2003 FORD EXPLORER SPORT TRAC Complaints

TL* THE CONTACT OWNS A 2003 FORD EXPLORER SPORT TRAC. WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE ABNORMALLY DECELERATED TO 40 MPH. IN ADDITION, THERE WAS SMOKE COMING FROM THE FRONT END OF THE VEHICLE. THE CONTACT WAS INFORMED BY ANOTHER DRIVER THAT SPARKS WERE COMING FROM UNDER THE VEHICLE. THE CONTACT MANEUVERED THE VEHICLE TO THE SHOULDER AND DISCOVERED THAT THERE WERE FLAMES UNDER THE DRIVER'S SIDE OF THE VEHICLE. THE FIRE DEPARTMENT WAS CALLED AND A FIRE REPORT WAS FILED. THE VEHICLE WAS TOWED TO A TOW YARD AND WAS NOT REPAIRED. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE MILEAGE WAS 182,000.

TL* THE CONTACT OWNS A 2003 FORD EXPLORER SPORT TRAC. THE CONTACT STATED THAT THE DRIVER'S SIDE REAR BODY MOUNT FRACTURED AND WAS PROTRUDING THROUGH THE BOTTOM OF THE CAB. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSIS BUT WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 70,000. . UPDATED 04/11/12 *BF UPDATED 04/30/12

BODY MOUNTS PREMATURELY DETERIORATING AND CRUMBLING. BODY RIDES LOOSE ON FRAME, WHICH CAN IMPACT SAFETY OF THE VEHICLE AND HANDING IN AN ACCIDENT. ALL BODY MOUNTS FOR THE CAB OF THE VEHICLE HAVE FAILED AND FALL APART TO THE TOUCH. SINCE THIS VEHICLE IS A BODY ON FRAME DESIGN, FAILED BODY MOUNTS CANNOT KEEP THE CAB FIRMLY ATTACHED TO THE FRAME OF THE TRUCK. APPARENTLY THE RUBBER MATERIAL USED WAS DETECTIVE. *TR

ENGINE & MULTIPLE PARTS IN 2003 FORD ARE NOT 2003, THEY ARE 2001 & 2002. 2002 ENGINE AND EARLIER HAD A TSB FOR THE TIMING CHAIN GUIDES & OILING. EVEN THOUGH TAKEN INTO THE DEALERSHIP WITH THAT COMPLAINT, MINE WAS SUPPOSED TO BE 2003, NOT AFFECTED BY THOSE PROBLEMS, SO SERVICE DID NOT REPAIR FOR TSB. LATER ON TIMING JUMPED BECAUSE GUIDES NOT REPLACED, BENT VALVE AND RUINED THE ENGINE TO TUNE OF $5,000, PLUS PARTS SPENT TO GET TO THAT POINT & RENTAL CARS. SHOULD BE NOTED THE FIRST REPLACEMENT MOTOR INSTALLED BY FORD RAN ONLY 15 MINUTES BEFORE IT BLEW FROM TIMING CHAIN DEFECT/POOR MANUFACTURING. HISTORY: BEFORE END OF 75,000 MILE EXTENDED WARRANTY I TOOK THE SPORT TRAC INTO THE DEALER TO TAKE CARE OF ALL THE LITTLE COMPLAINTS. ONE COMPLAINT WAS SLIGHT RATTLE TYPE OF SOUND WHEN THE CAR WAS COLD/COLD MORNING. DEALER SUGGESTED AN ENGINE FLUSH & TO SWITCH TO FULL SYNTHETIC OIL. THAT DID HELP FOR SEVERAL THOUSAND MILES. ENGINE RATTLE CAME BACK, ONLY VERY OCCASIONAL BUT WORSE SOUND THAN BEFORE ON REAL COLD MORNINGS. WAS COASTING TOWARD RED LIGHT, LIGHT CHANGED & I GAVE IT GAS, ENGINE STARTED MISSING SEVERELY AS I TOOK OFF W/CHECK ENGINE LIGHT COMING ON. LIMPED THE CAR HOME. PUT CODE READER ON & STARTED REPLACING PARTS CALLED FOR, MOSTLY TUNE UP, THEN EGR COMPONENTS, ETC., NEW CODE THROWN AFTER EVERY REPAIR. SMOG PARTS FOR 2003 DID NOT FIT, I HAD TO TAKE THE PARTS BACK & EXCHANGE THEM FOR 2001. WHEN ENGINE WAS CHANGED SERVICE REP TOLD ME ENGINE IN CAR WAS 2002, EVEN HAD TO REPLACE THERMOSTAT HOUSING BECAUSE ROUTING WAS DIFFERENT, ANGLE INCORRECT, NOT 2003, I TOOK PICTURES OF BLOCK & #'S, NOT A 2003, IT IS 2002 (PICTURES SHOW MY ENGINE, NO DIRT ACCUMULATION AT ALL). CARB STATES I CANNOT INSTALL AN ENGINE OLDER THAN THE CHASSIS INTO THE CAR, MOST ESPECIALLY OLDER SMOG COMPONENTS. CAN FORD? CAN FORD SELL A CAR AS NEW, SPECIFIC MODEL YEAR, BUT USE LEFTOVER PARTS FROM PREVIOUS YEARS & STILL CALL IT A NEW CAR? ISN'T THIS FRAUD? HOW CAN VEHICLE BE REPAIRED, TSBS FOLLOWED, ETC.? *TR

