2018 FORD EXPLORER Complaints

While driving on the interstate the piece of trim along the passenger side windshield flew off. No warnings. I am unsure if it caused any damage to anyone driving near me. It took me a moment to realize what had happened. I took the car to Ford repair where they had to replace the pillar molding, pillar molding hardware kit, and pillar molding mount bracket.

On the exterior this car has a plastic A-pillar cover on both sides of the windshield, i already had one fly off on expressway ( luckily didnt hit anyone or cause an accident) i replaced the one, but now the other side is coming loose as well, not sure if its a defect in the clips or the design , but the dealer doesnt acknowledge this to be a problem, there happily charging 600.00 to replace each A-pillar and they keep coming loose

Was driving on the high way and the B pillar trim detached and was hanging by the wire. No damage was done to this area prior and appears the adhesive gave out. Due to incident back lift gate is inoperable and displays as open.

I was driving on the freeway when one of my A pillers flew off and cause the person behind me to loose control of their car. About 5 min later the other a piller flew off almost causing an accident with a semi and trailer.

My screen went black for my Ford Explorer. I have no access to climate controls, backup Camera, radio, GPS, etc. My local Ford dealership said there was a recall pending but that’s been a few months now. It’s very dangerous driving like that with my 4 and 2 year old in the car.

The passenger windshield trim piece blew off my vehicle on the interstate yesterday and caused the vehicle behind me to swerve to try to avoid it. Looking through my rear view mirror, the driver appeared to lose control due to over correction. The driver avoided a collision and crash, but it looked hairy for a few moments. The driver's side trim piece blew off my vehicle last year. After Googling, I see that this is a very common problem that should be addressed, in my opinion, with a recall due to safety.

January 2023 - vehicle shifts hard, revs high between shift points, almost jumps between shifts. Trouble code p0757- shift solenoid “b” stuck open. 85,000 miles. Cost to fix $900. December 2023 - same code, same symptoms. Now entire transmission needs to be replaced at a cost of $6600. 100,000 miles.

After dealer inspection of my 2018 Ford Explorer, I was informed that the rear knuckles needed replacement due to cracked bushing. I was informed that this is a safety issue that needs to be addressed immediately, at a cost of $2400.00. After some cursory research I found that there was a recall for 2011-2017 Ford Explorers with the same issue, but not for 2018. This is obviously a known problem and should be addressed for 2018 vehicles.

The contact owns a 2018 Ford Explorer. The contact stated that while driving approximately 55 MPH, the passenger’s side trim detached from the vehicle. The trim struck the front windshield of another vehicle, causing the other driver to lose control of the vehicle and the vehicle spun out. The contact was unsure if the front windshield was cracked due to the impact. There were no reported injuries. The contact called the local dealer and was referred to a Collision Center for assistance. The vehicle was not diagnosed or repaired. The Collision Center was contacted and provided an estimate for the repair. The manufacturer was contacted, opened a case, and referred the contact to the NHTSA Hotline. The failure mileage was approximately 99,800. The VIN was not available.

Windshield cowl (trim) had deteriorated, possibly due to common heat and sun damage. 1. We do not know whether or not the deteriorated cowl will affect windshield stability or water leaks. If windshield stability is affected, it would affect safety. 2. Other complaints have noted that pieces of deteriorated cowl/trim have impacted safety of nearby vehicles. 3. The vibration, humming, and buzzing are irritating to drivers and passengers. // This observed deterioration occurred when the vehicle was 5 years old, however, we know of the same problem occurring in a 2019 Explorer at about 3 years. // The local Ford dealer stated it would cost over $650 to replace the cowl.