2002 FORD EXPLORER SPORT Complaints

WHILE UNLOADING ITEMS FROM BACK I HAD THE HALF GLASS OPEN, AS I WALKED AWAY THE BACK GLASS JUST SLAMMED DOWN AND SHATTERED EVERYWHERE. *TR

WHILE DRIVING MY 2002 FORD SPORT TRAC AT ABOUT 40 MPH,ENGINE SHUT OFF WITHOUT ANY WARNING,JUST A SHAKING FEELING,THEN COMPLETELY SHUT OFF,WHILE IN MOTION. VERY DANGEROUS SITUATION! NO CHECK ENGINE LIGHT CAME ON AND NO CODES WERE PRESENT. I WAS ABLE TO GET OUT OF TRAFFIC AND AVOID BEING HIT. HAD TO CRANK FOR ABOUT HALF A MINUTE AND IT RESTARTED. HAVE DRIVEN ON A DAILY BASIS ABOUT 200 MILES SINCE AND PROBLEM HAS NOT RECURRED AS OF YET.VEHICLE IS WELL MAINTAINED AND UP TO DATE ON FILTERS,ETC... *TR

SEVERE DETERIORATION OF THE BODY MOUNT BUSHINGS TO THE POINT WHERE THEY CRUMBLE WHEN TOUCHED. INFERIOR MATERIAL. *TR

THEY WERE ROTTEN AND FALLING APART, I WAS LOOKING ONLINE AND EVERYBODY HAD THE SAME PROBLEM. THAT SHOULD BE A MANUFACTURED RECALL. IT'S A SAFETY HAZARD. *TR

LIFT GATE WINDOW HINGE BROKE SCRATCHING THE PAINT AND HURTING MY HAND CATCHING IT SO IT WOULD NOT BREAK THE OTHER HINGE. CALLED FORD THE FIRST TIME THIS HAPPEN AND THEY SAY ITS NOT PART OF THE RECALL WHICH I CANT FIGURE OUT SINCE THIS IS THE THIRD TIME THIS HAS HAPPEN TO ME SINCE I'M THE OWNER OF MY 02 EXPLORER SPORT AND FOUND OUT THIS HAPPEN TO THE ORIGINAL OWNER ONCE.SOMETHING HAS TO BE DONE! I RESEARCH THIS ON LINE AND SEE MANY OTHER EXPLORER OWNERS WITH THE SAME PROBLEMS AND THE SAME STORY COME ON LETS DO SOMETHING ABOUT THIS!!!! *TR

WHEN TRYING TO SHIFT CAR FROM DRIVE INTO PARK, THE GEAR SHIFT LEVER BROKE OFF INSIDE THE STEERING COLUMN AND FELL OF IN MY HAND. THE CAR WAS STILL IN DRIVE AND I TURNED OFF THE IGNITION. THE KEY COULD NOT BE REMOVED AND THE CAR WAS TOWED TO THE DEALERSHIP. TO REPAIR THIS LINKAGE PART, THE ENTIRE STEERING COLUMN HAD TO BE REPLACED, AT A COST OF OVER $1800. I CALLED FORD TO REPORT THE INCIDENT AND WAS TOLD THAT THEY HAVE NO RECORD OF SOMETHING LIKE THIS EVER HAPPENING BEFORE. THEY SAID THEY WOULD ADD THE INCIDENT TO THEIR DATABASE. I TOLD THEM THAT I FELT THIS WAS A SERIOUS SAFETY ISSUE AND THAT THIS NEEDS TO BE REFERRED TO ENGINEERING OR QUALITY ASSURANCE FOR INVESTIGATION BEFORE SOMEONE GETS INJURED OR KILLED. I GOT THE IMPRESSION THAT FORD WAS NOT GOING TO DO ANYTHING WITH THIS INFORMATION. *TR