TL* THE CONTACT OWNS A 2003 FORD EXPLORER SPORT TRAC. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START. THE CONTACT ALSO STATED THAT SHE ATTEMPTED ON SEVERAL OCCASIONS TO START THE VEHICLE WHILE DEPRESSING THE ACCELERATOR PEDAL, BUT IT WOULD NOT START. THE VEHICLE WAS TOWED TO A LOCAL REPAIR SHOP, WHO DIAGNOSED THAT THE FUEL PUMP WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE CONTINUED. THE CONTACT STATED THAT THE FUEL PUMP WAS REPLACED A TOTAL OF FOUR TIMES WITHIN THE PAST SIX MONTHS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE AND REFERRED THE CONTACT TO NHTSA. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 82,500 AND THE CURRENT MILEAGE WAS 82,600.

2003 FORD EXPLORER SPORTRAC, INTERMITTENTLY BRAKE PEDAL GOES TO FLOOR, PEDAL VIBRATES, UNABLE TO STOP. NO ACCIDENT YET BUT VERY SCARY SITUATION. SCHEDULED TO HAVE DEALER INSPECT ON 8/8/2011. THIS HAS HAPPENED SEVERAL TIMES. NO ERROR CODES ON VEHICLE DIAGNOSTICS. THIS COULD CAUSE A SERIOUS ACCIDENT!! *TT

TRANSMISSION WENT OUT AT 89,000 MILES. THIS IS THE SECOND FORD I'VE HAD THAT THE TRANSMISSION WENT OUT AT 89,000. I HAVE ALSO HAD SEVERAL BRAKE ISSUES THAT FORD REFUSED TO ADDRESS AFTER EXTENDED WARRANTY EXPIRED. *TR

IT STARTED WITH HUMMING VIBRATING NOISE IN THE FRONT END LEFT TIRE ENDING WITH FRONT WHEEL BEARING FAILURE AND SMALL FIRE TO THE WHEEL BEARING RUBBER BOOT AND HARD PULLING TO THE LEFT TOO DANGEROUS TO DRIVE THIS IS A MAJOR MECHANICAL FAILURE AFTER INSPECTING I FOUNT THAT ONLY THE ONE NUT WAS HOLDING TIRE ON. *TR

WHEN I PULL DOWN MY STEERING WHEEL, THE LEFT BLINKER DOES NOT WORK NEITHER DOES THE BRAKE LIGHTS. IF THE WHEEL IS UP EVERY THING WORKS. *TR

AFTER DRIVING SEVERAL MILES WITHOUT INCIDENT, I PULLED INTO TRAFFIC AND ACCELERATED TO ABOUT 45 MPH THEN LET UP ON PEDDLE BUT VEHICLE CONTINUED TO ACCELERATE. TO BRING IT UNDER CONTROL I HAD TO TURN THE IGNITION OFF AND AT THAT POINT, LOST POWER STEERING AND SOME BRAKES. I HAD CAR TOWED TO LOCAL DEALER AND HAVE NOT YET HEARD FROM THEM. *TR