1999 FORD EXPLORER Complaints

TL* THE CONTACT OWNS A 1999 FORD EXPLORER. THE CONTACT STATED THAT THE VEHICLE CAUGHT ON FIRE WHILE IN THE CONTACT'S DRIVEWAY WITH THE ENGINE TURNED OFF. THE FIRE DEPARTMENT WAS CALLED AND ADVISED THAT THE FIRE ORIGINATED FROM THE BATTERY COMPARTMENT. A FIRE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. NEITHER THE DEALER NOR THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE AND THE CURRENT MILEAGE WAS 212,000.

FRONT WINDSHIELD WIPER FAILURE:FRONT WINDSHIELD WIPERS FAIL TO WORK CONSISTENTLY. WIPERS COME ON EVEN THOUGH IT IS SET TO THE OFF POSITION. SOMETIMES WIPERS DO NOT COME ON WHEN THEY ARE TURNED TO THE ON POSITION. IN ORDER FOR WIPERS TO WORK CONSISTENTLY THEY WOULD HAVE TO BE MANUALLY ENGAGE WITH HAND AND HAND HAS TO BE KEPT ON THE WIPER CONTROL SWITCH SWITCHING IT ON AND OFF TO MOVE THE WIPER BLADES. WIPERS WOULD COME ON INTERMITTENTLY WHILE DRIVING. WIPERS WOULD ACT ERRATICALLY AND FAIL TO OPERATE PROPERLY 90% OF THE TIME. WIPERS SOMETIMES WOULD COME ON AFTER VEHICLE HAS WARMED UP. WIPERS CAN COME ON ANYTIME WHILE DRIVING. FAULTY HOOD/WEAK HYDRAULIC ARMS: THE HOOD CANNOT SAFELY STAY UP BECAUSE THE HYDRAULIC ARM SUPPORTS ARE TOO WEAK TO HOLD THE WEIGHT OF THE HOOD. THE HOOD SUPPORT DOES NOT LOCK INTO PLACE SO THAT THE HOOD WOULD STAY UP SAFELY. NO SAFETY BAR WAS INSTALLED ON THIS VEHICLE TO SAFELY HOLD UP/PROP UP THE HOOD IN CASE OF HYDRAULIC ARM/SUPPORT FAILURE. IF THE VEHICLE GETS BUMPED WHILE THE HOOD IS UP THE HOOD WOULD FALL AND CLOSE SHUT. BECAUSE THE HOOD WILL NOT STAY UP IT REQUIRES TWO PEOPLE WHEN CHECKING UNDER THE HOOD. ONE PERSON TO HOLD THE HOOD WHILE OTHER IS UNDER IT. EXTREME RUST & RUST THROUGH INTERIOR RUNNING BOARDS/STEP UP: BOTH DRIVER AND PASSENGER SIDE INTERIOR RUNNING BOARDS/STEP UP HAVE EXTREME RUST AND RUSTED HOLES THROUGH THE FRAME IN MANY SPOTS.WHEN THE DRIVER OR PASSENGER SIDE DOORS ARE OPEN ALL RUST CAN BE SEEN.SOME RUST AND RUSTED HOLES THROUGH THE FRAME IN MANY SPOTS IS VISIBLE FROM THE EXTERIOR EVEN WHEN DRIVER OR PASSENGER SIDE DOORS ARE CLOSED. *TR

TL* THE CONTACT OWNS A 1999 FORD EXPLORER SPORT. THE CONTACT WAS DRIVING APPROXIMATELY 35 MPH IN RAINY WEATHER CONDITIONS AND THE WINDSHIELD WIPERS FAILED TO OPERATE DURING ACTIVATION. THE WINDSHIELD WIPERS WOULD OPERATE WHENEVER THE WINDSHIELD WASHER CONTROL DEVICE WAS ENGAGED. ALSO, THE WINDSHIELD WIPERS OPERATED WHEN MANUALLY TURNING THE CONTROL LEVER. ON NUMEROUS OCCASIONS, THE WINDSHIELD WIPERS ACTIVATED WHILE IN THE OFF MODE. IN ADDITION, THE HOOD SUPPORT ARM WOULD NOT REMAIN IN AN UPWARD POSITION. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 76,500. UPDATED 02/22/12*LJ THE CONSUMER STATED THE WIPERS WOULD ACTIVATE, WHEN THE DEFROSTER WAS ON. UPDATED 03/01/12

