2003 FORD EXPLORER SPORT TRAC Complaints

drivers side rear brake line developed a hole caused by the emergency brake cable rubbing against it causing all the brake fluid to leak & the brakes failed. Fortunately my husband was driving on our rural road & not out on the main highway. We have not been able to get it repaired yet.

The driver was driving down the expressway and her back tire blew out causing her vehicle to spiral out of control and the vehicle then flipped and started rolling downhill, the vehicle airbags did not deploy in the vehicle at all. The driver and her mother are in critical condition. Yes, the safety of others safety was put at risk. I did contact Ford Manufacturer on her behind of the airbags and they said there is nothing they can do for her with the vehicle being totaled out. But my main problem is why these airbags did not deploy. The vehicle is going to be inspected by her insurance company here in the next few days. There were no prior lamps, messages, or anything that would have indicated that the airbags were defective.

TAKATA RECALL .. THE SMELL OF FUEL INSIDE THE CAB AND OUTSIDE IS REALLY BAD. IT'S MAKING ME SICK AND GIVING ME HEADACHES. THE TRUCK DOESN'T RUN RIGHT AND THE MILEAGE IS AWFUL.

WE HAD PURCHASED THIS VEHICLE BOUT A YEAR AGO AND WHEN WE GOT IT WE WENT TO GET TIRES AND FRONT END ALIGNMENT AND THEY ENDED UP REPLACING UPPER ND LOWER BALL JOINTS, CONTROL ARM AND SWAY BAR ON PASSENGER SIDE.THIS WAS 6/20/2017. IT WASN'T MAKING ANY NOISE UNTIL 1/3/2018. I WAS GOING DOWN CITY STREET AND SOMETHING POPPED AND THEN IT STARTED ROARING. IF YOU PUT IN 4WD IT ROARS LOADER AND JERKS. 1/23/18 REPLACED DRIVERS SIDE WHEEL HUB AND BEARINGS. IT STILL ROARS WHILE ACCELERATING SPEED BUT NOT AS BAD IN 2WD BUT PUT IN 4WD ITS REAL LOUD AND JERKS YOU . I HAVE DONE RESEARCH ONLINE FOR THIS YEAR MODEL SPORT TRAC AND IT SEEMS LIKE THERE ARE SEVERAL COMPLAINTS ABOUT THIS SAME ISSUE. EVERYTIME GET ONE THING FIXED ON FRONT END SOMETHING ELSE HAPPENS TO IT. YOU CAN DRIVE IT BUT IF YOU GET OVER 10-15 MPH THE ROARING GETS WORSE AND IT LOCKED THE THE WHOLE WHEEL UP AND JERKED THE TRUCK TO THE SIDE OF THE ROAD

THE CAB TO FRAME MOUNTING BOLT BUSHINGS, AND STEERING STABILIZER BUSHINGS ARE HAVE AND ARE CRUMBLING. ALL NEED TO BE REPLACED. I FEEL FORD IS AWARE OF THIS PROBLEM AND SHOULD HAVE TO FIX IT. I JUST INHERITED THIS TRUCK AND JUST FOUND OUT ABOUT THIS. THANK YOU.

TRUCK WAS RUNNING FINE. THEN ON SEVERAL OCCASIONS IT WOULD SLIP OUT OF GEAR WHILE I WAS COMING OFF OF OR ONTO EXIT RAMPS. SEEMED LIKE AS THE ENGINE DECELERATED IT WOULD SLIP INTO NEUTRAL. SOMETIMES IT WOULD EVENTUALLY FIND THE GEAR AND SOMETIMES I HAD TO COME TO A COMPLETE STOP, WHICH WAS REALLY SCARY SINCE I WAS IN TRAFFIC WHEN THIS HAPPENED. A SHORT TIME LATE (A MATTER OF WEEKS). I NOTICED IT WOULD NOT GO INTO GEAR WHEN THE TRUCK WAS COLD (AFTER SITTING OVERNIGHT. THIS HAS RAPIDLY PROGRESSED INTO ALMOST COMPLETE FAILURE. I CAN STILL GET THE TRUCK TO MOVE IF I SHIFT MANUALLY INTO L1 OR L2 BUT D DOES NOT WORK AT ALL. ADDITIONALLY I NOTICED THAT SOMETIMES MY O/D LIGHT WOULD BE BLINKING AND SOMETIME O/D WOULD GO COMPLETELY OFF AND THE TRUCK WOULD NOT SHIFT INTO HIGH GEAR. I FOUND IF I STOPPED, TURNED THE TRUCK OFF AND RESTARTED IT WOULD OFTEN FIX THE ISSUE. THIS IS NOT LONGER TRUE. I WILL BE TAKING THE TRUCK TO MY MECHANIC ON MONDAY. I LOOKED UP THE ISSUE AND SEE THAT THIS IS COMMON COMPLAINT WITH MANY EARLY 2000 FORD VEHICLES. SHAME THE COMPANY DOES NOT RECOGNIZE IT'S FAILURE AND STAND UP AND FIX IT. I DID NOT HAVE ANY ACCIDENT DUE TO THIS ISSUE BUT I COULD SEE IF THIS FAILURE OCCURRED AS SOMEONE WAS PULLING INTO TRAFFIC OR IN THE MIDDLE OF HEAVY TRAFFIC THAT THIS COULD DEFINITELY CAUSE A SERIOUS ACCIDENT.

