2018 FORD EXPLORER Complaints

The windshield trim will not stay on-I will have to take in for replacement. I have already read this was an ongoing issue and was being investigated so I wanted to get my report in as well. This should be a recall issue.

The contact owns a 2018 Ford Explorer. The contact stated that while his wife was driving approximately 70 MPH, the exterior rubber molding from the front passenger’s side windshield trim detached from the vehicle and struck a second vehicle. The contact stated that 3 of the 4 windshield trim panels had become loosened and were not properly secured to the vehicle. The cause of the failure was not yet determined. The manufacturer and local dealer were notified of the failure. The contact referenced the NHTSA Investigation: PE23001 and stated that the vehicle had experience the failure. The failure mileage was 55,000.

Around 4:45 , was unable to access cruise control the message rapidly flashed., loss of headlights and all lighting for a few seconds. Was going 70 mph. I exited the interstate to turn around and go to my work on southbound the wrench light came on and I lost power steering, power, acceleration in my turn on the on ramp and proceeded off the road onto the incline somehow avoiding a rollover and teetering sideways. Meanwhile no power to open my window etc. at an angle where I couldn’t open the door, took a minute to get out of the seatbelt. Suddenly got my window able to open and crawled out. The cops, and tow truck couldn’t believe I didn’t roll. The car was at a dealership the previous week for loss of power and terai. System problems/ no power steering and they replaced the throttle body 3 days before this happened. I’ve had multiple electrical/exhaust/power failures. I am terrified to drive this vehicle. It’s been to different dealerships and the ford ones and ford don’t care (only the dealership I purchased it at tries) it is at a fifth one now. We have forscan reports of the failures also. Multiple images at scene also. Car wouldn’t drive correctly and terrain management fault, unloaded itself from trailer too.

On a trip from South Carolina to New York, both A-pillar trims blew off on the highway. I am attributing this to both the fluctuations in temperature in the prior 12 hours (over 30 degrees) and a known issue with this vehicle. It was also very windy out.

I have had three incidents of total brake failure on this vehicle. First, about 3 months ago I could not stop while parking in my garage and hit a work bench. I chalked it up to just a weird low speed incident as the brakes worked fine the next time I drove it. Second, I was traveling on wet roads and 27 degree weather and could not stop for a yellow light. At the time I attributed it to an icey skid because, again, the brakes worked fine the next time I needed them. But in retrospect, I do not recall any feeling that the brakes were working. Lastly, today I rear ended a car in front of me when the brakes and the supposed forward collision system both failed dramatically. I was probably going 25 MPH coming to a red light and started to apply my brakes several hundred feet before the intersection. Nothing happened and I, panicked, began pumping the pedal relentlessly. Finally the dashboard crash warning light started flashing and still no drop in speed. I tried to get into low gear, but by that time it was too late and I crashed into a van in front of me. It totaled my car and pretty well wiped out the rear doors and windows of the van. Fortunately, no one was injured. I was not cited because an EMT nurse was in the lane beside me and witnessed my brake pumping, steering wheel grabbing actions and could tell what was going on. The police are going to investigate the brake problem as well as my insurance company, USAA. There have been no brake recalls issued for my vehicle and any other recalls are up to date. There are approximately 50000 miles on it and it has had meticulous care and regular maintenance and brake shoes are still listed as good condition on my last visit for an oil change.

The contact owns a 2018 Ford Explorer. The contact stated that while driving at an undisclosed speed, the infotainment screen was inoperable. No warning lights were illuminated. The vehicle was taken to a local dealer, where it was diagnosed that the application programming interface module (APIM) needed to be replaced; however, the part for the repair was on backorder. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 89,000.

The passenger side front windshield A pillar outer trim flew off the car when we were driving on CA freeway 15 on Saturday, February 25, 2023. The entire molding flew off and we don’t know if it hit any cars behind us since we were going at least 70 mph.

I have a 2018 Ford Explorer. My SYNC 3 is showing a black screen due to a failed APIM. I do not have my rear camera, GPS, or hands-free capability which impedes driving safely. Ford has recalled multiple other years of my vehicle for this same reason, but not the 2018. Ford has also extended it's warranty up to 7 years/100,000 miles on some years of my vehicle, for the same reason, but not the 2018. I am reading that there are numerous other owners who a have the same problem with only an expensive resolution. The Ford dealer confirmed the need to replace the APIM today at a cost of $1,417. This is unacceptable due to the safety factor and that they know this is a problem in their vehicles. I reported it to Ford and their response was my warranty is expired and there is no recall, so I have to pay.

The contact owns a 2018 Ford Explorer. The contact stated the rearview camera screen was blue and inoperable. The contact stated the “Camera not Available” warning light was illuminated. The contact took the vehicle to the local dealer, where it was diagnosed with needing the rearview camera to be replaced. The vehicle was not repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 40,000.

The contact owns a 2018 Ford Explorer. The contact stated while driving at approximately 60 MPH, the driver’s side roof rail suddenly detached from the roof of the vehicle. The cause of the failure was not yet determined, and the vehicle was not yet repaired. The manufacturer was not notified of the failure and informed the contact that the VIN was not included in the NHTSA Campaign Number: 21V316000 (Structure). The contact stated that the vehicle had experienced the failure listed in the recall. The local dealer was not contacted. The failure mileage was 81,000.