2003 FORD EXPLORER Complaints

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THERE WAS A CRACK ON THE FRAME OF THE VEHICLE STARTING FROM THE BOTTOM OF THE REAR GLASS GOING DOWN TOWARD THE MANUFACTURER'S EMBLEM. THE DEALER AND THE MANUFACTURER WERE NOTIFIED OF THE FAILURE BUT DENIED ANY ASSISTANCE WITH REPAIRS TO THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 86,000 AND THE CURRENT MILEAGE WAS 96,000.

MY 2003 FORD EXPLORER WAS IN THE SHOP FOR A FUEL SMELL AND DIAGNOSED WITH A FUEL TANK LEAK AROUND THE FUEL FILLER HOSE AT THE GAS TANK. THERE IS VISIBLE CRACKING ON THE PLASTIC SURROUNDING THE BASE OF THE FILLER NECK AS IT ATTACHES TO THE FUEL TANK WITH CONSTANT FUEL SEEPAGE. I CALLED THE CUSTOMER RELATIONSHIP CENTER AT FORD MOTOR COMPANY WITH THE HOPE THAT THEY WOULD BE CONCERNED ABOUT THIS SERIOUS ISSUE AND WAS GIVEN A CASE NUMBER AND ASKED TO TAKE MY VEHICLE INTO MY LOCAL FORD DEALER'S SERVICE DEPARTMENT FOR AN INSPECTION TO VERIFY THE PROBLEM. I LEFT MY VEHICLE WITH THEM FOR AN ENTIRE DAY AND WAS TOLD AT THE END OF THE DAY THAT THERE WOULD BE NO ASSISTANCE AVAILABLE FROM FORD AND THEREFORE NO WORK OR INSPECTION WAS PERFORMED BY THE SERVICE DEPARTMENT. THIS IS A CRITICAL FORD MOTOR COMPANY ENGINEERING PROBLEM AND WOULD HOPE THEY WOULD TAKE A SERIOUS INTEREST IN RESOLVING SUCH A HAZARDOUS ISSUE. *TR

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THE REAR LIFTGATE GLASS BOLT BRACKETS DETACHED FROM THE HINGES, CAUSING THE GLASS TO DETACH. THERE WAS A RECALL ASSOCIATED WITH THE DEFECT UNDER NHTSA CAMPAIGN ID NUMBER 04V442000 (STRUCTURE: BODY: HATCHBACK/LIFTGATE: HINGE AND ATTACHMENTS) BUT THE VEHICLE WAS INELIGIBLE FOR THE RECALL REPAIR DUE TO THE BUILD DATE. THE VEHICLE HAD NOT BEEN REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 85,000.

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE VEHICLE WAS INCLUDED IN THE RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 04V442000 (STRUCTURE:BODY:HATCHBACK/LIFTGATE:HINGE AND ATTACHMENTS). AFTER THE REPAIRS WERE PERFORMED THE CONTACT ATTEMPTED TO OPEN THE LIFT GATE WHICH SEPARATED FROM THE STRUT AND DETACHED FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO REPLACED THE HINGES. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.

BODY MOUNTS PREMATURELY DETERIORATING AND CRUMBLING. BODY RIDES LOOSE ON FRAME, WHICH CAN IMPACT SAFETY OF THE VEHICLE AND HANDING IN AN ACCIDENT. ALL BODY MOUNTS FOR THE CAB OF THE VEHICLE HAVE FAILED AND FALL APART TO THE TOUCH. SINCE THIS VEHICLE IS A BODY ON FRAME DESIGN, FAILED BODY MOUNTS CANNOT KEEP THE CAB FIRMLY ATTACHED TO THE FRAME OF THE TRUCK. APPARENTLY THE RUBBER MATERIAL USED WAS DETECTIVE. *TR

MY 2003 FORD EXPLORER HAS A CRACKED REAR PANEL. THIS IS THE SECOND TIME IT HAS HAPPENED. THE FIRST TIME IT WAS COVERED BY WARRANTY AND FORD REPAIRED IT AT NO CHARGE. THIS TIME THEY WILL NOT. I WAS TOLD IT WILL COST APPROXIMATELY $300.00 AND IT WOULD HAPPEN AGAIN. THE CRACK DEVELOPS RIGHT IN THE MIDDLE OF THE PANEL UNDER THE REAR WINDOW. *TR

WHEN I WAS SWITCHING THE GEAR FROM REVERSE TO DRIVE AT A GAS STATION, THE SHIFTER LEVER WAS SNAPPED OFF. I CANNOT MOVE THE CAR ANY MORE, AND THE KEY GOT STUCK IN THE STEERING COLUMN. I FIND LOADS OF OTHERS HAVE SAME PROBLEM HAPPENED AND FORD IS NOT DOING ANYTHING ON THIS DANGEROUS/COULD BE FATAL PROBLEM. *TT

