2016 FORD EXPLORER Complaints

The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The problem remedied by TSB 21B11-s2 did not occur in my vehicle while the TSB was in effect. It has now surfaced

The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

A-pillar trim flew off while driving. Obviously could've caused harm to other drivers. Ford has not notified me of when my vehicle will be repaired. Dealership offered to repair at cost to me.

The contact owns a 2016 Ford Explorer. The contact stated while driving at an undisclosed speed, the driver's side windshield trim detached and flew off the vehicle. The contact stated that due to the failure, there was a gap at the base of the windshield, allowing water to enter the engine compartment. Additionally, the contact stated that the passenger's side windshield trim was fractured. The dealer was made aware of the failure however, the contact was informed that the parts to perform the repair were not yet available. The contact received notification of NHTSA Campaign Number: 24V03100 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure and a case was filed. The failure mileage was 109,000. VIN tool confirms parts not available.

The contact owns a 2016 Ford Explorer. The contact stated that while the vehicle was parked, the keyless entry pad driver’s side B-pillar detached. The vehicle was taken to a dealer where it was determined that the driver’s side B-pillar needed to be replaced. The vehicle was repaired but the failure reoccurred after two years. The vehicle was taken to a dealer where it was determined that the driver’s side B-pillar needed to be replaced. The vehicle was not repaired. The vehicle was taken to the residence. The vehicle was repaired but the failure reoccurred a month later. The vehicle was taken to a dealer, and the contact was informed that the driver’s side B-pillar needed to be replaced again. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was unknown.

The recall has been in place for replacing an exterior A-pillar trim part - we have tried to get it replaced, but there are no parts nationally. Why haven't the parts been created? It has been over a year

At around 50,000 miles the Turbo on the engine was leaking oil. Dealer replaced the turbo and kept the part. It needed to be replaced to avoid a catastrophic failure of the turbo which in turn could cause severe engine oil loss resulting in engine failure and oil contamination of the catalytic converters O2 sensors and possibly a car fire. There was no warning but was caught during a routine oil change. Unknown if the dealer reported it.

There is a lot fuel- fumes/odor entering the cab of the vehicle when exceling the speed.