I WAS LEAVING THE STORE PARKING LOT. I STARTED THE CAR, PRESSED THE BREAK, PUT THE VEHICLE IN DRIVE AND THE PASSENGER SIDE AIRBAG DEPLOYED. THIS IS THE SECOND TIME THIS HAS HAPPENED SINCE THE FIRST INCIDENT IN SEPTEMBER 2014. THE VEHICLE WAS NOT HIT OR BUMPED IN ANY WAY. I WAS NOT BACKING OUT, I WAS IN DRIVE TO PULL OUT OF THE SPACE. *TR

TOOK VEHICLE IN FLUID CHANGES, COMPLETE CHECK, AND TO INVESTIGATE A LEAK UNDER VEHICLE. AFTER "COMPLETE" CHECK SAID THEY FOUND BAD SERPENTINE BELT, AIR FILTER AND BUT NOTHING VALVE COVER GASKETS AS CAUSE OF LEAK. COST TO REPAIR GASKETS OVER $1000. WHILE DOING REPAIR THEY CALLED AGAIN AND SAID THEY FOUND THAT THE REAR TIMING CARTRIDGE WAS BROKEN AND PIECES OF IT MISSING. TOLD ME THAT BOLT WAS WORE HALF WAY THROUGH AS TIMING CHAINING WAS RUBBING IT. SAID IF IT BREAKS BEFORE REPAIR ENGINE WILL "BLOW" AND NEED TO BE REPLACED. TOLD ME IT WOULD COSTS OVER $2,500 TO REPLACE THIS CARTRIDGE. TOTAL COST WAS NOW OVER $4,000. I ASKED WHY PART WAS BAD WHEN ENGINE ONLY HAD 84,000 MILES AND WHY THIS WASN'T FOUND WITH THE "COMPLETE" CHECK. MECHANIC STATED ONLY SAW IT BECAUSE HE HAD THINGS APART TO FIX VALVE COVER GASKETS. TOLD ME IT WAS A PLASTIC PART AND EVEN WITH LOW MILEAGE THE PLASTIC DETERIORATES WITH TIME. SAID PART ONLY DESIGNED TO LAST 100,000 MILES. IF I AM TO BELIEVE THIS FORD MECHANIC, FORD USES A PLASTIC PART IN A CRUCIAL PART OF THE ENGINE (TIMING) AND IF THAT PART FAILS THE ENGINE WILL "BLOW". AND THEY CANNOT KNOW THE PART IS BAD UNLESS THEY HAVE THE ENGINE APART FOR OTHER MAJOR REPAIRS. SO IF THE VALVE COVER GASKETS WERE NOT LEAKING THE ISSUE WOULD HAVE BEEN UNDETECTED BY THE FORD MAINTENANCE "COMPLETE" CHECK UP. IN ADDITION FORD HAS NOT ISSUED A WARNING THAT THIS ENGINE WILL POSSIBLY "BLOW" AFTER ONLY 100,000 MILES IF THIS PART NOT REPLACED BY A $2,500.00 - $3,000.00 REPAIR. FORD SHOULD PAY FOR THIS REPAIR. THEY DESIGN A VEHICLE THIS WAY WITH NO WARNING TO THE BUYERS/OWNERS. IF I AM TO BELIEVE THE FORD MECHANIC THERE IS NO WAY TO REALLY KNOW YOU MAY HAVE A PROBLEM. HOW ARE WE TO PROTECT OURSELVES? MY FRIEND SHOWED ME THIS SITE AND DID SOME SEARCHING ON OTHER BLOGS/SITES DEALING WITH VEHICLE ISSUES. THERE ARE NUMEROUS CASES OF THIS UNACCEPTABLE ISSUE. *TR

TL* THE CONTACT OWNS A 2003 FORD EXPLORER SPORT TRAC. THE CONTACT STATED THAT THE VEHICLE IGNITED IN FLAMES WHILE PARKED IN THE DRIVEWAY. THE CONTACT DID NOT DISCLOSE HOW THE FIRE WAS EXTINGUISHED. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 180,000.

MY FORD SPORT TRAC HAS FAILED TO LOCK WHEN THE GEAR SHIFT IS PUT INTO THE PARK POSITION. WHEN YOU START TO GET OUT THE VEHICLE WILL ROLL AND YOU WILL HEAR A CLICKING NOISE IN THE TRANSMISSION. IT HAS DONE THIS FOR SOME TIME AND I HAD IT FIXED ONCE BUT IT IS DOING IT AGAIN. *TR