1994 FORD EXPLORER Complaints

PURCHASED VEHICLE TRANSMISSION OUT,CAME WITH REBUILT TRANSMISSION,INSTALLED,LASTED ABOUT 1 YEAR.KEPT BLOWING FRONT SEALS.ALWAYS HEATED UP GOING UPHILL.NEXT TRANSMISSION,SAME STORY.SERVICED REGULAR,WITH FILTER CHANGE.CURRENT TRANSMISSION IN TRANS. SHOP,BURNT UP,NEW CLUTCHES,BANDS,SEALS,YOU NAME IT.IT STILL WILL NOT SHIFT CORRECTY DUE TO SERVO PISTON FAILURE,THAT ALSO NEEDS FIXED.A4LD TRANSMISSION IN TOO SMALL FOR THE EXPLORER VEHICLE.I LIKE THE VEHICLE IN GENERAL,EVEN INSTALLED MANUAL LOCKOUTS TO HELP THIS SIDUATION.THIS VEHICLE HAS HAD GOOD CARE,BUT TO NO AVAIL.I BELIEVE THAT THE FORD MOTOR COMPANY SHOULD BE HELD ACCOUNTABLE FOR PRESENTING THE AMERICAN CONSUMER WITH SUCH BAD DRIVETRAIN SIDUATIION,THAT I AM SURE THAT THEY BOTH KNEW ABOUT,AND JUST DID NOT CARE.IT LEFT ME,A SERVICE CONNECTED DISABLED VETERAN,ON THE SHOULDER OF THE HIGHWAY,MANY TIMES.EVEN ON MY WAY TO THE VA HOSPITAL.REGUARDS

HIGH BEAMS ACT AS LOW BEAMS ALL THE TIME, UNLESS YOU PULL THE BRIGHTS TOWARDS YOU AND HOLD WHICH IS ALSO A FATALITY. *TR

TL* THE CONTACT OWNS A 1994 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50 MPH, AN ODOR OF GASOLINE FUMES EMITTED INSIDE OF THE VEHICLE AND THE ENGINE WARNING LIGHT ILLUMINATED. IN ADDITION, THERE WAS SMOKE COMING FROM UNDER THE HOOD. THE CONTACT EXPERIENCED BRONCHIAL HEALTH ISSUES THAT REQUIRED MEDICAL ATTENTION AS A RESULT FROM INHALING THE FUMES. THE VEHICLE WAS TAKEN TO A DEALER, WHO DIAGNOSED THAT THE FUEL LINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 190,000. THE VIN WAS UNAVAILABLE.

APRIL, 1996 I, MY EX WIFE, AND MY DAUGHTER WERE COMING BACK FROM PALMDALE, LA COUNTY, TRAVELING EAST ON 138 HIGHWAY BACK TO ONTARIO, SAN BERNARDINO COUNTY, WHERE I USED TO RESIDE. WHILE I WAS PASSING SLOW TRUCK IN TWO HIGHWAY TRYING TO GET BACK IN THE FRONT OF THE TRUCK ONE OF THE FRONT TIRES EXPLODED I LOST CONTROL OF THE 1994 FORD EXPLORER GOT ON THE DIRT THE CAR WAS AIRBORNE LANDED TURN GOD KNOWS HOW MANY TIMES AND LANDED ON THE SIDE. *TR

MY TENANT'S VEHICLE - A 1994 FORD EXPLORER - SPONTANEOUSLY CAUGHT FIRE WHILE PARKED IN MY PROPERTY'S GARAGE IN THE MIDDLE OF THE NIGHT. THE FIRE DEPARTMENT WAS ABLE TO EXTINGUISH THE FLAMES AND DETERMINED THAT THE CAUSE OF THE FIRE WAS THE CAR ITSELF - LIKELY A FAULTY CRUISE CONTROL VALVE ACCORDING TO THEM. THE INSURANCE COMPANY WILL CONDUCT ITS OWN INVESTIGATION. *TR

I WAS SITTING AT A STOP LIGHT ALL OF A SUDDEN THE TRUCK ACCELERATED FORWARD. THE NEXT EVENT I WAS TRAVELING ABOUT 40 MILES AN HOUR AND THE TRUCK ACCELERATED OUT OF CONTROL AND I WAS UNABLE TO STOP IT, THE BRAKES WOULDN'T STOP IT, FINALLY I TURNED THE KEY OFF AND IT SHUT DOWN. IT'S BEEN HAPPENING ON AND OFF SINCE THEN. IT DOESN'T HAPPEN ALL THE TIME, BUT, I NEVER KNOW WHEN IT WILL HAPPEN AGAIN. I CONTACTED FORD SEVERAL TIMES ABOUT THIS PROBLEM AND THEY TOLD ME IT COULD BE ALOT OF DIFFERENT REASONS, THEY NAMED OFF SOME PARTS AND I REPLACED ALOT OF THEM AND AM STILL HAVING THE SAME PROBLEM. THEY DID SAY THEY HAVE HEARD OF OTHER PEOPLE HAVING THE SAME PROBLEMS, BUT THEY WERE NOT ALL FOR THE SAME REASONS. *TR

