2003 FORD EXPLORER SPORT Complaints

I HAVE A BAD PROBLEM ( 2 ) TIMES WITH THE FUEL PUMP THE FIRST ONE WAS SPRAYING GAS OUT TOP EXTERIOR OF FUEL PUMP .MY HUSBAND WENT TO A WRECKING YARD AND PURCHASED A USED FUEL PUMP THAN 5 TO 6 MONTHS LATER DONE THE SAME THING SPRAYING OUT TOP EXTERIOR ELBOW OF FUEL PUMP. I USE MY TRUCK TO TAKE MY DAUGHTER BACK AND FORTH TO SCHOOL AND IT IS A VERY DANGEROUS CAUSE THE FUMES WERE REALLY BAD INSIDE OF CAB AND PLUS IF SOME ONE WAS TO THROW A CIGARETTE OR ANYTHING THAT COULD IGNITE THE LEAKING GAS . I THINK THAT THIS MATTER SHOULD BE FIXED CAUSE I KNOW THAT I AM NOT THE ONLY ONE THAT HAD OR HAS THIS PROBLEM AND NOT TO SAY ALL OF THE OTHER THINGS THAT ARE WRONG LIKE MY HIGH BEAMS NOT WORKING THE FRONT DOOR WINDOW IS VERY SLOW GOING UP AND DOWN AND THE BACK DOOR ( PASSENGER RIGHT SIDE ) BLOW MOTOR AND ECT. THE BIG ONE IS THE FUEL PUMP I FELL THAT THIS IS THE WORST AND IT SHOULD BE FIX BEFORE SOMEONE GETS BADLY HURT OR KILLED. *JB

SEVERE CLANKING/BANGING NOISE IN PASSENGER REAR. REPLACED SHOCKS. NOISE WORSENED. RESEARCHED AND FOUND NUMEROUS COMPLAINTS REGARDING BODY MOUNTS WITH FORD EXPLORER SPORT VEHICLES. UPON INVESTIGATION - REACHING UP UNDER VEHICLE FOUND NO "BODY INSULATOR LEFT ON PASSENGER SIDE REAR AND ON DRIVER REAR THE INSULATOR CRUMBLED LIKE DIRT AND FINE POWDER. THE BODY MOUNTS APPEARED TO BE MANUFACTURED OF A FOAM LIKE MATERIAL - SUBSTANDARD AT BEST! REPLACEMENT PARTS MUST BE PURCHASED THROUGH FORD SINCE NO OTHER AFTERMARKET PARTS ARE AVAILABLE. PARTS ONLY (THAT BEING ABLE TO SALVAGE THE BOLTS AND SLEEVES) AND PURCHASE THE TWO PAIR OF INSULATORS ONLY - $680.00. THE SAME MATERIAL THAT FAILED AND SHOULD NOT. THERE ARE VEHICLES ON THE ROAD WITH BODY MOUNTS FOR 40 TO 50 YEARS. THIS IS A MANUFACTURER'S RESPONSIBILITY AND THE COST FOR THESE PARTS IS THIEVERY. IT IS UNSAFE TO OPERATE A VEHICLE WITHOUT REPAIRING DEFECTIVE BODY MOUNTS DUE TO THE POSSIBILITY OF BODY ROLL OR OTHER LOSS OF CONTROL. SINCE THE MOUNTS SHOULD NOT FAIL THROUGHOUT THE LIFE OF THE VEHICLE I SINCERELY REQUEST AN INVESTIGATION BE LAUNCHED INTO THE MULTIPLE COMPLAINTS BEING FILED FOR THE YEARS 2001-2003 FORD EXPLORER SPORT BODY MOUNTS. *TR

REAR LIFT GATE PANEL CRACKED WHILE VEHICLE WAS PARKED. CONCERNS WITH UNSTABLE REAR GLASS, ABILITY OF HATCH TO REMAIN CLOSED AND OPERATION OF REAR WIPER. GLASS INSTABILITY A CONCERN WHILE DRIVING AND WHEN USING LIFTGATE. PRIOR INJURIES HAVE BEEN REPORTED. *TR

