2018 FORD EXPLORER Complaints

The NHTSA has opened an investigation into 2011-2019 models experiencing an issue with the windshield trim panel. The trim panels are cracked and disintegrating and pieces are missing posing a hazard while the vehicle is being operated at highway speeds.

The contact owns a 2018 Ford Explorer. The contact stated that while driving at approximately 80 MPH, the vehicle stalled without warning. The contact stated that she was able to coast the vehicle off the roadway safely. The vehicle was then towed to an independent mechanic where the failure could not be duplicated; however, the failure recurred. The contact stated that while driving at an undisclosed speed, the vehicle stalled without warning. The contact stated that a message then flashed on the instrument panel “Full Accessory Active”. The contact stated that the following day, she attempted to start the vehicle, but the engine failed turnover. The contact stated that she waited approximately 30 minutes to an hour and was able to restart the vehicle. The vehicle was taken back to the independent mechanic, but the failure could not be duplicated. The failure recurred. The vehicle was not repaired. The dealer was not notified of the failure. The manufacturer was notified of the failure and the contact was provided a case number and advised to contact the NHTSA Hotline. The failure mileage was approximately 79,008.

I have owned this vehicle for a year and have gone through three batteries. It shows multiple coded for circuit shorts - Passenger mirror motor, tailgate/liftgate/trunk motor as well as the cinch striker motor, instrument panel which has lost communication with cruise control module, power steering module, battery voltage circuit below threshold, driver side curtain deployment control 1 circuit short to ground, switch illumination. When the vehicle is stopped or parked it constanly idles up to 1000 to 1500 rpms. These are all the codes that are showing on my vehicle. There has to be some sort of issue causing these problems. What happens if my airbag deploys without warning causing me to cause a major accident which can harm myself, my spouse, children and the people around me.

Right side windshield trim panel detached from the car while moving. Had to purchase two different pieces at a cost of approximately $139.00 each. Plus the cost of installation.

As I was driving on to the grocery store on a stop light I heard a rattle sound deflecting to another vehicle, the other vehicles driver heard the noise and noticed a puddle of water,and notified me. Emediatly i pulled over. Indeed, there was leak, unfortunately couldn't tell where it was coming from .I Called my mechanic, and a tow truck.My mechanic called me today October 11,2023 to notify me that the water pump had failed.He asked me if there had been any warning sings or temperature change,I responded no.He told me that if the incident had happened on the highway, I might have caused damage to the engine and potentially the vehicle might have shut off do to over heating.Keep in mind that my 2018 ford explorer only has 70,000 miles.Now I'm stuck with a bill of 1,400 dollars.Im gonna get an update tomorrow October 12,2023 on my vehicle status, if there was anything else damaged do to the water pump failure.No lights or warning sings were lid on my dashboard.

The windshield trim has come loose & come off on the left side while going down the road. The right side is beginning to do the same thing. I noticed pieces missing on 10/10/23 & on 10/11/23 a big piece flew off the car as I was driving down the highway.

The contact owns a 2018 Ford Explorer. The contact stated that while self-inspecting the vehicle, he noticed the paint on the front of the hood was corroded and peeling. The vehicle was taken to the dealer; however, the dealer informed the contact that his VIN was not included in an unknown recall. The manufacturer was made aware of the failure and referred the contact to file the complaint with the NHTSA hotline. The failure mileage was approximately 12,000.

The car had catastrophic engine failure. It had zero mechanical issues and all routine maintenance. It started rough a few times. Which I now know was a misfire. It then overheated while driving. Brought to a mechanic who said it was a blown head gasket. The coolant leaked into the oil. Engine had to be replaced at 102,000 miles.

The contact owns a 2018 Ford Explorer. The contact stated that on several occasions while in reverse, the back-over prevention screen displayed a black screen preventing the image from being seen. The vehicle was taken to a dealer where it was diagnosed that the APIM needed to be replaced. The vehicle was not repaired. The contact stated that the manufacturer was notified of the failure. The failure mileage was approximately 90,000.

The contact owns a 2018 Ford Explorer. The contact stated that while the vehicle was idling at a stop, the vehicle hesitated while responding. No warning lights were illuminated. The contact stated that the vehicle was diagnosed, and it was determined that the torque converter had overheated. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The vehicle was then towed to an independent mechanic for a second opinion where it was determined that the transmission needed to be replaced. The vehicle was not repaired. The contact stated that the vehicle was then towed to the residence where it remained. The manufacturer was notified of the failure and confirmed that the VIN was not included in a recall. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was approximately 103,000.