INVESTIGATION OF A MOTOR VEHICLE TRAFFIC COLLISION REVEALED THAT THE ACCELERATOR PEDAL ON 1994 FORD EXPLORER (UNKNOWN MILES) MAY BECOME STUCK IN THE "FULL OPEN THROTTLE" POSITION. CONDITION OCCURS WHEN THE ACCELERATOR PEDAL ARM WEARS A SLIT IN THE RUBBER SOUND/HEAT INSLUATION ON THE FLOOR BOARD. AFTER THAT OCCURS, WHEN THE ACCELERATOR IS FULLY DEPRESSED, THE ARM CAN BECOME STUCK IN THE RUBBER. CONDITION WAS DISCOVERED DURING INVESTIGATION OF A FATAL CRASH. AFTER THE CONDITION WAS DISCOVERED, IT COULD BE EASILY AND REPEATEDLY REPLICATED. NOTE: FATALITY OCCURRED WHEN THE DRIVER, FOR UNKNOWN REASONS, EXITED THE VEHICLE WHILE IT WAS STILL IN MOTION AT UNKNOWN SPEED. DRIVER DIED UPON IMPACT WITH ROAD. VEHICLE CONTINUED OFF ROAD AND CAME TO REST, MOSTLY UNDAMAGED, IN A FIELD WELL OFF ROAD SURFACE. *TT

WHILE DRIVING I TURNED ON AIR CONDITIONER AND IMMEDIATELY LIGHT SMOKE BEGAN OUT OF AIR CONDITIONING VENTS AND THEN THE NEXT MOMENT THE SMOKE WAS EXTREMELY HEAVY OUT OF THE VENTS AND THEN VISIBLE FIRE UNDERNEATH FRONT PASSENGER SIDE DASHBOARD. I IMMEDIATELY PULLED THE VEHICLE OFF THE SIDE OF THE ROAD AND EXITED, 10 MINUTES LATER IT WAS FULLY ENGULFED IN FLAMES. *LN

1994 FORD EXPLORER HAD SMOKE COMING OUT OF THE AIR-CONDITIONER VENTS INTO THE PASSENGER COMPARTMENT, SLIGHT AT FIRST, THEN SO HEAVY THAT FORWARD VISIBILITY WAS OBSCURED. AFTER STOPPING THE VEHICLE, A SMALL FIRE WAS SEEN BURNING THE PLASTIC EVAPORATOR COVER WHERE THE BLOWER MOTOR RESISTOR ASSEMBLY IS MOUNTED IN THE EVAPORATOR COVER. SOME SNOW THROWN ON THE FIRE PUT IT OUT. THE BLOWER MOTOR APPEARS TO BE SHORTED OR MAYBE JAMMED FROM ROTATING, CAUSING THE RESISTOR TO GET HOTTER THAN NORMAL, IGNITING THE PLASTIC COVER. MAYBE LEAVES OR OTHER FLAMMABLE DEBRIS CONTACTED THE RESISTOR, BUT I CAN'T TELL AS THE FLAMES BURNED UP ANYTHING IN THE AREA AROUND THE RESISTOR ASSEMBLY. FORTUNATELY, I WAS ABLE TO BRING THE VEHICLE TO A SAFE STOP, IN SPITE OF VERY LIMITED VISIBILITY IN THE HEAVY SMOKE. I WAS ON A SLOW SPEED, LOW TRAFFIC CITY STREET. THE RESULTS WOULD HAVE BEEN MUCH WORSE IF THE FIRE OCCURRED AT HIGHWAY SPEEDS. THE BLOWER MOTOR WILL BE AVAILABLE FOR INSPECTION WHEN I REMOVE AND REPLACE IT TO TRY AND GET THE AIR SYSTEM WORKING FOR HEAT AT LEAST. *TR

LIGHT CONTROL SWITCH HEATS UP SO HOT THAT WIRES AND PLUG IN MELT,BURN AND CRACK CAUSING LIGHT SWITCH FAILURE THAT COULD GO UNKNOWN CAUSING A CRASH OR FIRE. *TR