TL* THE CONTACT OWNS A 2003 FORD EXPLORER SPORT. THE CONTACT STATED THAT HE NOTICED THAT THE REAR LIFT GATE HINGES WERE LOOSE AND THE CONTACT WAS CONCERNED THAT THE REAR GLASS WINDOW WOULD FALL FROM THE VEHICLE. THE VEHICLE WAS NOT INSPECTED BY A DEALER OR AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS CONTACTED AND ADVISED HIM THAT THE VEHICLE WAS NOT INCLUDED IN A MANUFACTURER'S RECALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNAVAILABLE. THE CURRENT MILEAGE WAS APPROXIMATELY 153,000. *TR

THE FORD EXPLORER SPORT HAS SERIOUS ELECTRICAL PROBLEMS. *REAR BRAKE LIGHT WOULD NOT TURN OFF AND CAUSED MY BATTERY TO DRAIN. TOOK IT TO THE SHOP AND THEY STATED THIS IS A KNOWN PROBLEM WITH FORD EXPLORERS, THAT THE BRAKE LIGHT SWITCH THAT THE CAR HAS IS DEFECTIVE. THE MECHANIC ACTUALLY STATED THAT THEY STOPPED MAKING THAT KIND OF BRAKE LIGHT SWITCH, SO THEY HAD TO ORDER A NEW KIND OF BRAKE LIGHT SWITCH. BECAUSE THE MECHANIC'S STATEMENT, THIS INFORMED ME THAT FORD IS AWARE OF THE BRAKE LIGHT SWITCH THAT CAME WITH THE CAR IS DEFECTIVE. *DOOR AJAR LIGHT SOMETIMES COMES ON FOR NO REASON WHEN ALL DOORS ARE FULLY CLOSED, AND THEN TURNS OFF ON IT'S OWN AFTER A COUPLE DAYS. I CALLED FORD AND THEY STATED THIS SOMETIMES HAPPENS AND I NEEDED TO GREASE THE DOOR LATCHED AND CLEAN THE RUBBER LINING ON THE DOORS. I DID ALL THIS AND IT STILL HAPPENS SOMETIMES. I'VE SEEN COMPLAINS ABOUT THIS ONLINE TOO. THIS IS DANGEROUS BECAUSE NOW WHEN THE DOOR AJAR LIGHT COMES ON PEOPLE MAY IGNORE THINKING IT'S THE REGULAR GLITCH, WHEN IT COULD POSSIBLY BE AN OPEN DOOR ONE DAY. *POWER DOOR AND POWER WINDOW MOTOR CONSTANTLY GOES OUT EACH YEAR. I HAVE HAD THIS REPAIRED THREE TIMES NOW. THIS IS ALSO DANGEROUS BECAUSE IN AN EMERGENCY PASSENGERS CAN'T EXIT A WINDOW IF NEEDED. *TR

2/14/2007 I NOTICED THERE IS A FRACTURE/CRACK BETWEEN THE TAILGATE DOOR OPENER AND THE WINDOW. THE FRACTURE/CRACK BECOMES MORE/LESS WIDER DEPENDING ON HOW HOT OR COLD IT IS OUTSIDE. I WENT TO THE DEALER AND THEY STATED IT WOULD CAUSE ME BETWEEN $400-$800 TO GET IT FIX AND THE WHOLE AREA WILL NEED TO BE REPLACED. THEY STATED THAT IT SHOULD NOT CAUSE MUCH PROBLEM UNLESS SOMEONE HITS THE BACK OF MY CAR OR I CLOSE THE TAILGATE NOT SOFT ENOUGH, WHICH COULD DAMAGE THE WINDOW. SINCE THEN, I HAVE NOTICED THAT ALL EXPLORERS THAT I SEE HAVE THE SAME FRACTURE/CRACK ON THE TAILGATE DOOR ON THE SAME AREA LOCATION. I ALSO HAVE SEEN MANY MANY MANY COMPLAINTS ABOUT THIS ONLINE. THIS HAS TO BE A DEFECT THAT IS CAUSING THE FRACTURE ON THE TAILGATE DOOR BELOW THE WINDOW. THIS COULD CAUSE INJURY IF THE WINDOW BREAKS OR THERE IS ISSUE WITH THE DOOR OPENER HINGE. *TR

