW DOWN THE VEHICLE AS IT APPROACHED AN INTERSECTION. AFTER SEVERAL ATTEMPTS TO APPLY BRAKES FAILED, I WAS ABLE TO MANEUVER THE VEHICLE TO THE RIGHT SHOULDER AND STOP IT BY SWITCHING OFF THE ENGINE. SEARCHING TO FIND THE SOURCE OF THE PROBLEM, I REACHED FOR THE ACCELERATOR PEDAL, WHICH WAS LOOSE AND SUBSEQUENTLY DANGLED IN MY HAND. THE VEHICLE WAS TOWED TO NORTH COUNTY FORD, VISTA CA., WHERE IT WAS REVEALED THAT"BROKEN ACCELERATOR BRACKET WELDS" WERE THE SOURCE OF THE PROBLEM. THE CAR WAS THEN REPAIRED AT A COST OF $132.89. ON MONDAY MAY 12 AND AGAIN ON TUESDAY MAY 13, I CALLED FORD MOTOR CO. CONSUMER SERVICE (800) 392-3673, TO REPORT WHAT I BELIEVE IS A SAFETY DEFECT IN THE VEHICLE AND TO REQUEST A REIMBURSEMENT FOR THE REPAIR. I WAS TOLD BY THE FORD REPRESENTATIVES THAT THE "INCIDENT" WOULD BE REPORTED TO THEIR ENGINEERING DIVISION, BUT SINCE THERE WERE NOT ANY RECALLS ON CASES SUCH AS THIS, THEY WOULD NOT COVER THE COST OF REPAIR. I CERTAINLY TAKE EXCEPTIONAL TO THEIR FINDING AND EXPRESSED MY DISAGREEMENT. THEREFORE, I REQUEST YOUR AGENCY TO LOOK INTO THIS INCIDENT AS I FEEL THERE IS A POTENTIAL HAZARD TO PUBLIC SAFETY AND TO HELP DETERMINE WHETHER OR NOT I AM DUE REIMBURSEMENT FOR THE COST OF THE REPAIR OF THIS DEFECT. *JB

MY EXPLORER ONLY PRODUCES WARM AIR FOR HEAT AND DEFOGGING WHEN THE TEMPERATURE OUTSIDE IS TOO HOT TO WANT OR NEED WARM AIR. THE DEALERSHIP SERVICE CENTER SAYS IT IS THE BLEND DOOR & ACTUATOR ASSEMBLY THAT HAS FAILED. I SAY IT DEFECTIVE BY DESIGN AND SHOULD BE REPAIRED AT THEIR EXPENSE, THEY DISAGREE. NOT BEING ABLE TO PROPERLY DEFOGG A WINDSHIELD IS A SERIOUS SAFETY ISSUE. *NLM

FORD EXPLORER HEATER PLENUM/ACTUATOR STOPPED WORKING THIS PAST WINTER. CLIMATE CONTROL IS STUCK ON COLD AND DEFROST DOES NOT WORK IN COLD WEATHER. DURING A ROAD TRIP TO A NEARBY CITY EARLY THIS SPRING I WAS BARLEY ABLE TO SEE OUT THE WINDSHIELD BECAUSE OF THE ICE AND FOG ON MY WINDSHIELD. I BELIEVE THIS IS A KNOWN MECHANICAL DEFECT BY FORD AND DEALERS. THIS IS A VERY DANGEROUS PROBLEM. IN CONTACTING SEVERAL SEATTLE-AREA DEALERS, ALL REFUSED TO FIX AS A SAFETY PROBLEM, SAID NO RECALL HAD BEEN ISSUED, SAID I WAS OUT OF WARRANTY, THIS IS ABSURD FOR A PROBLEM THEY CAUSED WITH FAULTY DESIGN AND PARTS THAT CAUSES SERIOUS VISIBILITY PROBLEMS IN MANY OLDER EXPLORERS. *JB

WHILE DRIVING THE CONSUMERS VEHICLE CAUGHT ON FIRE UNDER THE DASH. IT WAS LATER DETERMINED THAT THE CONSUMER NEVER RECEIVE A RECALL NOTICE RELATED TO THIS FAILURE BECAUSE SHE MOVED BUT THE MAIL WAS LATER ROUTED TO HER. THE CONSUMER WANTS TO KNOW WHAT ACTION CAN BE TAKEN SINCE THE RECALL HAS EXPIRED. *NLM

1997 FORD EXPLORER EQUIPPED WITH AN ELECTRONIC AUTOMATIC TEMPERATURE CONTROL SYSTEM. THE PLASTIC AIR BLEND DOOR IN THE HEATER PLENUM HAS BROKEN, PREVENTING THE SYSTEM FROM REGULATING THE TEMPERATURE.

IDLE NOT RETURNING AFTER CRUISE CONTROL WAS DISENGAGED AND BRAKES WOULD NOT WORK. CRUISE CONTROL KEPT ACCELERATING. MY THREE CHILDREN WERE IN THE CAR, WAS ABLE TO STOP THE CAR BY PUTTING IT IN NEUTRAL, AT THAT POINT THE BRAKES WORKED. PULLED TO THE SIDE OF THE INTERSTATE AND SHUT THE CAR OFF. WHEN TRYING TO START CAR AGAIN, ENGINE REVVED TO THE POINT WHERE IT SOUNDED LIKE IT WAS GOING TO BLOW UP. *NLM

THE VEHICLE WAS SERVICED ON 4/1/03 FOR THE CHECK ENGINE LIGHT. ON 4/14/03 CONSUMER ENTERED A PARKING LOT AND TURNED OFF VEHICLE IGNITION. CONSUMER RESTARTED THE VEHICLE, HEARD A THUMP, AND NOTICED THE BATTERY INDICATOR LIGHT WAS ILLUMINATED. THE DEALER DIAGNOSED THAT THE SERPENTINE BELT POPPED. *NLM

MY HEATER TEMPERATURE CONTROL BECAME INOPERATIVE. THE BLEND DOOR INSIDE THE PLENUM CHAMBER IS BROKEN AND NO LONGER MOVES (ON FULL HEAT). THE NEW PLENUM CHAMBER NOW CONTAINS A NYLON DOOR IN STEAD OF PLASTIC. THIS LOOKS LIKE FORD KNOWS THERE IS A PROBLEM WITH THE OLD STYLE DOORS BUT WILL NOT GIVE ANY ASSISTANCE ON REPAIRS. THE COST OF REPAIR IS STEEP! I WAS QUOTED $108.00 FOR THE PLENUM CHAMBER AND $598.00 TO INSTALL IT. FROM WHAT I HAVE LEARNED THE PROBLEM IS NOT ISOLATED TO ME, IN FACT THE DEALER I PHONED HAD JUST SOLD A REPLACEMENT PLENUM THE PREVIOUS DAY AND WAS WAITING FOR ONE TO ARRIVE TO FILL THERE STOCK. WHEN A DEALER STOCKS A PART THERE USUALLY IS A LARGE DEMAND FOR IT! *NLM