2018 FORD EXPLORER Complaints

Attempted to make an appointment on XXX with [XXX], 2121 W Bell Rd, Phoenix, AZ 85023 phone 602-375-7400 to have the two open safety recalls completed( 26V101 & 24v031). Could not make a service appointment because the service writer said that parts were not available and had no idea of when they would be available to fix the safety recalls. Service writer indicated they COULD NOT notify me when parts were available. I was to continuously call them for follow up as to when the car could be fixed. I continue to use the vehicle in spite of the safety defects as I can not afford another transportation method. Please help me get my Explorer fixed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The driver side Keyless door entry pillar has come off on the highway and hit something. The keyless door entry panel came off in 2023 and Koons Ford of Annapolis charged me $ 523.00 to fix the panel. The panel has a small clip and double stick tape. Sorry, double stick tape is not going to hold up to weather variations throughout the year, wind speed and age. Terrible and dangerous design. You gave 2017 a Recall 25S53 for ford but NOT 2018

The horn on my vehicle activates (blows) when I turn the steering wheel to certain positions. I believe this to be a road hazard. Especially since I had to remove the horn relay to prevent the horn from blowing in traffic until I can get it repaired. Several other Ford vehicles have been recalled for this exact problem. Just to diagnose this problem at the Ford dealer is $170.00. Help!

The exterior A-pillar applique trim piece began detaching from the vehicle while driving. The part became loose and was hanging from the vehicle whilst in motion, at which point I safely pulled over and removed it to prevent it becoming a road hazard. The trim is now fully detached and available for inspection upon request. Upon checking Ford's official recall portal, the recall is confirmed as incomplete against this vehicle with the status "remedy not yet available." Ford's own recall notice stated parts were anticipated in the latter half of 2024 — it is now June 2026 and parts remain unavailable, representing an 18-month overrun on Ford's own published commitment. No warning was given prior to the trim becoming loose. No crash, fire or injury occurred. I am requesting this be logged as an active safety incident rather than a routine pending recall, and that NHTSA apply pressure on Ford to prioritize parts availability for owners whose trim has already physically detached while driving.

The transmission completely failed without any warning lights or any other audible or visible signs of failure. This left my stranded on the side of the road. The local dealership has told me that I do have to replace the transmission. I have since called Ford Manufacturing's customer service department who told me there are no programs available to help assist with the cost of the transmission repair. There were no lamps, messages, sounds, smells, or visual cues.

I had 2 recalls on my 2018 Ford Explorer and when I was finally notified parts were available for both I took to dealer to have them both fixed. Ford fixed the recall (rear suspension toe link - 26S08/26V101) but could not completely repair the other A Pillar Trim recall (24S08/26V101) because they said parts were not available. My letter clearly states they were. Ford ripped off my A pillar trim exposing both sticky and jagged plastic edges not only making an unsightly appearance but safety hazard. I have grabbed this area several times getting in and out, scraping my hands, staining my skin and clothes with the adhesive left on and get foreign objects stuck in this area.

The driver’s side B-pillar popped off while driving on the highway at appx. 65mph. It snapped in half. The top portion is gone but the wired portion with the keypad is remaining still. The passenger side looks like it may come off as well.

On March 26, 2026, my vehicle received the rear suspension toe link replacement under Ford/NHTSA Recall 26S08 (26V101000). Within approximately 5 weeks, all four rear tires were completely destroyed by misalignment caused by Ford’s non-adjustable replacement parts. On approximately May 2, 2026 — during the first rain after the recall service — my vehicle hydroplaned and skidded uncontrollably, creating a serious risk of collision and injury. On May 4, 2026, Mavis Tire & Brake [XXX] ) confirmed the cause: Ford’s non-adjustable recall toe link replacement had left my rear wheels severely out of alignment (rear total toe measured 2.09° — over 4x outside the acceptable range of 0.10°–0.50°). The Mavis Service Manager documented in writing on Invoice #21381: “REPLACED REAR ARMS WITH ADJUSTABLE ARMS TO CORRECT ALIGNMENT.” The Mavis technician noted I was the second Ford Explorer customer within the same few weeks to present with this identical defect. I paid $1,507.93 out of pocket for four replacement tires, two new adjustable control arms to replace Ford’s defective recall parts, and alignment service. KEY EVIDENCE IN MY POSSESSION: • Mavis Invoice #XXX ($1,507.93) with Service Manager’s written admission • Pre- and post-repair alignment reports showing extreme misalignment and full correction • Photographs of destroyed Bridgestone Alenza 255/50R20 tires (severe inner-edge wear) • Ford dealership video from March 26, 2026 showing tires in good condition before recall service • VIN door sticker confirming vehicle specs • Complete case overview document prepared for submission INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

A-Pillar Trim flew off on the highway and almost caused a accident. The second one is also coming off. There was a recall for certain VINs but somehow mine wasn't included in the recall.

Subject: BBB Auto Line Claim – Water Intrusion and Sunroof/Moonroof Motor Damage Related to Recall To Whom It May Concern, I am submitting this written statement as supporting explanation to claim # XXX) with regarding my 2018 Ford Explorer Sport (VIN: [XXX] ) and issues related to a known exterior trim defect that allows water intrusion into the vehicle. Ford has issued recalls and service campaigns related to exterior trim components on the 2018 Ford Explorer, including A-pillar and roof rail trim that may become loose or improperly sealed. These components can allow water to enter the vehicle structure. As a result of this defect, my vehicle has experienced water intrusion that has affected the sunroof/moonroof system, including the motors and associated components. The presence of water in this area has caused malfunction of the sunroof/moonroof and track operation and has created the potential for further electrical damage. The condition appears to be directly related to the trim defect that Ford has acknowledged through safety recall campaigns affecting the 2018 Ford Explorer. Despite this known issue, the damage to the sunroof/moonroof components has not been fully addressed. I am requesting that Ford Motor Company: 1.Acknowledge that the trim defect allowing water intrusion contributed to the damage of the sunroof/moonroof and tracking system. 2.Cover the cost of diagnosing and repairing any damaged sunroof/moonroof motors and related components. 3.Ensure that all recall-related trim repairs are properly completed to prevent further water intrusion. This claim is being filed because the defect originates from a manufacturing issue that has been the subject of recalls affecting this model. As a consumer, I should not be responsible for repairs caused by a defect acknowledged by the manufacturer. Vehicle Information Year/Model: 2018 Ford Explorer Sport VIN: [XXX] Manufacturer: Ford Motor Company I respectfully request that INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 5