2014 FORD EXPLORER Complaints

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. WHILE DRIVING 35 MPH, THE STEERING WHEEL SEIZED WITHOUT WARNING. THE CONTACT MANAGED TO DRIVE HOME AT LOW SPEEDS. THE VEHICLE WAS TURNED OFF AND RESTARTED, BUT IT DID NOT RETURN TO NORMAL. DAVE SMITH FORD, LLC (4045 TRANSIT RD, WILLIAMSVILLE, NY 14221, (716) 634-2000) WAS CONTACTED AND STATED THAT THE VIN WAS NOT INCLUDED IN A RECALL. THE CONTACT WAS INFORMED TO BRING THE VEHICLE IN FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED AND THE FAILURE RECURRED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 14V286000(STEERING). THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 70,000.

THE WATER PUMP IN MY 2014 FORD EXPLORER 3.5L V6 ENGINE BEGAN LEAKING COOLANT. THE WATER PUMP HAD TO BE REPLACED AT 79,000 MILES. I BECAME AWARE OF THIS PROBLEM AFTER GETTING AN OIL CHANGE. THE COOLANT RESERVOIR HAD TO BE FILLED AND I WAS INFORMED OF A POSSIBLE COOLANT LEAK. TWO WEEKS AFTER GETTING THE COOLANT FILLED, MY RADIATOR FAN BEGAN RUNNING FAST AND LOUD. I BROUGHT IT INTO THE SHOP AND WAS TOLD I HAD A LEAKING WATER PUMP. THERE WAS ONLY ONE INCH LEFT OF COOLANT IN THE RESERVOIR AFTER JUST BEING FILLED UP. I WAS THEN TOLD IT WOULD TAKE 14-16 HOURS OF LABOR TO REPLACE THE WATER PUMP WHICH ITSELF COSTS LESS THAN $150. I WAS REFERRED BY THE SHOP TO THE DEALERSHIP BECAUSE THE WORK NEEDED WAS EXTENSIVE AND BECAUSE IT INVOLVED A FORD PART. THE DEALERSHIP REFUSED TO PAY FOR THE REPAIRS AND REFERRED ME TO FORD. THE DEALERSHIP CONFIRMED THE WATER PUMP LEAK. BASICALLY, THE ENGINE HAD TO BE TAKEN APART TO REPLACE THE WATER PUMP, BECAUSE THE PUMP IS MADE PART OF THE ENGINE ITSELF. I BELIEVE THE FORD ENGINE AND THE WATER PUMP IS DEFECTIVE. THE GASKETS OR BEARINGS IN THE WATER PUMP FAIL AND THERE ARE WEEP HOLES IN THE WATER PUMP WHICH ALLOW COOLANT TO LEAK INTO THE ENGINE AND MIX WITH THE ENGINE OIL. MY VEHICLE WAS OUT OF THE MANUFACTURER'S WARRANTY. I SPENT $1,839.82 TO FIX A SINGLE WATER PUMP! THERE SHOULD BE AN INVESTIGATION INTO THIS MANUFACTURING AND DESIGN DEFECT DUE TO THE BURDEN IT PLACES ON THE PUBLIC. THERE ARE ALSO SAFETY ISSUES CAUSED BY THIS DUE TO VEHICLES BEING SO AFFECTED BY THE COOLANT LEAKS THE ENGINES SHUT DOWN COMPLETELY WHILE IN USE. I UNDERSTAND THIS HAS HAPPENED TO MANY, MANY OTHER FORD 3.5L V6 ENGINES. I HAVE THE MY VEHICLE REPAIR RECORDS IF YOU WOULD LIKE TO REVIEW THEM.

WHEN YOU ACCELERATE AT HIGHER SPEEDS IE ON THE FREEWAY THE CAR IS FILLED WITH EXHAUST SMELL.

