2016 FORD EXPLORER Complaints

The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 25V347000 (Structure); however, the part to do the recall repair was not yet available. The vehicle was taken to the dealer. The vehicle and the contact were informed that the B-pillar trim needed to be replaced. The dealer confirmed that parts were not yet available and that only half of the B-pillar trim could be replaced. The dealer stated that the remaining part needed to be provided by the manufacturer. The dealer informed the contact that parts might to available April of 2027. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure.

Transmission is company. Was driving and it bucked forward SO bad I had a panic attack with my kids in the back and had to have it towed home. Sounds like a computer issue because no me manic can figure out what’s wrong with it. Dealership had put in a ‘brand new’ transmission when I bought it in 2021.

After multiple communications with the local Ford Dealership, the recall on the vehicle has not been completed nor inspected. The Ford Dealership has repeatedly stated that they do not have the parts and cannot give an estimated time frame of arrival. The conversation always ends, "we will call when the parts come in". This has been over a year now. Today I called a different dealership in the area and received the same response. The Recalled Part on my vehicle is deteriorating, and it is only a matter of time before it detaches and causes damage or injury. Any help resolving this issue would be appreciated.

The contact owns a 2016 Ford Explorer. The contact stated that while driving 70 MPH, the driver’s side B-pillar trim detached from the vehicle and was dangling by two wires. The contact later used black duct tape to seal the trim in place. The dealer was notified of the failure and later informed the contact that parts for NHTSA Campaign Number: 24V031000 (Structure) were not available for the recall repair. Additionally, the contact stated that the front driver’s side A-pillar trim was rattling while driving at various speeds. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure. The failure mileage was approximately 106,000.

The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure). The contact stated that while driving 70 MPH on two occasions, the driver's side A-pillar trim flew off the vehicle into traffic. The vehicle was taken to the same dealer twice, where it was diagnosed, and it was determined that the A-pillar trim needed to be replaced. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 90,000.

The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

Hello. I purchased my car in 2018. 2-3 years later, the power steering would randomly go out while driving - on the highway and city roads. This could happen once and then not again for 6+ months. When this happened a message would display about a "steering assist fault, service now". I found that if I pulled over, turned the car off and then on, it would generally work again. We had the vehicle in to 3 separate repair shops between 10/2022 and 10/2025 and no one could diagnose the issue as they needed it to replicate the condition. (In hindsight find this strange (concerning!!) as a simple google search shows what I am describing is a very common issue with a number of Ford models and also other vehicles.) In June 2026, while on vacation with my family (on a mountain) it happened again. We turned the car on and off several time, disconnected/reconnected the battery and could not get the car to start working again and this time the steering wheel was completely locked. We had the vehicle towed and rented a car to drive home. The dealership was able to diagnose and repair the issue by replacing the entire steering rack assembly. No issues since then.

25V347 and 24V031 I recieved a notice of the first recall in February 2024. Over the Summer of 2024 and 2025 both the A-pillar and B-pillar trim has melted and become detached from the vehicle during high heat warnings and during my commute to work on the interstate 60 miles each day. Parts from the vehicle flew off at high rates of speed and were at risk to others on the road. For 2.5 years now I have driven a duct taped windshield on both drivers and on the passenger sides windows and on the tops of the door frames. The windshield rattles on the interstate--I feel this is dangerous. I have now recieved my 3rd factory recall: 25N17 Every day I drive this duct taped FORD, it is cemented in my mind that I will never purchase another Ford or Ford related product.

The contact called on behalf of his wife, who owns a 2016 Ford Explorer. The contact stated that while reversing at an undisclosed speed, the vehicle independently accelerated. The check engine warning light was illuminated. The contact researched online and was made aware of NHTSA Campaign Number: 25V164000 (Power Train); however, the VIN was not included. The vehicle was taken back to the residence. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 155,000.

The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that upon further inspection, the contact became aware that the front A-pillar trim sealants were deteriorating. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 130,000.