TL* THE CONTACT OWNS A 2002 FORD EXPLORER SPORT TRAC. WHILE DRIVING APPROXIMATELY 30 MPH, THE CONTACT NOTICED THAT THE BRAKE PEDAL WAS PULSATING, ACCOMPANIED BY AN ABNORMAL GRINDING NOISE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN ADVISED THE CONTACT THAT THE FRONT AND REAR BRAKES WOULD HAVE TO BE REPAIRED. AFTER THE REPAIR, THE CONTACT NOTICED THAT THE BRAKE PEDAL WOULD FEEL SPONGY WHEN DEPRESSED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE TECHNICIAN ADVISED THAT TWO OF THE ABS SENSORS WERE FAULTY AND WERE OVERRIDING THE BRAKES. THE MECHANIC DISCONNECTED THE ABS SENSORS. THE CONTACT DID NOT EXPERIENCE ANY FAILURES AFTER THE SENSORS WERE DISCONNECTED. THE APPROXIMATE FAILURE MILEAGE WAS 76,000.

BODY/CHASSIS MOUNTS ARE DETERIORATING AND CRUMBLING. BODY IS NOW LOOSE ON THE FRAME AND HAS SLIGHT MOVEMENT. THESE MOUNTS ARE NOT RUBBER LIKE MOST; THEY ARE SOME SORT OF URETHANE COMPOSITE. INTERNET RESEARCH AND TRUCK OWNER SITES CONFIRM THIS TO BE A COMMON PROBLEM. FORD DOES NOT SEE THIS AS A SAFETY/RECALL ISSUE AND HAS DIRECTED OWNERS OF SUSPECT VEHICLES TO YOUR DEPARTMENT. THIS PARTICULAR VEHICLE HAS NEVER BEEN IN SALT OR SNOW AND HAS ALWAYS BEEN IN NORTH CAROLINA. THE CAB SHAKING AND RATTLING IS CAUSING MOVEMENT THAT WILL UNDOUBTEDLY EFFECT THE BRAKE LINES AND STEERING COLUMN AS THEY ARE ATTACHED TO BOTH THE BODY AND THE CHASSIS. FORD IS NOW USING ANOTHER COMPOUND FOR THE MOUNTS APPARENTLY IN RESPONSE TO COMPLAINTS. *TR

PART# 2L2Z-98420A68-AA HINGE AND ATTACHMENTS FOR LIFTGATE BROKE 08/04-2008. RECALL CAMPAIGN#PE04045-PURCHASED ANOTHER HINGE FROM FORD PARTS DEPT. INVOICE# 216039 ON 08/04/2008-THEY DID NOT TELL ME THERE WAS A RECALL ON THIS PART ITEM- BOUGHT PART AND REPLACED IT MYSELF. 08/26-2012 THE OTHER HINGE BROKE AND CALLED 1-888-327-4226 AND WAS TOLD RECALL WAS OVER- THE FORD STORE NEVER TOLD ME THIS PART WAS RECALLED AND CHARGED ME $43.95. NOW THE OTHER SIDE OF THE HATCHBACK HINGE HAS BROKEN AND HAVE BEEN TOLD I HAVE TO PAY TO GET IT REPAIRED MYSELF AGAIN. NEVER RECEIVED ANY POSTCARD FOR RECALL NOTICE. THIS PART IS DEFECTIVE-BOTH HINGES HAVE BROKEN- I HAVE PAID FOR ONE HINGE AND REPLACED IT MYSELF AND DO NOT THINK I SHOULD HAVE TO REPLACE THE OTHER ONE ALSO AND SHOULD BE PAID THE $43.95 I PAID NOT EVEN COUNTING MY TIME AND LABOR AND FORD SHOULD PAY FOR THE OTHER SIDE SINCE THIS HINGE IS CLEARLY DEFECTIVE. *TR

TL* THE CONTACT OWNS A 2002 FORD EXPLORER SPORT. THE CONTACT STATED THAT THE VEHICLE BODY MOUNT BUSHINGS WERE CORRODED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE BODY MOUNT BUSHINGS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 70,000 AND THE CURRENT MILEAGE WAS 78,000.