AS I WAS DRIVING THE SUN VISOR DROPPED, AND STARTED TO DANGLE AND SWING TOWARDS MY FACE. IT STARTLED ME AND I SWERVED THE CAR A LITTLE, TRIED TO DODGE THE VISOR FROM HITTING ME IN THE FACE/HEAD, AND THEN PULLED INTO A PARKING AREA. I NOTICED THE SUN VISOR HINGE HAD CRACKED AND THE WIRING CAME LOOSE. I TOOK IT TO THE FORD DEALER QUICK LANE AND THEY STATED IT WOULD COST ME BETWEEN $120-$250 DEPENDING ON THE COLOR AND IT WOULD NEED TO BE REWIRED DURING INSTALLATION. THIS COULD CAUSE SOMEONE TO HAVE AN ACCIDENT OR INJURY, AND THERE IS NO REASON THIS PART SHOULD OF BROKEN LIKE THIS. *TR

SITTING AT A STOP SIGN VEHICLE WENT INTO ACCELERATION GAS PEDDLE WENT TO FLOOR. FOOT WAS ON THE BRAKE. CHECKED NO CARPET STUCK UNDER THE GAS PEDDLE. FOOT WAS NOT TOUCHING GAS PEDDLE. IT WAS ALMOST LIKE THE CRUISE CONTROL WAS PRESSING THE GAS PEDDLE. CRUISE CONTROL WAS OFF. SHUT VEHICLE OFF THEN BACK ON ISSUE WENT AWAY. THIS HAS HAPPENED OTHER TIMES TO MYSELF AND MY WIFE. SOMETIMES WHILE PUSHING THE GAS THE GAS PEDDLE LEAVES YOUR FOOT AND CONTINUES TO THE FLOOR ON ITS OWN, PRESSING THE BRAKE AND TURNING VEHICLE OFF SEEMS TO RESOLVE THE ISSUE. THIS ISSUE HAPPENS SO IN FREQUENTLY THAT IT IS HARD TO REPRODUCE FOR SERVICE SHOP. *TR

I HAVE HAD FUEL TANK ISSUES FOR A YEAR NOW AND THEY ARE GETTING WORSE. MY GAUGE STOPPED WORKING ABOUT 13 MONTHS AGO WHICH WAS NO BIG DEAL. NOW I AM UNABLE TO PUT MORE THEN 4-5 GALLONS OF GAS IN AT A TIME. THE SAFETY SENSOR STOPS THE PUMP FROM FILLING UP MY TANK AND IF I TRY TO DO IT A LITTLE AT A TIME IT JUST SHOOTS GAS OUT OF MY FILL AREA AND GETS EVERYWHERE. I HAVE BEEN DOUSED IN GAS AND I HAVE RUN OUT OF GAS IN VERY BAD AREAS. THE SENSOR REPLACEMENT WAS ONLY A TEMPORARY FIX, NOW IT'S IMPOSSIBLE TO PUT GAS IN MY TANK AND IT'S STARTING TO RUN POORLY. I HAVE TO STOP EVERYDAY FOR GAS. THIS IS A MALFUNCTIONING FORD PART THAT SHOULD BE RECALLED AND REPLACED. I HAVE RUN OUT OF GAS AND WHEN THAT HAPPENS EVERY THING SHUTS DOWN INCLUDING THE POWER STEERING. IT WAS DANGEROUS AND DIFFICULT TO MANEUVER MY TRUCK, I WAS GETTING ON THE FREEWAY AND THE ON RAMP WAS A SEMI-CIRCLE. *JS

TL* THE CONTACT OWNS A 2003 FORD EXPLORER SPORT TRAC. WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE ABNORMALLY DECELERATED TO 40 MPH. IN ADDITION, THERE WAS SMOKE COMING FROM THE FRONT END OF THE VEHICLE. THE CONTACT WAS INFORMED BY ANOTHER DRIVER THAT SPARKS WERE COMING FROM UNDER THE VEHICLE. THE CONTACT MANEUVERED THE VEHICLE TO THE SHOULDER AND DISCOVERED THAT THERE WERE FLAMES UNDER THE DRIVER'S SIDE OF THE VEHICLE. THE FIRE DEPARTMENT WAS CALLED AND A FIRE REPORT WAS FILED. THE VEHICLE WAS TOWED TO A TOW YARD AND WAS NOT REPAIRED. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE MILEAGE WAS 182,000.