I HAVE A 2003 FORD EXPLORER, RAN TO THE STORE LAST NIGHT TO BUY GROCERIES. LOADED THINGS INTO MY TRUCK, CLOSED THE DOOR AND THINGS WERE FINE. ARRIVED HOME TO REMOVE THE GROCERIES AND THERE WAS A 6 INCH LONG CRACK ON THE REAR HATCH OF MY TRUCK RIGHT BESIDE THE FORD LOGO AND REAR WINDSHIELD WIPER. I TAKE PRIDE IN MY VEHICLE AND KEEP IT CLEAN AND THE OUTSIDE BODY IS PERFECT; UNTIL THIS HAPPENED. I AM DISAPPOINTED THAT I CALLED FORD AND THERE IS NO RECALL IN REGARDS TO THIS, BUT THERE ARE HUNDREDS OF COMPLAINTS ONLINE ABOUT THE EXACT SAME ISSUE. I WANT FORD TO PAY FOR THE REPAIR OF THIS. I HAVE BEEN A LOYAL FORD CUSTOMER AND SO HAS BY FAMILY SINCE THE EARLY 1980S. I WILL PROBABLY NEVER PURCHASE ANOTHER FORD AS THIS IS JUST ANOTHER ISSUE THAT FORD WON'T ACKNOWLEDGE. *KB

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. WHILE DRIVING 50 MPH, THE OVERDRIVE AND CHECK ENGINE WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TOWED TO THE DEALER WHO INSPECTED THE FAILURE AND INFORMED THE CONTACT THAT THE TRANSMISSION WAS FAULTY AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED WHO ADVISED THAT THERE WERE NO RECALLS FOR THE FAILURE AND OFFERED NO FURTHER ASSISTANCE. THE FAILURE MILEAGE WAS 175,024.

I WAS DRIVING AT 60 MPH AND APPROACHING A RED LIGHT 1/4 MILE AHEAD I RELEASED PRESSURE ON THE ACCELERATOR BUT THE CAR MAINTAINED 60 MPH AND WOULD NOT SLOW DOWN, I APPLIED THE FOOT BRAKES BUT REALIZED THIS WAS NOT THE ANSWER, IT FELT LIKE THE CRUISE CONTROL WAS NOT RELEASING HOWEVER THE CRUISE CONTROL NOT BEING USED, I PLACED THE CAR IN NEUTRAL AND BRAKED TO A STOP THE ENGINE WAS RACING. I TAPPED THE ACCELERATOR WITH MY FOOT AND THE ACCELERATOR PEDAL RETRACTED , THE ENGINE SLOWED,I CONTINUE MY TRIP AND AFTER DRIVING A FEW MILES FOUND THAT THE ACCELERATOR WAS STUCK AGAIN,I SELECTED NEUTRAL AND TAPPED THE ACCELERATOR,THE ENGINE WENT BACK TO IDLE.I PULLED OVER AND LOOKED AT THE ACCELERATOR CABLE WHERE IT CONNECTS TO THE ACCELERATOR TO MAKE SURE THE ACCELERATOR WAS NOT CAUGHT ON THE CARPET, I OPENED THE HOOD TO CHECK THE ACCELERATOR CABLE WHICH WAS HIDDEN UNDER A LARGE PLASTIC SHROUD (COVER), I REMOVED THE SHROUD IN AND IMMEDIATELY DISCOVERED THE PROBLEM. A SMALL CHEAP SNAP AND LOCK FASTENER IN THE END OF THE CRUISE CONTROL CABLE HAD BROKEN ALLOWING THE STIFF CRUISE CONTROL CABLE CONNECTOR TO SLIP FROM ITS CONNECTOR AND RESTRICT OR LOCK THE RETARDING MOVEMENT OF THE ACCELERATOR CABLE, THE THROTTLE CABLE DOES NOT RETRACT AND THE ENGINE IS STUCK AT A HIGH RPM AND A NOVICE DRIVER WOULD NOT KNOW WHAT TO DO AND WOULD PROBABLY PANIC AND EVENTUALLY THE BRAKES WOULD FADE AND THE DRIVER CRASH. WHEN THE REMEDY IS TO 1) SHIFT TO NEUTRAL AND 2) TAP AND RELEASE THE ACCELERATOR QUICKLY WHICH BECAUSE THE CRUISE CABLE IS NOT ATTACHED OR ANCHORED AT IT'S END QUICKLY FREES THE ACCELERATOR CABLE IN MY OPINION THIS CRUISE CONTROL CONNECTOR AND WEAK METAL SPRING TYPE PUSH IN FASTENER IS TOO WEAK AND SUFFERS FROM METAL FATIGUE OVER TIME. I AM JUST GLAD MY WIFE WAS NOT DRIVING ALONE WHEN THIS HAPPENED. *TR