2002 FORD EXPLORER SPORT Complaints

WHILE DRIVING AT VARIOUS SPEEDS BLACK SMOKE WOULD CAME FROM THE TAIL PIPE. CONSUMER COULD SMELL GAS FUMES INSIDE THE VEHICLE. .*AK DRIVERS REAR DOOR WILL NOT OPEN FROM THE INSIDE. DRIVERS SIDE SEAT MOLDING IS FALLING OFF. CENTER DUCT LOOSE ON DASH. DRIVERS SEAT CUSHION LOST ITS FORM. *TS

CONSUMER CALLED COMPLAINING ABOUT STALLING PROBLEMS. VEHICLE COMPLETELY SHUT DOWN MORE THAN A DOZEN TIMES WHILE DRIVING AT MORE THAN 40 MPH. MANUFACTURER WAS CONTACTED AND STATED THAT THIS WAS THE FIRST TIME THAT THEY HEARD OF THIS PROBLEM. DEALER WAS CONTACTED, AND VEHICLE HAD BEEN AT THE DEALER FOUR DIFFERENT TIMES, AND THEY STILL COULDN'T FIND WHAT WAS WRONG WITH THE VEHICLE. *AK

CONSUMER RECEIVED RECALL# 03V281000 NOTICE CONCERNING HIGH BACK SEATS. CONSUMER TOOK THE VEHICLE TO THE DEALER WHO KEPT THE VEHICLE ALL DAY. UPON RETURNING TO DEALER TO PICK UP VEHICLE CONSUMER REALIZED THAT DEALER DID NO REPAIRS BECAUSE THE PARTS WERE NOT AVAILABLE.*AK

ENGINE STALLED AT 4683 MILES ON THE ODOMETER. DATE: 7 OCTOBER 2002. I NOTED THAT IT NOW IDLES AT 600 RPM. I DON'T KNOW WHAT THAT MEANS. *JB

FORD EXPLORER SPORT TRAC, 2002. AT 4,122 MI BATTERY LIGHT FLASHED THREE TIMES, AND TRUCK NEARLY STALLED. *JB

THE VEHICLE WAS HARD TO STEER AND CONTROL WHEN IT WAS DRIVEN AT SPEEDS AT AR OVER 70 MPH. THE TECHNICIAN NOTICED THAT THE REAR SWAY BAR LINKS WERE WORN. THE TECHNICIAN REPLACED THE REAR SWAY BARS, REAR SPRINGS AND REAR SHOCKS. *AK *NLM

WHILE DRIVING VEHICLE DIES OUT, BUT WILL RESTART. TOOK VEHICLE TO DEALER, AND THE DEALER REPROGRAMMED THE FUEL SYSTEM. *AK THE FIRST TWO FAILURE, THE VEHICLE STARTED UP IN 3 TO 5 MIN. THE THIRD FAILURE, THE MOST SERIOUS, IT TOOK APPROX. 10 MIN. TO START IN HEAVY TRAFFIC. CONSUMER TOOK TO DEALER. TWO MONTHS LATER, VEHICLE QUIT RUNNING AT 45 MPH. CONSUMER LIMPED HOME AT 5 MPH, LET IDLE FOR 10 MIN. THEN IT RAN FINE AGAIN. *PH

BOUGHT FROM DEALER, USED WITH 15000 MILES. AFTER 300 MILES HAD TO HAVE TRANSMISSION REBUILT (TRANNY WARNING LIGHT AND VIBRATION UNDER ACCELERATION, UPSHIFT 1ST TO 2ND OR 2ND TO 3RD). ONLY HAPPENED OCCASIONALLY. THREE WEEKS AFTER REBUILD NOTICED VIBRATION AT SLOW SPEEDS, BUT COULD NOT REPLICATE ON DEMAND. DEALER COULD NOT REPEAT VIBRATION AND RETURNED IT WITH NO ACTION. ONE WEEK LATER TRANSMISSION WARNING LIGHT ILLUMINATED ON 2 DIFFERENT DAYS. TAKEN TO DEALER FOR EVALUATION TODAY. I'M CONCERNED THAT THERE MAY BE AN INHERENT PROBLEM WITH THE TRANSMISSION

I HAVE BEEN SMELLING ANTI-FREEZE. I JUST NOTICED THAT MY RADIATOR HOSE HAS BEEN RUBBING ON THE OIL FILL AND MADE A NICE BIG HOLE ON THAT SIDE AS WELL AS ON THE OTHER SIDE FROM ANOTHER MECHANISM UNDER THE HOOD. NICE ASSEMBLY. I OWNED MY TRUCK FOR 8 MONTHS NOW.*AK

I OWN A 2002 SPORT TRAC, AT ABOUT 46000 MILES MI TRANSMISSION STARTED TO MISS SHIFTS FROM 2ND TO 3RD GEAR, IT TOOK ABOUT 3 TO 4 SECONDS FOR THE TRANSMISSION TO GET INTO THE NEXT GEAR, SO I TOOK IT TO THE DEALER WHERE I USUALLY HAVE THE TRUCK SERVICED THINKING THAT IT JUST NEEDED A FLUID CHECK DUE TO THE FACT THEY PERFORMED A TRANSMISSION FLUID CHANGE AT ABOUT 30000. WHEN I WENT BACK TO THE DEALER I WAS ADVISED THAT THE TRANSMISSION HAD A PROBLEM ON THE FLUID LINES AND THE TRANSMISSION HAD TO BE TAKEN OUT TO BE REBUILT, SO I ASKED WHY WAS THIS HAPPENING AND THEY STATED THAT THERE WAS A PROBLEM WITH THE GASKETS BEEN WORN OUT INSIDE THE TRANSMISSION. BUT THEY COULDN'T SPECIFY IF THIS WAS A FACTORY PROBLEM OR A OWNER ABUSE PROBLEM, SO WHEN I ASKED IF THERE WAS A TRANSMISSION RECALL BY THE MANUFACTURER (FORD) ON THIS TYPE OF TRUCKS THE ANSWER WAS NO. THEN I WAS ADVISED THAT MY TRUCK WAS OUT OF FACTORY WARRANTY WHICH IS 3 YEARS OR 36000 MILES AND IF I WANTED TO HAVE THE JOB DONE IT HAD TO BE SELF FINANCED, SO I ASKED FOR AN ESTIMATE WHICH WAS ABOUT 18 HOURS LABOR @ $100 P/H AND $500 IN PARTS TOTALING $2300 AND FINALLY AFTER CALLING FORD AND COMPLAINING ABOUT THIS $30000 TRUCK HAVING A FAULTY TRANSMISSION AND GETTING A "YOUR TRUCK IS OUT OF WARRANTY, AND WE DON'T HAVE ANY OTHER TRUCKS WITH THE SAME PROBLEM" I FINALLY PAID THE REPAIRS OUT OF MY POCKET WHICH I PERSONALLY THINK SHOULD NOT BE HAPPENING ON A ALMOST BRAND NEW TRUCK. *JB