2014 AWD EXPLORER, 72,405 MI: 12-2019 HEARD SLIGHT GRINDING FR FRONT LEFT & ONLY HEARD WHEN DECELERATING FR APPROX 30 MPH. RECOGNIZED SOUND BECAUSE IT HAPPENED ON FRONT RIGHT 11-2018, 8032 MI EARLIER. BROUGHT IN IMMEDIATELY. SAME PART FAILED AGAIN ON THE RIGHT & NOW ALSO ON THE LEFT FRONT WHEEL & BECAME EMBEDDED IN THE KNUCKLES ON BOTH SIDES, & TECHS COULD NOT REMOVE BEARINGS W/O DESTROYING KNUCKLES. THIS IS THE 3RD WHEEL HUB BEARING THAT FAILED IN THIS CAR. SINCE LAST PART REPLACEMENT 11-2018, FORD REDESIGNED PART DUE TO REPEATED FAILURE. THEY WILL BE REPLACING THE RIGHT & LEFT FRONT HUB BEARINGS W/REDESIGNED PART, HOWEVER, THEY WILL NOT, PAY FOR THE $725 FEE TO REPLACE THE KNUCKLES THAT WERE RUINED & NEITHER WILL MY EXT WARRANTY. IF THE FAULTY HUB BEARINGS DID NOT FAIL, THEY WOULD NOT HAVE CAUSED THE BEARINGS TO SEIZE INTO THE KNUCKLES, THEREBY RUINING THEM AS WELL. FORD CUSTOMER CARE TOLD ME SINCE I AM PAST THE ORIGINAL WARRANTY, THEY WILL NOT CONSIDER ANY COMPENSATION. PEACOCK FORD, MAITLAND, FL SAID THEY WILL FOLLOW FORD'S DIRECTION. NHTSA HAS REPORTS OF WHEELS FALLING OFF FROM THIS. SERVICE MGR AGREES FORD SHOULD PAY BECAUSE HUB BEARINGS CAUSED IT. I OPENED CASE WITH FORD #CAS25112513 & SERVICE MGR ALSO FILED A COMPLAINT WITH FORD ASKING TO COVER THE ADDITIONAL PARTS. A WEEK LATER, NO RESPONSE. I PAID THE $493.43 TO P/U CAR. PEACOCK DIDN'T CHG FOR LABOR. NEED FORD TO COVER ANY ADDITIONAL DAMAGES CAUSED BY FAILURE OF RIGHT & LEFT HUB BEARINGS. PAID: 11-2018 $117.48, & 12-2019 $493.43 = $610.91 TOTAL FOR A REPEATEDLY FAILING PART. FORD MFGD FAULTY PART & KNOWS IT BECAUSE THEY REDESIGNED IT. FORD'S PART CAUSED THE FAILURE OF OTHER PARTS WHICH THEY WOULD NOT COVER. SERVICE MGR AGREES W/ME BUT SAYS HE NEEDS FORD'S AUTHORIZATION. SERVICE MGR., ERIC LANGFIELD: 407-635-8080. FORD CUSTOMER CARE CASE #CAS25112513

2014 AWD EXPLORER, 72,405 MI: 12-2019 HEARD SLIGHT GRINDING FR FRONT LEFT & ONLY HEARD WHEN DECELERATING FR APPROX 30 MPH. RECOGNIZED SOUND BECAUSE IT HAPPENED ON FRONT RIGHT 11-2018, 8032 MI EARLIER. BROUGHT IN IMMEDIATELY. SAME PART FAILED AGAIN ON THE RIGHT & NOW ALSO ON THE LEFT FRONT WHEEL & BECAME EMBEDDED IN THE KNUCKLES ON BOTH SIDES, & TECHS COULD NOT REMOVE BEARINGS W/O DESTROYING KNUCKLES. THIS IS THE 3RD WHEEL HUB BEARING THAT FAILED IN THIS CAR. SINCE LAST PART REPLACEMENT 11-2018, FORD REDESIGNED PART DUE TO REPEATED FAILURE. THEY WILL BE REPLACING THE RIGHT & LEFT FRONT HUB BEARINGS W/REDESIGNED PART, HOWEVER, THEY WILL NOT, PAY FOR THE $725 FEE TO REPLACE THE KNUCKLES THAT WERE RUINED & NEITHER WILL MY EXT WARRANTY. IF THE FAULTY HUB BEARINGS DID NOT FAIL, THEY WOULD NOT HAVE CAUSED THE BEARINGS TO SEIZE INTO THE KNUCKLES, THEREBY RUINING THEM AS WELL. FORD CUSTOMER CARE TOLD ME SINCE I AM PAST THE ORIGINAL WARRANTY, THEY WILL NOT CONSIDER ANY COMPENSATION. PEACOCK FORD, MAITLAND, FL SAID THEY WILL FOLLOW FORD'S DIRECTION. NHTSA HAS REPORTS OF WHEELS FALLING OFF FROM THIS. SERVICE MGR AGREES FORD SHOULD PAY BECAUSE HUB BEARINGS CAUSED IT. I OPENED CASE WITH FORD #CAS25112513 & SERVICE MGR ALSO FILED A COMPLAINT WITH FORD ASKING TO COVER THE ADDITIONAL PARTS. A WEEK LATER, NO RESPONSE. I PAID THE $493.43 TO P/U CAR. PEACOCK DIDN'T CHG FOR LABOR. NEED FORD TO COVER ANY ADDITIONAL DAMAGES CAUSED BY FAILURE OF RIGHT & LEFT HUB BEARINGS. PAID: 11-2018 $117.48, & 12-2019 $493.43 = $610.91 TOTAL FOR A REPEATEDLY FAILING PART. FORD MFGD FAULTY PART & KNOWS IT BECAUSE THEY REDESIGNED IT. FORD'S PART CAUSED THE FAILURE OF OTHER PARTS WHICH THEY WOULD NOT COVER. SERVICE MGR AGREES W/ME BUT SAYS HE NEEDS FORD'S AUTHORIZATION. SERVICE MGR., [XXX]: [XXX]. FORD CUSTOMER CARE CASE #[XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

