2016 FORD EXPLORER Complaints

The contact owns a 2016 Ford Explorer. The contact stated while driving at an undisclosed speed, the front passenger's side windshield trim detached and flew off. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure and a case was filed. The failure mileage was 65,000. VIN tool confirms parts not available.

The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated while driving approximately 50 MPH, the driver’s side A-pillar trim detached, and the front passenger’s side A-pillar trim became loosened. The contact was not able to retrieve the driver’s side A-pillar trim. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 50,000.

Randomly whilst driving, my dash had multiple error messages pop up and my power steering went out completely. The error messages were as follows: Service AdvanceTrac, Terrain Management System Fault, Hill Start Assist Not Available, & Power Steering Assit Fault. This keeps happening intermittently, while I am driving. This causes a serious safety issue, for my steering wheel to lock up while I am driving! I did get the codes for the errors and they are as follows: U0420-41, C0051-67, U0151-00, U0131-00. My ABS system failed check, as well. This is a known issue with Ford vehicles, as there have already been recalls for previous models. According to [XXX]: "Ford has recalled earlier model year Explorers with power steering problems before. In 2014, Ford recalled certain model year 2011-2013 Ford Explorers, saying these vehicles “may experience an intermittent connection in the electric power steering gear, which can cause a loss of the motor position sensor signal resulting a shut down of the power steering assist.” According to Ford, this issue “may increase the risk of a accident.” In 2015, Ford recalled certain model year Ford Fusion, Ford Taurus, Ford Flex, Mercury Milan, Lincoln MKS, Lincoln MKT, and Lincoln MKZ vehicles. According to Ford, these vehicles had “electric power steering assist systems that may shut down as a result of a steering motor sensor fault.” As a result, “[i]f the vehicle experiences a loss of power steering assist, extra steering effort will be required at lower speeds, increasing the risk of a vehicle crash”. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Power steering started to make creaking sounds when turning the steering wheel right or left. Speed not a factor. I was concerned that something might be seriously wrong so took to local mechanic. Need to replace the rack and pinion steering gear. Took a week to get the parts. Cost 2500.00 to fix. Now it needs to go back for a redo cause there are issues with the electronics. Must wait another week for replacement parts. Must redo rack and pinion and recalibrate computer. Ford has to do it as local mechanics don’t have the the proper calibration computer. Platinum version. Just shy of 52,000 miles.This should be on fords recall list.

I recently went to a mechanic sho0 to have a wheel alignment done because my steering wheel is about 50% tilted to the left. The shop told me they were unable to align the vehicle because there was a problem with my toelinks in the back of my car preventing the wheel from being straight. I called Ford to see if there was anything they could do because I got my toelinks done when there was a recall back in 2019. I have since had issues with my steering wheel not being lined and thought it was just out of balance. I would like for the toelinks to be looked at once again because apparently there is an issue with them.

The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact stated while driving approximately 35 MPH, the trim A Pillar on the driver’s side was loose and flapping in the slip stream. The contact stopped the vehicle on the side of the road and used tape to secure the trim. The failure mileage was approximately 76,000. VIN tool confirms parts not available.

Rack & Pinion Went out while driving . Ford dealer said it’s on back order a lot of vehicles have done it . Had complete steering loss in the mist of driving down road. It’s electrical .

The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that there was water leaking into the cabin of the vehicle whenever in rained from the sunroof, causing an electrical short circuit. The dealer was contacted. The manufacturer was not made aware of the issue. The failure mileage was 151,455. VIN tool confirms parts not available.

The contact owns a 2016 Ford Explorer. The contact stated that the vehicle was experiencing significantly rough idling while in drive(D) or while in reverse(R). Additionally, the contact stated that while accelerating from a complete stop, the vehicle jolted and hesitated to respond. The contact also stated that the vehicle shuddered while driving at various speeds. There was no warning light illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the failure was related to TSB Number: 20-2271. The dealer was notified of the failure. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the TSB was superseded and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 102,000.

The contact owns a 2016 Ford Explorer. The contact stated while driving at an undisclosed speed, the A-pillar trim on both sides of the windshield started to detach. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted, and the dealer stated that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and the failure. The failure mileage was approximately 45,000. VIN tool confirms parts not available.