I HAVE A 1999 FOR EXPLORER SPORT (2 DOOR) AND IN FEBRUARY OF 2011 THE DOOR ON THE PASSENGER SIDE LOCKED AND AS NOT BEEN ABLE TO BE OPEN SINCE THEN. I CALLED FORD MOTOR COMPANY ABOUT IT, THINKING THAT IT WOULD BE A SAFETY CONCERN IF IN A WRECK AND A PASSENGER COULD OPEN THE PASSENGER DOOR. WAS TOLD NOT A SAFETY CONCERN AND TO GET IT FIX I WOULD HAVE TO PAY FOR IT. I DON'T UNDERSTAND HOW A COMPANY CAN THINK THAT A DOOR ON A VEHICLE NOT OPENING IS NOT A SAFETY CONCERN. *TR

TL* THE CONTACT OWNS A 1999 FORD EXPLORER. THE CONTACT STATED THAT THE WINDSHIELD WIPERS WOULD SPORADICALLY OPERATE WITHOUT ACTIVATION AND WHEN ACTIVATED, WOULD NOT OPERATE AT ALL. THE FAILURE PROGRESSED UNTIL THE WIPERS WERE COMPLETELY INOPERABLE. THE CONTACT'S PERSONAL MECHANIC INSPECTED VEHICLE AND ADVISED THAT THE CLOCK SPRING HAD FAILED AND WAS CAUSING THE PROBLEM. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE AND CURRENT MILEAGE WAS UNKNOWN.

ACCELERATOR PEDAL BRACKET FALLS RIGHT OFF OF FIREWALL WHICH THEN THE VEHICLE LOOSES ALL ACCELERATION CAPABILITIES. ONLY THREE SPOT WELDS HOLD THIS BRACKET ONTO THE FIREWALL. THE SPOT WELDS SEEM INSUFFICIENT TO HOLD THE BRACKET ONTO THE FIREWALL. SOME WELDER EXPERTS STATE ON AUTO FORUMS THAT THE SPOT WELDS ARE NON-CONFORMING REGARDING THE REQUIRED DIAMETER OF A GOOD WELD. *TR

TL*THE CONTACT OWNS A 1999 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 30 MPH THE CONTACT ATTEMPTED TO ACTIVATE THE WINDSHIELD WIPER BUT IT WOULD NOT FUNCTION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE MECHANIC STATED THE GENERIC ELECTRONIC MODULE NEEDED TO BE REPLACED. THE INDEPENDENT MECHANIC ADVISED OF A RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 00V072000 (ELECTRICAL SYSTEM: FUSES AND CIRCUIT BREAKERS). THE DEALER WAS NOTIFIED AND STATED THE VEHICLE WAS NOT INCLUDED IN THE RECALL AND COULD NOT FIND ANY FURTHER INFORMATION ABOUT THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 220,000.

TL*THE CONTACT OWNS A 1999 FORD EXPLORER. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 35 MPH THE WINDSHIELD WIPERS BEGAN TO OPERATE INVOLUNTARILY TWO OR THREE TIMES. DURING THE FAILURES, SMOKE WOULD BEGIN TO RISE FROM THE TOP OF THE STEERING COLUMN. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE DEALER WOULD ONLY DIAGNOSE THE FAILURE AT THE OWNER'S EXPENSE. THE FAILURE WAS NOT DIAGNOSED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 150,000.

TL* THE CONTACT OWNS A 1999 FORD EXPLORER. THE CONTACT STATED THAT THE DRIVERS SIDE SEAT WOULD NOT STAY IN THE UPRIGHT POSITION. THE VEHICLE WAS INSPECTED BY AN INDEPENDENT MECHANIC AND THEY ADVISED HIM THAT THE BOLTING OF THE SEAT FAILED DUE TO THE WEIGHT CAPACITY. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS ALSO CONTACTED AND THEY OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 70,000.

TL* THE CONTACT OWNS A 1999 FORD EXPLORER. THE CONTACT STATED THAT THERE WAS LITTLE SUPPORT FOR THE DRIVER SIDE SEAT BACK AND WHILE DRIVING 35 MPH, THE SEAT FRACTURED. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 03V281000 (SEATS:FRONT ASSEMBLY:RECLINE) AND THE VEHICLE WAS TAKEN TO THE DEALER FOR REPAIRS HOWEVER, THE CONTACTS VEHICLE WAS NOT INCLUDED IN THE RECALL. THE MANUFACTURER WAS CONTACTED WHO CONFIRMED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL AND OFFERED NO FURTHER ASSISTANCE. THE FAILURE MILEAGE WAS 30,000.