1994 FORD EXPLORER Complaints

THE SHOCKS THAT HOLD THE TAILGATE UP HAVE FAILED AND BROKEN AWAY FROM THERE WELDS. I HAVE CONTACTED FORD AND THEY INFORMED US OF A RECALL THAT HAD STARTED AND ENDED IN 96. I CANT BELIEVE HOW FORD IS HANDELING THIS. I HAVE READ OTHER COMPLAINTS OF THE SAME NATURE ON THIS WEB SITE AND IT IS OBVIOUS THAT THIS IS A DESIGN FLAW. FORD CANT ISSUE A RECALL ON SOMETHING THAT HAS TO BROKE WHEN THE RECALL IS ISSUED KNOWING THAT AT SOME POINT IT IS GOING TO BREAK BUT WE ARENT GOING TO FIX IT. THIS IS OFFENSIVE TO ME BECOUSE THE EXPLORER HAS MULTIPLE MECHANICAL PROBLEMS BUT I WRITE THOSE OFF TO WEAR AND TEAR. THE TAILGATE SHOULD NOT FAIL. FORD SHOULD BE OBLIGATED TO FIX THIS PROBLEM ON WHATEVER YEAR THE VEHICLE MAY BE. I AM GOIN TO CONTINUE INVESTIGATING AND FIND SOME WAY TO GET THEM TO FIX IT. I WOULD JUST LIKE TO KNOW IF MAYBE YOU HAVE ALREADY SOLVED THE NEGOTIATING PROBLEM. IN MY MANUAL THERE IS A WARRANTY THAT SAYS ITS AGAINST ANY SHEETMETAL DETERIORATION FOR 6 YRS OR 100,000 MILES I WONDER IF THIS APPLIES IN MY SITUATION. I SURE HOPE THAT YOU ALL CAN HELP ME OUT OR LET ME KNOW WHAT IS HAPPENING WITH THIS PROBLEM. THANX

WHEN RAISING THE HATCHBACK THE TAILGATE LIFTER BROKE WHILE THE CONSUMER WAS PUTTING A SUITCASE IN THE VEHICLE AND THE BRACKET BROKE. THE SPOT WELD ON THE LEFT BRACKET HAD BROKEN LOOSE AND THE LIFT STRUT WAS JAMMING AGAINST THE TOP OF THE GATE. CONSUMER CONTACTED THE DEALER AND FOUND THAT THERE HAD BEEN A RECALL FOR THE LIFTGATE, BUT THEY ARE REFUSING TO SERVICE THE VEHICLE BECAUSE IT HAS OVER 60,000 MILES. *AK *ML

CONSUMER DROVE APPROXIMATELY 20 MINUTES BEFORE TURNING THE DEFROSTER ON, WITHIN 15 SECONDS HE BEGAN TO SMELL BURNING ODOR, SMELL LIKE LEAVES. CONSUMER SWITCHED THE ENGINE OFF AND SAT AND WATCHED, NEVER SAW ANY SMOKE. WHEN THE SMELL GOT DOWN APPROXIMATELY FIVE MINUTES LATER HE BEGAN TO DRIVE AGAIN, THERE IS AN OPEN INVESTIGATION AT THIS TIME. *AK

LEAVES ACCUMULATED IN HEATER BLOWER ASSEMBLY. APRIL 1994 WE PAID $92 TO HAVE LEAVES REMOVED FROM SYSTEM AFTER WE SMELLED BURNING LEAVES AND BLOWER MOTOR WAS NOISY. IN NOVEMBER 1996 WE PAID $52 TO HAVE BLOWER MOTOR RESISTOR REPLACED AFTER IT BURNED UP, FILLING CAR WITH SMOKE BUT NO FLAMES OBSERVED. WE CURRENTLY SMELL LEAVES BURNING EVERY TIME WE DRIVE THE CAR WITH HEATER ON SO EXPECT MORE PROBLEMS SOON.

WHILE DRIVING APPROXIMATELY 30 MPH, NOTICED A VEHICLE IN FRONT OF HIM WITH BRAKE LIGHTS ON. CONSUMER PUT HIS FOOT ON THE BRAKE PEDAL WHICH WENT ALL THE WAY DOWN TO THE FLOOR. VEHICLE DID NOT STOP. CONSUMER REAR ENDED ANOTHER VEHICLE. DEALER HAS BEEN NOTIFIED. *AK

LUGS: NUTS:BOLTS SHEARED OFF, CAUSING FRONT WHEEL TO SEPARATE AT 55-60MPH; HEARD A NOISE, LIKE CRUNCHING, PRIOR TO SEPARATION. SAW WHEEL ROLLING. VEHICLE COLLAPSED. BRAKED TO STOP VEHICLE. TOWED TO MECHANIC. INSURANCE ADJUSTER WILL BE CHECKING VEHICLE. *AK

WHILE DRIVING ON INTERSTATE AT 70 MPH, NUMEROUS TIMES ENGINE WOULF QUIT RUNNING AND VEHICLE STALLED. DEALER REPLACED FUEL PUMP RELAY SWITCH, AND VEHICLE WORKS FINE.

TRANSMISSION STOPPED OPERATING WHILE DRIVING. VEHICLE WAS TAKEN TO DEALER SHOP AND REPAIR WAS MADE,COST WENT TO THE CONSUMER. *AK ENGINE LIGHT COMES ON AND OFF. *YD

WHEN APPLYING THE ABS BRAKES ON DRY PAVEMENT THE PEDAL TRAVELED TO THE FLOOR ,CAUSING EXTENDED STOPPING DISTANCE, RESULTING IN A COLLISION. *AK

THE HYDRAULIC CYLINDER SEPARATED FROM THE REAR DOOR JUST AS THE OWNER WAS LIFTING THE DOOR OVERHEAD. THE DOOR CAME DOWN QUICKLY ON HER BACK, CAUSING SOME PAIN AND INJURY.