2016 FORD EXPLORER Complaints

The torque converter failed in my explorer while driving, making it act like it was in neutral. Luckily I was on a small road with little traffic, and able to pull over to a side street before my car was complete undrivable. If this happened on the highway or while turning, it probably would have cause a major issue or accident. NO warning lights on my dash and NO problem codes reported on OBD scanner tool. Ford has put out their own CSP for this issue a while ago and when I asked about it they told me it was expired. How can something they know is an issue expire? Dealership repair confirmed it was the torque converter and has to rebuild the transmission. I even found a service bulletin ford release about this problem, so they know about it.

Vehicle was purchased from carmax, there is a crack on the trim ar the d-pillar around the window on the driver side and passenger side. My wife bought a 2014 Ford Explorer about a week prior to mine from the same place and there is a crack in the same exact spot on the driver and passenger side. Causes water to leak into the interior of the vehicle. In the summer months it's causes a musty smell with the potential for mold to develop.

The contact owns a 2016 Ford Explorer. The contact stated that while driving at an undisclosed speed, the steering wheel made abnormal grinding sounds. No warning light was illuminated. The vehicle was taken to the dealer, where it was determined that the rack and pinion needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 132,400.

The contact owns a 2016 Ford Explorer. The contact stated that the passenger's side windshield exterior A-pillar trim had separated and flown off the vehicle. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was unknown. VIN tool confirms parts not available.

The contact owns a 2016 Ford Explorer. The contact stated while at a red light, the vehicle was shaking abnormally. No warning light was illuminated. The vehicle was drivable and was driven to a dealer. The dealer replaced the motor mounts and informed the contact that the torque converter and transmission needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The manufacturer was notified of the failure and informed the contact that the VIN was not under recall for the failure. No further assistance was provided. The contact was referred to the NHTSA Hotline to report the failure. The failure mileage was approximately 97,393.

The water pump failed on my way home from work. A light in my vehicle started blinking rapidly and a warning alarm started sounding in the vehicle cabin unexpectedly. My vehicle suddenly overheated in the middle of a busy intersection causing me to stop unexpectedly to assess the situation before proceeding to safety. I (middle aged female) had returned from a long trip with two toddlers 800 miles round trip which extended late into the night on remote stretches of road without assistance available for several miles only a few days earlier. Had this happened a few days earlier, during that trip, I would have been stranded with two toddlers, alone after dark in a remote location. An independent service center made the diagnosis and performed a repair. They stated I was lucky the leak did not enter my oil reservoir based on the location of the water pump, locking up the engine and leaving the car completely inoperable in said intersection. The location of the water pump, and the fact it failed around 100,0000 miles seemed premature for similiar vehicles and the design/placement of the water pump is significantly more difficult to troubleshoot and repair. The cost of the repair was ultimately $3825.69 plus an additional cost to procure a rental vehicle while for the week my vehicle was being repaired.

The contact owns a 2016 Ford Explorer. The contact stated while driving 60 MPH, the steering wheel was difficult to operate. The contact stated that the Hill Start Assist Not Available, The Terrain Management System Fault, and Service Advance-trac message was displayed on the instrument panel. The Traction Control and TPMS warning lights were illuminated. The vehicle was not drivable. The vehicle was towed to an independent mechanic; however, the vehicle was not diagnosed or repaired. The contact stated that the independent mechanic replaced the rack and pinion. The vehicle was repaired; however, the failure reoccurred. The manufacturer was not notified of the failure. The failure mileage was 160,000.

The contact owns a 2016 Ford Explorer. The contact stated while driving at an undisclosed speed, the vehicle lost motive power and was not able to exceed 50 MPH. The contact stated that the check engine warning light had been illuminated for over 3 years. t uThe vehicle was taken to a dealer to be diagnosed and the contact was informed the engine needed to be replaced due to the rear turbo causing damages to the front turbo and the engine. The vehicle was not repaired. The vehicle was then taken to an independent mechanic where it was determined that the turbos needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure; however; the contact was informed that the vehicle was nonder recall and that the vehicle was out of warranty. The failure mileage was approximately 97,000.

Steering was acting funny, return of the steering wheel to the straight position was becoming difficult. Electronic rack and pinion system then failed while driving. Luckily the issue occurred while in my driveway. Entire system was then replaced for roughly $2500.

While driving vehicle down the road, steering locked up. Vehicle was taken to the dealer and diagnosed as a bad rack and pinion. This vehicle has 84,000 miles and should not already have issues with the rack and pinion. This incident, could have put my family and many other people's lives/vehicles at risk.