2002 FORD EXPLORER SPORT TRAC Complaints

AFTER MAKING ABRUPT STOP HALF MILE BEFORE INCIDENT TO AVOID ACCIDENT, I CAME TO A STOP AT A STOP SIGN. WHEN I WENT TO ENTER A MAIN HIGHWAY, MY TRANSMISSION SLIPPED AND LEFT ME NON MOBILE IN THE INTERSECTION, ALMOST CAUSING ME TO GET HIT BROADSIDE. HAD TO GET OUT IN TRAFFIC TO PUSH MY VEHICLE OFF HIGHWAY. MANY EXACT TRANSMISSION PROBLEMS FOR THIS VEHICLE ALREADY POSTED ON INTERNET I SEE. VERY DANGEROUS. *TR

TRANSMISSION PROBLEM. O/D LIGHT BLINKING. TRANSMISSION INSTANTLY STARTED TO SLIP IN 3RD GEAR UNDER ACCELERATION. OVER 8,000 COMPLAINTS LISTED BUT FORD SAYS THAT IS NOT ENOUGH FOR RECALL. THIS TRANSMISSION HAS A HISTORY OF PROBLEMS, THAT CAN CAUSE MAJOR PROBLEMS WHILE DRIVING. BIGGEST ONE IS LOSE OF ACCELERATION IN TRAFFIC. THIS TRANSMISSION HAS A LENGTHY BAD HISTORY. IT IS THE 5R55 SERIES TRANSMISSION, STARTING WITH THE FAULTY SOLENOID PACK. IF YOU LOOK AT THIS TRANSMISSIONS HISTORY, YOU WILL FIND THE SAME COMPLAINTS ABOUT IT OVER AND OVER AGAIN, SLIPPING WHILE IN GEAR FAILURE TO SHIFT, O/D LIGHT BLINKS THEN GOES OUT, TRANS FAILING AT 50,000M, 60,000M. I AM ON MY SECOND PAIR OF TIRES AND THE TRANSMISSION IS FAILING. I DRIVE LESS THAN 8700 MILES PER YEAR AND MAINTAIN MY VEHICLE VERY WELL. THIS TYPE OF FAILURE SHOULD NOT HAVE OCCURRED. I THINK FORD IS AWARE OF THE PROBLEM BUT REFUSES TO DO ANYTHING ABOUT IT TILL THEY WILL BE FORCED TO DO SOMETHING. *TR

THE BODY MOUNT INSULATORS DETERIORATED AND THE BODY COULD COME LOOSE FROM THE CHASSIS. FORD WANTS OVER 3000 DOLLARS FOR THIS REPAIR WHICH IS AN OBVIOUS MATERIAL FLAW. *TR

WHILE DRIVING MY 2002 FORD SPORT TRAC AT ABOUT 40 MPH,ENGINE SHUT OFF WITHOUT ANY WARNING,JUST A SHAKING FEELING,THEN COMPLETELY SHUT OFF,WHILE IN MOTION. VERY DANGEROUS SITUATION! NO CHECK ENGINE LIGHT CAME ON AND NO CODES WERE PRESENT. I WAS ABLE TO GET OUT OF TRAFFIC AND AVOID BEING HIT. HAD TO CRANK FOR ABOUT HALF A MINUTE AND IT RESTARTED. HAVE DRIVEN ON A DAILY BASIS ABOUT 200 MILES SINCE AND PROBLEM HAS NOT RECURRED AS OF YET.VEHICLE IS WELL MAINTAINED AND UP TO DATE ON FILTERS,ETC... *TR

SEVERE DETERIORATION OF THE BODY MOUNT BUSHINGS TO THE POINT WHERE THEY CRUMBLE WHEN TOUCHED. INFERIOR MATERIAL. *TR

THEY WERE ROTTEN AND FALLING APART, I WAS LOOKING ONLINE AND EVERYBODY HAD THE SAME PROBLEM. THAT SHOULD BE A MANUFACTURED RECALL. IT'S A SAFETY HAZARD. *TR

TL* THE CONTACT OWNS A 2002 FORD EXPLORER SPORT TRAC. WHILE DRIVING APPROXIMATELY 30 MPH, THE CONTACT NOTICED THAT THE BRAKE PEDAL WAS PULSATING, ACCOMPANIED BY AN ABNORMAL GRINDING NOISE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN ADVISED THE CONTACT THAT THE FRONT AND REAR BRAKES WOULD HAVE TO BE REPAIRED. AFTER THE REPAIR, THE CONTACT NOTICED THAT THE BRAKE PEDAL WOULD FEEL SPONGY WHEN DEPRESSED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE TECHNICIAN ADVISED THAT TWO OF THE ABS SENSORS WERE FAULTY AND WERE OVERRIDING THE BRAKES. THE MECHANIC DISCONNECTED THE ABS SENSORS. THE CONTACT DID NOT EXPERIENCE ANY FAILURES AFTER THE SENSORS WERE DISCONNECTED. THE APPROXIMATE FAILURE MILEAGE WAS 76,000.

BODY/CHASSIS MOUNTS ARE DETERIORATING AND CRUMBLING. BODY IS NOW LOOSE ON THE FRAME AND HAS SLIGHT MOVEMENT. THESE MOUNTS ARE NOT RUBBER LIKE MOST; THEY ARE SOME SORT OF URETHANE COMPOSITE. INTERNET RESEARCH AND TRUCK OWNER SITES CONFIRM THIS TO BE A COMMON PROBLEM. FORD DOES NOT SEE THIS AS A SAFETY/RECALL ISSUE AND HAS DIRECTED OWNERS OF SUSPECT VEHICLES TO YOUR DEPARTMENT. THIS PARTICULAR VEHICLE HAS NEVER BEEN IN SALT OR SNOW AND HAS ALWAYS BEEN IN NORTH CAROLINA. THE CAB SHAKING AND RATTLING IS CAUSING MOVEMENT THAT WILL UNDOUBTEDLY EFFECT THE BRAKE LINES AND STEERING COLUMN AS THEY ARE ATTACHED TO BOTH THE BODY AND THE CHASSIS. FORD IS NOW USING ANOTHER COMPOUND FOR THE MOUNTS APPARENTLY IN RESPONSE TO COMPLAINTS. *TR

THE BODY MOUNTS ON THE VEHICLE ARE DESINTEGRATING. I TOUCHED IT WITH MY HAND AND IT FELL APART. BODY MOUNTS SHOULD LAST MUCH LONGER. *TR

WHILE DRIVING, THE DRIVERS SEAT RECLINED INTO THE BACK SEATING AREA CAUSING LOSS OF CONTROL OF THE VEHICLE. AFTER PULLING OFF THE ROAD AND INSPECTING THE SEAT, THE FRAME OF THE DRIVERS SEAT FRACTURED CAUSING THE BACKREST TO SEPARATE FROM LOWER PORTION OF THE SEAT AND OVERRIDE THE RECLINER HANDLE. *TR