2018 FORD EXPLORER Complaints

No incident yet.Between front door and back door, trim not secure. Is this included in recall #24V031?

car developed leaks and a mold smell. brought car to dealer, apparently, sunroof drains were plugged up cause water to build up in the car. The mold is making my wife and I sick. This is a severe health hazard caused by a manufacturing or design defect. The service dept at the dealer tried 3 or 4 time to sanitize, all failed and now they recommend replacing ALL of the upholstery in the car, rugs, headliner and seats. Mold has permeated this vehicle and it is not driveable. Ford should issue a recall for this problem and cover any costs.

Ford explorer transmission is out and at 62000 miles just under 5 years old. While driving vehicle it will loose power, making it difficult to drive safely. vehicle is currently at a ford dealership that verified issued. Ford motor company states must submit complaint here. when vehicle looses power it states "check manual" with a wrench symbol. No check engine is displayed.

Three times within the last 4 years I have had a Map Sensor failure. I was told the first time, this is rare. I was told the second time, this never happens twice. This time I'm told that they just don't know what is causing it. Must be 3 bad sensors in a row somehow. The engine failure on [XXX] was nearly catastrophic and I nearly died. I was going 70mph on a [XXX] at [XXX]. [XXX] can be dangerous under the best conditions, this was during dangerous storms along with being at rush hour. The engine completely stalls and I lose all power to drive. The first time it happened in a parking lot in August of 2020. The second time was Sept of 2022 and I was in my neighborhood. Sunset Ford has no explanation and have repaired it and sent me on my way once again. There are no signs this will happen - it just suddenly happens and I have no ability to react due to the complete engine stall. I have also had 2 oil system failures with this vehicle. It has only 42k miles on it. I do not feel safe driving this vehicle. I don't understand how this is acceptable at all honestly. How can I feel safe driving my children in this vehicle? 5 major repairs in just over 4 years. Have the repairs been done correctly? I question why more has not been done to ensure that another catastrophic event doesn't happen that could result in death of myself or family. Even my numerous requests for information and service reports were met with resistance and what seems like attempts at hiding information from Sunset Ford. Not only could I have been seriously injured or killed, but this could have caused a large scale accident affecting many others on that hwy. This feels negligent by either Sunset Ford or by Ford Mo Co. This should not happen in a safe and reliable vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2018 Ford Explorer. The contact stated that while driving at 40 MPH, there was an abnormal sound coming from the driver's side of the front window. The contact's wife observed a piece of the molding flapping. No warning light was illuminated. The vehicle was taken to a dealer, where it was diagnosed that the exterior A-pillar trim needed to be replaced. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. VIN tool confirms parts not available. The failure mileage was approximately 42,100.

The contact owns a 2018 Ford Explorer. The contact stated while driving approximately 55 MPH, a tractor trailer truck passed by in the opposite lane and the rear GPS fin and the radio antenna blew off the vehicle. The contact stated that the loss of the rear fin exposed the electrical circuits to the wind and water. The contact stated no warning light was illuminated. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle was not diagnosed and was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 98,000.

The contact owns a 2018 Ford Explorer. The contact stated that the rear backup camera would display a blue image on the infotainment screen. The dealer was notified of the failure and informed the contact that there were no recalls on the vehicle. The manufacturer was also notified of the failure and was given the same information as the dealer. The vehicle had yet to be repaired. The failure mileage was approximately 42,000.

The contact owns a 2018 Ford Explorer. The contact stated that the vehicle was parked when there was heavy rain in the area. The contact stated that after the heavy rain passed when they were placing items in the back seat, they noticed that water was in the cup holder. The contact discovered a crack in the sunroof allowing water to enter the vehicle. The contact stated that the failure recurred multiple times. The contact was concerned that there was no impact on the sunroof to have caused it to crack. The vehicle was taken to a dealer where the vehicle was diagnosed with a cracked sunroof frame. The vehicle was not repaired and remained at the dealer. The manufacturer was notified of the failure. The failure mileage was 99,000.

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000(Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

Frame around windshield is loose on the right. Rattles when driving at higher speeds.