LOSE OF POWER STEERING IN COLD WEATHER; NEEDS 50 DEGREES OR MORE FOR POWER STEERING TO WORK. NO WARNING LIGHTS WHEN POWER STEERING IS LOST.

2014 EXPLORER CONTINUOUSLY LEAKING COOLANT NEAR FRONT PASSENGER TIRE. DEALERSHIP REFILLED COOLANT AND PERFORMED A PRESSURE TEST AND WAS UNABLE TO DUPLICATE THE PROBLEM. ONE YEAR LATER, THE VEHICLE IS STILL LEAKING COOLANT AND I HAVE TO KEEP ADDING ADDITIONAL COOLANT. I AM CONCERNED THIS IS A WATER PUMP FAILURE AND COST TO REPAIR CAR WOULD BE UPWARD OF 8K

THE ENGINE IS IDLING ROUGHLY ESPECIALLY JUST AFTER I FILL THE GAS TANK. THE FUEL MILEAGE HAS BEEN STEADILY DECLINING EVEN THOUGH I'VE CHANGED THE SPARK PLUGS, COILS, MASS AIR FLOW SENSOR AND AIR FILTER. THE PROBLEM COULD BE A DEFECTIVE FUEL PUMP OR SOMETHING IN THE FUEL SYSTEM. THERE HAVE EVEN BEEN OCCASIONS WHERE THE VEHICLE WON'T START IMMEDIATELY AFTER I FILL THE GAS TANK UNTIL I'VE WAITED A FEW MINUTES.

VEHICLE HAS STRONG FUEL SMELL INSIDE CABIN AT STARTUP BUT THERE ARE NO ENGINE CODES TO CHECK. OTHER YEAR MODELS OF THIS VEHICLE HAVE HAD A RECALL ON THE FUEL SYSTEM LEAKING, BUT NOT YET ON THIS YEAR MODEL AS FAR AS I COULD FIND.

WHILE TRAVELING AT ABOUT 50 MPH ON A 4 LANE HIGHWAY, THE STEERING OF THE CAR BEGAN TO BE UNRESPONSIVE. IN SLIPPERY CONDITIONS I REDUCED THE SPEED AND WAS ABLE TO NEGOTIATE MY RETURN TO HOME. AFTER SHUTTING THE CAR OFF, I RESTARTED AND THE STEERING WHEEL WOULD NOT MOVE AT ALL. WHEN THE CAR WAS BEING LOADED ON THE TOW TRUCK, THE FRONT WHEELS COULD NOT BE STEERED AT ALL. DEALER REPLACED THE STEERING COMPUTER BUT I WAS TOLD THE MECHANICAL STEERING MECHANISM HAD FAILED ALSO. NO ONE WAS HURT OR ACCIDENT OCCURRED, BUT THE CASCADING PROBLEM CREATED A DANGEROUS SITUATION.